We Make Cameras
product catalog
www.videologyinc.com
Design
Develop
Manufacture
2
IP/ETHERNET
IP/ETHERNET 4
Cameras ~ Domes ~ Servers
USB/PHOTO
ID BADGING
CAMERAS
USB/PHOTO ID BADGING CAMERAS 15
CAMERAS
DOME
DOME CAMERAS 20
CAMERAS
HOUSED
CCTV HOUSED CAMERAS 26
CCTV
CMOS & CCD
CAMERAS
BOARD
CMOS & CCD BOARD CAMERAS 35
MONITORS
MODULES
MONITORS & MODULES 45
LENSES
LENSES 49
ACCESSORIES
SUPPLIES
POWER
POWER SUPPLIES/ACCESSORIES 54
3
IP/ETHERNET H.264 IP/Ethernet
Server Board
60SVM Features
• Advanced H.264, level 4.1 high profile video
compression
• 42mm x 42mm server board
• Up to 2 megapixels @ 30fps • 4 Audio channels in/out
- HDMI - Optional AAC encoding
- 1080p in/out • Power over Ethernet
• Up to 5 megapixels @ 12fps • Wireless capability
• Digital or composite video in • Record to a hard drive or SD card
• Up to 4 video streams in/out 30fps • SDK
- 1 1080i H.264/MJPEG
- 3 D1 H.264/MJPEG
- or various Mix 1 720p, 1 D1, 1 CIF
POE Board
42mm x 42mm • USB
(24VAC & POE) • RS232
60PBPOE • RS485
• GPIOs
Up to 10
Communication
Board
SD Card Interface
60C1200
Optional Hard Drive
70M04GB 4GB SD Card
70M08GB 8Gb SD Card
4
H.264 IP/Ethernet Domes
IP/ETHERNET
Visit www.videologyinc.com to see our
upcoming range of H.264 domes.
5
IP/ETHERNET IP/Ethernet Video
Server board
60SV12VA Features
• Single channel miniature 38mm board
• Development I/O board supports SD card
with ERS coding
• Composite video single stream in
- Ethernet out (MJPEG/MPEG4)
- Composite video out
• Software upgradable via USB or FTP
• Motion detection of 96 independent blocks with 5 levels of sensitivity
• Security for 4 users with 3 levels of authority
• Time/date stamp enabled
• Optional SDK available
60SV12VA
Network & Serial NTSC PAL JP2 female JP2 male
6
IP/Ethernet Color
IP/ETHERNET
Network Camera
20/21N758 Features
• Video recording at the edge - acts as a
remote server or DVR. No data loss via ERS
• Motion-JPEG and MPEG4 streaming with
audio
• Superior image quality from progressive scan CCD (up to 30fps)
• Built-in motion detection
• Analog BNC output for easy installation
• Built-in web server and network interface
• USB interface
Technical Specifications
Environmental
50mm (1.97”)
SD CARD
Operating Temp 5°C ~ 50°C (41°F ~ 122°F)
Operating Humidity Max. 80% RH
Storage Temp 0°C ~ 60°C (32°F ~ 140°F)
Storage Humidity Max. 85% RH
Mechanical
Dimensions W x H x D 62mm x 50mm x 95mm (2.44” x 1.97” x 3.74”)
62mm (2.44”)
95mm (3.74”) Weight 306g (0.67 lbs)
Lens Mount CS
IRIS USB
Alarm I/O 1 alarm in/1 alarm out, 1 reset
Connectors Power 1.3mm barrel jack
Video BNC
1. AES Ethernet RJ-45 jack
2. DC IRIS USB 5 pin mini B
3. DHCP
4. STATIC IP
Input/outputs DB-9
(RS-485, RS-232, alarms, audio)
ALC RESET POWER LAN
Software
Included IP recording application software (SecureView), for
Electrical 20N758 (NTSC) / 21N758 (PAL) SFT-07025 up to 16 cameras
Viewer Operating Windows 2000, Windows XP SDK (Optional) Software Development Kit available to system
System(s) SFT-07020-SDK integrators
Viewer Browser(s) Internet Explorer 6.x or above Minimum System Intel Pentium 1.5 GHz processor or above
Network Protocol(s) TCP/IP, DHCP, HTTP, UDP, SNTP, ICMP, DDNS, Requirements (2.8 GHz or higher recommended)
DNS, UPnP, PPPoE 128-MB RAM at least
Network Type Ethernet (RJ-45 wired, 10/100base-TX), MDIX (256-MB or higher recommended)
support Windows 2000, XP or above
Video Compression MPEG 4 & M-JPEG (5 levels) selectable 4 MB VGA card capable of 24-bit true color display
Security Supports 10 users (3 levels of security) 100 MB free hard-disk space for software installa-
Password protection available tion
Trigger Motion detection, alarm in In the multi-channel recording mode, the HD data
External Storage Slot for SD memory card 8Gb (max) transfer rates must be 66MB or above (100MB or
Image Sensor ¼” Sony Wfine VGA progressive scan CCD higher recommended)
Resolution 640 x 480 10/100 Base-TX network for LAN operation
Signal to Noise Ratio >48dB Microsoft Internet Explorer 6 or above
Sensitivity 0.75 lux Accessories
Gain AGC (selectable via ALC POT) Included Power Supply 5VDC
White Balance AWB (software controlled) Cable USB 2.0
