Anda di halaman 1dari 2

TECHNICAL REGULATION TB4092

Technical Regulation
REQUIREMENTS FOR SURFACE TEXTURE ON
Approved by TOOTH FLANKS FOR CYLINDRICAL Introduced
GEARSECO
Anders Absér 465461
Issued by Checked 1 Checked 2 Info class Status Approved Date Page
Frank Tomaselli sssaaq sssers I S 2010-02-08 1 (2)
No. of classified requirements, STD3944 <C>; <M>; No. of regulations, STD4178 <L>;

Technical Regulation
REQUIREMENTS FOR SURFACE TEXTURE ON TOOTH
FLANKS FOR CYLINDRICAL GEARS

Contents Page

1 Introduction .............................................................................................1
2 Field of application ..................................................................................1
3 Requirements..........................................................................................2
4 Appurtenant documents..........................................................................2
5 Changes .................................................................................................2

1 Introduction

In cylindrical gears the tooth flanks are exposed to very high mechanical
stresses. It is essential to have appropriate functional requirements for the
surface texture in order to fulfil acceptance criteria.
This Technical regulation includes all cylindrical gears at Scania.

2 Field of application

The document shall be applied when referred to on gear data drawing or any
other normative document.

N.B. The copyright and ownership of this document including associated computer data are and will remain ours.
They must not be copied, used or brought to the knowledge of any third party without our prior permission.
© Scania CV AB, Sweden

SV 1744 01-06 (2006-11-16)


TECHNICAL REGULATION TB4092
Technical Regulation
REQUIREMENTS FOR SURFACE TEXTURE ON
Issued by TOOTH
Checked 1 FLANKS
Checked 2 FOR CYLINDRICAL
Info class Status GEARS
Approved Date Page
Frank Tomaselli sssaaq sssers I S 2010-02-08 2 (2)

3 Requirements

The following table states the requirements on the flanks of cylindrical gears.

Level Ra Rz -0,8/Rmr0 5/Rmr(1) -0,8/Rmr0 5/Rmr(3) -0,8/Rmr0 5/Rmr(5)


max max minimum value minimum value minimum value

TB4092-A * 2,5 14 - 25% 50%

TB4092-B* 1,6 9 - 40% -

TB4092-C* 1,1 6,5 15% 75% -

TB-4092-D* 0,8 4,5 30% 95% -

* Measuring in profile direction when the machining texture is in lead


direction, for example broaching and grinding.
In remaining cases the measuring is in lead direction.

4 Appurtenant documents

Standard STD4261.
Standard EN-ISO 4288

5 Changes
ECO
Change number Section Change description Date Sign. Pho.

N.B. The copyright and ownership of this document including associated computer data are and will remain ours.
They must not be copied, used or brought to the knowledge of any third party without our prior permission.
© Scania CV AB, Sweden

SV 1744 01-06

Anda mungkin juga menyukai