INDICATIONS
Indications of a scavenge fire are loss in power and irregular running of the engine, high exhaust temperatures of
corresponding units, high local temperature in scavenge trunk, surging of turbocharger, and sparks and smoke
emitted from scavenge drains. External indications will be given by a smoky exhaust and the discharge of sooty
smuts or carbon particles. If the scavenge trunk is oily the fire may spread back-from the space around or adjacent to
the cylinders where the fire started and will show itself as very hot spots or areas of the scavenge trunk surfaces. In
ships where the engine room is designed as UMS, temperature sensors are fitted at critical points within the scavenge
spaces. activation would cause automatic slow down of the engine.
ACTION
If a scavenge fire starts two immediate objectives arise- they are to contain the fire within the scavenge space of the
engine and to prevent or minimize damage to the engine. The engine must be put to dead slow ahead and the fuel
must be taken off the cylinders affected by the fire. The lubrication to these cylinders must be increased to prevent
seizure and all scavenge drains must be shut to prevent the discharge of sparks and burning oil from the drains into
the engine room. A minor fire may shortly burn out without damage, and conditions will gradually return to normal.
The affected units should be run on reduced power until inspection of the scavenge trunking and overhaul of the
cylinder and piston can be carried out at the earliest safe opportunity. Once navigational circumstances allow it, the
engine should be stopped and the whole of the scavenge trunk examined and any oil residues found round other
cylinders removed. The actual cause of the initiation of the fire should be investigated
PREVENTION
To prevent scavenge fires good maintenance and correct adjustment must be carried out. Scavenge trunking must be
periodically inspected and cleaned and any buildup of contamination noted and remedied. The drain pockets should
also be cleaned regularly to remove the thicker carbonized oil sludges which do not drain down so easily and which
are a common cause of choked drain pipes. Scavenge drains should be blown regularly and any passage of oil from
them noted. The piston rings must be properly maintained and lubricated adequately so that ring blow-by is
prevented. At the same time one must guard against excess cylinder oil usage. With timed cylinder oil injection the
timing should be periodically checked. Scavenge ports must be kept cleared
The piston-rod packing rings and scraper rings should also be regularly adjusted so that oil is prevented from
entering the scavenge space because of butted ring segments. This may and does occur irrespective of the positive
pressure difference between the scavenge trunk and the crankcase space.
Fuel injection equipment must be kept in good condition, timed correctly, and the mean indicated pressure in each
cylinder must also be carefully balanced so that individual cylinders are not overloaded.
If cylinder liner wear is up to maximum limits the possibility of scavenge fires will not be materially reduced until
the liners are renewed