concerning the protection of waters against pollution caused by nitrates from agricultural sources
Fertiliser Plan
(Nitrates Derogation)
PPSN:
Name:
Address:
County:
Signature:
(of applicant)
NB: Your Fertiliser Plan should be sent to the Department with your 2011 Nitrates Derogation Application
form unless you have an approved REPS 4 plan in place OR had an approved 2010 Nitrates Derogation
Application.
The Fertiliser Plan must be available on your holding by 1st March each year. You must revise the Fertiliser Plan no
later than seven days following any changes in agricultural practices.
You must keep the Fertiliser Accounts up to date. After the end of the current calendar year, the completed Fertiliser
Accounts must be submitted to:
Nitrates Section, Department of Agriculture, Fisheries &Food, Johnstown Castle Estate, Co. Wexford
The Fertiliser Accounts, along with all receipts, dockets and invoices, must be submitted by 31 st March of the
following year.
1
FERTILISER PLAN
Table 1 - Total Nitrogen and Phosphorus produced by grazing livestock on your holding
A
Projected production of Nitrogen
Table 2 - Total Nitrogen and Phosphorus produced by non- grazing livestock on your holding
2
*Identify straw-bedded houses
Note: Free board must be deducted for all storage tanks Total Capacity
200mm for covered tanks
300mm for open tanks
* Identify straw-bedded houses
Total Capacity
3
Table 6 – Estimate of annual phosphorus fertiliser requirement
Soil Sample 1 CROP 2 Field or LPIS Plot Number Soil Sample 3 Area Actual Soil P Index4 Crop Requirement Total
Identification in Ha kg available P /ha Available P/Plot
(all land farmed) kg
1
You are required to provide soil analysis if available, in any event the results of a soil analysis must be provided at least once in every 4 years.
2
Please indicate whether winter or spring crop
3
Subject to (1) above at least one analysis per 5 hectares shall be required
4
Assume Index 3 where no valid soil test result available
4
Table 7 - Estimate of annual nitrogen fertiliser requirement
Soil Sample1
Identification CROP2 Field and/or LPIS Plot Soil Sample3 Area in Ha N Index Crop Requirement Total Available N/Plot
(As per Table 6) Number (tillage crops only) kg available N/ha kg
Additional Notes
You are required to provide soil analysis if available, in any event the results of a soil analysis must be provided at least once in every 4 years.
2
Please indicate whether winter or spring crop
3
Subject to (1) above, at least one analysis per 5 hectares shall be required
5
ORGANIC Fertiliser (Livestock manure derived from housing) CHEMICAL Fertiliser
LPIS/ Crop Nitrogen Phosphorus
Soil sample CROP2 Field Area TYPE3 Available N Available P Organic
identificatio No (ha) from organic from organic fertiliser Chemical Total Chemical Total
fertiliser fertiliser (M3 or litres or N Chemical P Chemical
n2
(As per table 6) (kg/ha) (kg/ha) tonnes/ha) (kg/ha) N (kg/ha) P
Please state (kg) (kg)
units used
In the case of soiled water please specify suitable fields and method of application:
2
You are required to provide soil analysis if available, in any event the results of a soil analysis must be provided at least once in every 4 years.
2
Please indicate whether winter or spring crop
3
Describe the type of organic fertiliser to be applied e.g. cattle slurry, FYM etc
6
Prepared by
I/we certify that the Fertiliser Plan set out herein for ____________________________________ conforms in all respects to the requirements
laid down for the Nitrates Derogation.