White Balance Range 2700 - 6300K Optional SD Card 4GB – 70M04GB
Shutter Speed 1/30 – 1/27,000 8Gb – 70M08GB
Frame Rate 30 frames/sec. (max) @ 640 x 480 Note: SDHC Class 6 SD cards required
Iris Controls Electronic shutter/DC iris Supported by
Video Output 1Vp-p composite, 75 ohms
Power Input 5VDC (24VAC to 5VDC
via optional converter – 60PBIP5)
Power Consumption 3W max
LED Indicators Power and Ethernet Safety Standards
Audio Function Line level - 16bit, 8KHz sample rate FCC, CE
7
IP/ETHERNET Single Channel
Video Server
With Built-in SD Card
60SV12VA-B Features
• Video recording at the edge - acts • Time stamp & text overlay
as a remote server or DVR. No • Pan tilt zoom control, RS485
data loss via ERS
• I/O supports advanced motion
• SD files are guaranteed NO DATA
• Detection in independent zones
LOSS when continuously over-
with 5 sensitivity levels
written with ERS firmware
• Supports encryption
• Converts analog cameras to IP
addressability • Supports 10 users with 3 levels of
authority
• Supports MJPEG/MPEG 4 stream-
ing with audio • Compact metal box size fits easily
in remote areas
• 10/100 baseT Ethernet
• Adjustable image size, bit-rate &
quality
Technical Specifications
32mm
110mm 60mm
60SV12VA-B Environmental
Network & Serial NTSC PAL Operating Temperature 0°C ~ 50°C (32°F ~ 122°F)
Network Protocol(s) TCP/IP, DHCP, HTTP, SNTP, DDNS, UPnP, Storage Temperature -20°C ~ 60°C (-4°F ~ 140°F)
FTP, SMTP, PPPoE, SMTP, ARP, ICMP Operating Humidity 30% ~ 80%
Viewer Operating Windows 2000, Windows XP MTBF 135,000
System(s)
Mechanical
Viewer Browser(s) Internet Explorer 6.x or Netscape Navigator 7.x
Dimensions (L x W x H) 110mm x 60mm x 32mm
Network Type Ethernet (RJ-45 wired, 10/100 base-TX), (4.33” x 2.36” x 1.25”)
MDIX support
Weight 260g (9.17 oz)
Network API Supported with SDK
Alarm I/O 1 alarm in/1 alarm out, 1 reset
Network Capabilities Live/rec./play/PTZ camera control/system
Alarm Notice GPIO output & SD, FTP, SMTP recording
setup
Connectors RS485, audio
Network Throughout 2.0 Mb/sec, 2.0 Mb/sec,
30 frames @ 704x480 25 frames @ 704x576 Software
Web Server Access 8 simultaneous users Included SFT-07025 IP recording application software (SecureView)
Remote Access Software Microsoft Internet Explorer or Client Optional SFT-07020-SDK SDK available to system integrators
Minimum System Intel Pentium 1.5 GHz processor or above
Serial Port RS-485
Requirements (2.8 GHz or higher recommended)
USB USB slave 1.1 128-MB RAM at least (256-MB or higher recommended)
USB Download rate < 1Mb Supported by
Windows 2000, XP or above
Video/ Electrical 4 MB VGA card capable of 24-bit true color display
Video Compression M-JPEG / MPEG4 (dual modes) 100 MB free hard-disk space for software installation
Video Input 1.0Vp-p, 75 ohms (BNC unbalanced) In the multi-channel recording mode, the HD data
transfer rates must be 66MB or above (100MB or
AGC Range: 0.5 ~ 2.0Vpp
higher recommended)
Chrominance: 0.286Vpp, +/- 2db
10/100 Base-TX network for LAN operation
Color sub-carrier lock range: +/- 200H
Microsoft Internet Explorer 6 or above
Video Output Level 1.0Vpp +/-10%, 75Ohm (BNC unbalanced)
Video Output Frequency -3dB +/-1dB at 3 MHz (30 fps, best recording) Accessories
Video Output Burst Level 286mv +/- 10% or vector +/- 10 Included Power Supply 5VDC
Compression Picture Pixels 704 x 480, 704 x 240, 704 x 576, 704 x 288, Cable USB 2.0
352 x 240 352 x 288 Optional SD Card 4GB – 70M04GB
Video Fine Tune Control Contrast, brightness, hue, saturation 8Gb – 70M08GB
Display Refresh Rate 60 fps 50 fps Note: SDHC Class 6 SD cards required
Compression Resolution 720 x 480 (full) 720 x 576 (full) Safety Standards
Audio Function 16bit, 8KHz sample rate FCC, CE, RoHS
Power Input 12VDC 200mA
Power Consumption 3W
8
Extended Recording
IP/ETHERNET
System (ERS)
20N758
ERS Features
• Proprietary file system for Videology’s
network camera family
• Continuous, uninterrupted recording of
looped video
• Guaranteed no data loss 260SV12VA-B
• Special firmware that overcomes limitations of FAT based systems by
creating large, contiguous files of the maximum permissible size.
