Build Procedure
420.00 –
420.06mm
If these measurement
are out of spec then Ensure that the grease
please report to Sandvik nipple holes and the
before proceeding lifting holes are clean
from debris.
Sandvik Mining and Construction
Shaft Assembly
209.85mm
209.75 -
240.00mm
280.09mm
239.89 –
280.06 –
If these measurement are out of spec
then please report to Sandvik
Engineering and Quality department
before proceeding
Serial Number
Part Number
Location face
Bottom step
Non-Drive side
bearing housing
Part # J4170000
Part # Description
J4260000 Tall Tooth
J4710000 Corrugated 13%
J2960000 Corrugated 18%
J5790000 Square
When fitting the swing jaw plate it is imperative that the recesses
in the Swing jaw plate locate on the Key of the Jaw stock as failure
to do so will cause the plate to fall off
Compression
Disk Washer Part
Disk Part #
# J3990000
SC1006 x 4
Sandvik Mining and Construction
Crusher Mainframe Assembly
M48 Nut
To fit the Ram Spigot Part # J4520000 first clean and de-grease
Then apply stud lock to the face shown and insert into the mainframe on
the L/H and R/H side with the pin facing into the mainframe
Tighten onto the mainframe using M48 nut and torque to 3200N/M
Base Bracket
J4450000
Sleeve
J5080000
Sandvik Mining and Construction
Fixed Jaw Plate Fitment
Bearing
BT6001
Ram
HR1050
Circlip
FAW78IC
Location Pin
Circlip
FAW36XC
Sandvik Mining and Construction
Clamp rams
Circlip
Ensure the bearing housings pass the mainframe and then guide onto
the location point as shown
Use a bar in the bearing housing fixing hole to line up all of the bolt
holes ready for fixing
4 hydraulic
washers
Ram HR1090
Before fitting the toggle
rams Part # HR1090 you
must first fit link arm
bearing Part BT3009 # & Bearing
bearing BT6006 BT3009
Bearing BT6006
Sandvik Mining and Construction
Toggle Jaw Bracket
Lift the toggle ram assembly into position and ensure the correct orientation of the
ram assemblies (see below) and secure in place with Circlip Part # FAW36XC
The ram ports should be facing upwards
L/H assembly
R/H L/H
R/H assembly
assembly assembly
M24bolt and
With the toggle rams in washer
place you can now mount
the Toggle Plate Tie Bar
Part # J5390000 along
with Support Bush Part #
J5370000 hold I place with Tie Bar
an M24 flat washer and J5390000
M24x80 bolt
Leave this loose do not Bush
tighten J5370000
Before fitting the toggle plate you will need to lift the jaw stock to give
you enough room
To do this lower a suitable chain down into the chamber and place
the hook into the bottom of the swing jaw as shown
Now raise the crane until the jaw stock has pivoted around enough
With the toggle plate in place attached the Toggle Tie bar on
to the “Y” bracket with a M24x80 (10.9) bolt along with M24
flat washer and Spacers Bush Part # J5370000
Then torque to 979 N/M on all 4 of the Tie Bar bolts
Spacer J4550000
Spacer J4550000
Tighten in place
Tie Bar