A shunt reactor is connected in parallel with a transmission line or other load. A series
reactor is connected between a load and source.
Bus reactors
A bus reactor is a type of air core inductor, or in some cases, oil filled, connected between
two buses or two sections of the same bus in order to limit the voltage transients on either
bus. It is installed in a bus to maintain system voltage when the load of the bus changes. It
adds inductance to the system to offset the capacitance of the line which varies due to
load, humidity, weather, generator excitation and temperature.
Line reactors
A line reactor is placed in line at the point of use or just after a transformer to maintain a
stable amperage to the user. When a line is disconnected from the system, the line
reactor is also disconnected from the system. Line reactors are often used to compensate
line capacitance, mitigate voltage transients due to switching, and to limit fault currents,
especially in case of underground transmission lines.
A bus reactor and a line reactor are interchangeable as long as they are rated for the
same voltage which is dependent upon substation's physical layout, and bus
configuration.
Shunt reactors
Shunt reactors are used in power systems to counteract the effect of the line parasitic
capacitance, thereby stabilizing the system voltage within acceptable limits. For short
lines, we can basically ignore the impact of capacitive current from a voltage regulation
point of view, but medium and long lines can have voltages at their receiving end much
higher than the sending end, thus creating issues such as over-fluxing of power
transformers and over stressing of line insulators. Under light-load conditions, the line
produces more VARs, resulting in receiving end voltage being higher than sending end
voltage. In order to consume the excess VARs when system is lightly loaded, an inductor
is added to the system. Since inductors absorbs VARs, a reactor is connected in parallel
with shunt capacitance of the line known as Shunt Reactor,
Series reactors
Series reactors are used as current limiting reactors to increase the impedance of a
system. They are also used for neutral earthing. Such reactors are also used to limit the
starting currents of synchronous electric motors and to compensate Reactive Power in
order to improve the transmission capacity of power lines.
References
[1] [2]
1. http://www.onegrid.com.au/wp-content/uploads/2012/03/BR-EN-TH07-11_2004-
Series_Reactors_and_Voltage_Control.pdf
2. https://www.eiseverywhere.com/file_uploads/1ab4d67dd86dae934ff4ed4f96e79400_fi
s2_pap.pdf