com/wiki/GPON_module_basic_test_examples
1 of 5 31/08/2018 10:46
GPON module basic test examples - MikroTik Wiki https://wiki.mikrotik.com/wiki/GPON_module_basic_test_examples
Adtran TA-5000)
To verify your Adtran TA-5000 is able to detect if the Mikrotik SFP GPON module is connected to
your GPON network
Note - the serial-number "MKTK0c150621" indicates the Adtran TA-5000 does see the Mikrotik SFP
GPON module.
2 of 5 31/08/2018 10:46
GPON module basic test examples - MikroTik Wiki https://wiki.mikrotik.com/wiki/GPON_module_basic_test_examples
show remote-device ont 2@1/20/1.gpon note: Replace the 2@1/20/1.gpon part of the command with your
configuration You should something similar to the following:
I will later edit and add more information for how to configure the Adtran and Mikrotik (when I figure it
out). North Idaho Tom Jones
I am now able to confirm the that I was able to get a Mikrotik GPON SFP module (inserted into a Mikrotik
2011UiAS-2HnD running 6.37.3) to work in my ISP GPON network. My head-end to the GPON networks
are Adtran TA-5000 units (System Release 08.05.01.02).
I suspect there may be more than one way to configure everything... Here is what I did:
This is a CLI show run from my Adtran TA-5000 showing the parts of the Adtran configuration to make the
Mikrotik GPON module work:
3 of 5 31/08/2018 10:46
GPON module basic test examples - MikroTik Wiki https://wiki.mikrotik.com/wiki/GPON_module_basic_test_examples
. . . edit (added additional information) ... Feb 24 2017 North Idaho Tom Jones - I have been able to
successfully test the Mikrotik GPON module installed in a Mikrotik to my Adtran TA-5000 using the
following configurations:
A very interesting possibility for use could be where a single GPON module equipped Mikrotik may be able
to function as a Multi-Dwelling multi-Residential-Gateway device and support something similar to SubH.
To do this, configure the Mikrotik on a Vlan on talking to your Out-Of-Band SubH network. Then add some
MetaRouter virtual routers to your Mikrotik where each virtual Mikrotik is uniquely dedicated to each
dwelling. Thus it is possible to make a single Mikrotik act as if it were multiple routers where each virtual
router is isolated. This may be cost effective compared to other GPON multi-dwelling solutions. North
Idaho Tom Jones
Calix B6 Series
4 of 5 31/08/2018 10:46
GPON module basic test examples - MikroTik Wiki https://wiki.mikrotik.com/wiki/GPON_module_basic_test_examples
5 of 5 31/08/2018 10:46