Anda di halaman 1dari 6

What safety precaution is infrequently used to eliminate or Electron flow detection systems

lessen the probability of large amounts of static electricity


when filling above ground flammable storage tanks? NFPA 77

What are the first symptoms of frostbite? “pins and needles” sensation followed by numbness

What is the maximum burst pressure required for LPG Hoses? 1250 psig

What is not considered a major type of machine guard within Swing away
general industry?

Minimum riser height and maximum tread width, in inches, 6 ½; 11


for fixed industrial steps recommended by OSHA and ANSI
What type of aerosols is a problem associated with arc Fluorides; nickel and chromium
welding of stainless steel?

Pressure testing is generally considered to be a potentially Destructive-stringent safety precautions need to be followed
what type of test??

What types of voltage and current characterize static High voltages and very low current values
electricity?

What is the most economical way to protect an elevated Cathodic protection


water tank from the damaging effects of corrosion?

Inspection of wire rope for lifting or hoisting does not include Interlay of chock wires
what?
But it does include the following:

Wear of crown wires


Lubrication
kinking
What NFPA standard does private fire brigades fall under? NFPA 600

What does not require an equipment grounding conductor? Double insulated hand tool

Which of the following is the standard material used in chain Alloy steel chain
slings used for moving and lifting material in industry?

According to the Commercial Motor Vehicle Safety Act of Single vehicle with a GVW of 26,000lbs.
1986, a CDL is required for what operation??

According to OSHA HAZ Com; who has the responsibility to The manufacturer or importer of the chemical
determine if a material is hazardous?
Define ergonomics? Design the job to fit the person

What technique provides the largest margin of safety when Provide separate entrance/exits that favor right hand turns
designing a large parking lot that feeds a busy arterial
roadway?

What analysis technique where individuals are interviewed Critical incident technique
about accidents, near misses and hazardous conditions is?

What is the prime or initial event in event tree analysis called? The initiating event

Describe single point failure? A single failure will seriously affect the safety of the system
What is not true about Failure Modes and Effects Analysis FMEA does not identify multiple failures, human factors and
(FMEA) interfaces

Heinrich’s 1930’s famous domino theory of accidents? Social, fault, unsafe act, accident, injury

Heinrich’s ratio of no injury accidents, to minor injuries, to 300-29-1


major injuries?

Heinrich’s principle in the way safety professionals viewed Shifted emphasis from conditions to actions.
the cause of certain mishaps?

What is not true concerning establishment of management Management goals should be published
goals for the occupational safety and health program?

Anda mungkin juga menyukai