Adjust footstand
Procedure
The Cisco Unified IP Phone 3905 has a foldable footstand. Unfold the footstand to give the phone an elevated
viewing angle.
Cisco Unified SIP Phone 3905 Administration Guide for Cisco Unified Communications Manager 10.0
1
Cisco Unified SIP Phone Accessories
Install Phone on Wall Mount Plate
The following figure shows a list of items required to mount the Cisco Unified SIP Phone
Cisco Unified SIP Phone 3905 Administration Guide for Cisco Unified Communications Manager 10.0
2
Cisco Unified SIP Phone Accessories
Install Phone on Wall Mount Plate
Procedure
Step 1 Plug the telephone line cord (RJ45 connector) into the phone jack at the base of the phone as shown in the
following image:
2 RJ45 Connector
Cisco Unified SIP Phone 3905 Administration Guide for Cisco Unified Communications Manager 10.0
3
Cisco Unified SIP Phone Accessories
Install Phone on Wall Mount Plate
Step 2 Plug the RJ45 connector into the wall mount phone jack as shown in the following image:
Step 3 Slip the mounting holes on the base of the wall mount plate and over the wall mount pins as shown in the
following image:
Cisco Unified SIP Phone 3905 Administration Guide for Cisco Unified Communications Manager 10.0
4
Cisco Unified SIP Phone Accessories
Adjust the Handset Rest
Step 4 Firmly slide the IP phone down into place as shown in the following image:
Cisco Unified SIP Phone 3905 Administration Guide for Cisco Unified Communications Manager 10.0
5
Cisco Unified SIP Phone Accessories
Adjust the Handset Rest
Procedure
Step 1 Remove the handset from the cradle and pull the plastic tab from the handset rest.
Step 2 Rotate the tab 180 degrees.
Step 3 Hold the tab between two fingers, with the corner notches facing you.
Step 4 Line up the tab with the slot in the cradle and press the tab evenly into the slot. An extension protrudes from
the top of the rotated tab.
Step 5 Return the handset to the handset rest.
Cisco Unified SIP Phone 3905 Administration Guide for Cisco Unified Communications Manager 10.0
6