• 8GB SD card capable (16GB card coming soon)
• Motion Detection (MJPEG Quality)
• Time date stamped
Technical Specifications
When an i-NETSTREAM camera or server with ERS is
installed it acts as a remote server or DVR. It does not
Electrical SD-Card
need to be installed on a network; it can record Video Structure FAT12/FAT16/FAT32 protocols
independently. Card Size 8GB max
Card Type SDHC Class 6 or above pre-formatted by the
Panasonic SD card format utility
With ERS there is no need to cable back to the head-end
Image Source Motion-JPEG
for sensitive and special monitoring needs. Data can be
Frame Rate 1 FPS (max) for continuous recording
stored and secured separately, without worrying about 0.5FPS
head-end tampering. ERS allows for an expedited 0.25 FPS
0.125 FPS
playback process rather than sorting through multiple Event Triggering Motion detection
DVR files, eliminating the complication and cost of a DVR Digital alarm input/Network alarm input
and associated labor altogether. Network disconnection
Schedule
Limitations Class 6 SD card or above
SD cards in other cameras record only short video clips in Single user access via network during recording
response to motion triggers and cannot record with Remote Access Yes (via authorized user)
The MJPEG files may be played back with any standard player using Videology’s ERS utility SD card. SDHC
Class 6 SD cards or higher are required.
Videology’s i-NETSTREAM IP camera model 20N758 and server 60SV12VA-B comes loaded with Extended-
Recording System (ERS) firmware at no extra charge. The competitively priced products are cost-effective
components of a larger network surveillance system, allowing for maximum flexibility.
9
IP/ETHERNET 5” Color Outdoor IP
Dome With WDR
DW59WI Features
• WDR (wide dynamic range)
>102dB
• Power over Ethernet, 24VAC auto • GPIO port
detect
• 1 way audio
• MJPEG / MPEG 4 compression
• Motion detection
• 3-Axis wall or ceiling mountable
• Time/date stamp enabled
• IP 66 rated
Technical Specifications
Connectors DW59WI W/Base W/ Optional Wall Mount Arm
(78V0020) (78V0019)
Ethernet/POE Ø140.1mm
Ø85.9mm
Audio In
67.9mm
117mm
USB Reset
50mm
Alarm Power
Ø100mm
DW59WI Environmental
Network & Serial NTSC PAL Operating Temp -20°C ~ 55°C (-4°F ~ 131°F)
Network Protocol(s) TCP/IP, DHCP, HTTP, UDP, SNTP, ICMP, DDNS, Storage Temp -20°C ~ 70° C (-4°F ~ 158°F)
DNS, UPnP, PPPoE
Viewer Operating Windows 2000, Windows XP
System(s) Mechanical: Cast Aluminum Housing
Viewer Browser(s) Internet Explorer 6.x or above Weight 1.4kg (3lbs) dome & base only
Network Type Ethernet (RJ-45 wired, 10/100 base-TX), Alarm I/O 1 alarm in/1 alarm out, 1 reset
MDIX support Connectors Power 24VAC Flying leads
Network API Supported with SDK Power over Ethernet RJ-45 jack
Network Capabilities Live / record / play /system setup Ethernet RJ-45 jack (same as P.O.E.)
Network Throughout 2.4 Mb/sec, 2.4 Mb/sec, 5-pin mini B USB
30 fr @ 704x480 25 fr @ 704x576 Video assist cable BNC (inside dome)
Web Server Access Up to 8 simultaneous users Input/outputs Quick disconnect
Remote Access Software Microsoft Internet Explorer or Client Tamper Resistant Torx head
Video Compression MPEG 4 & M-JPEG (5 levels) selectable Screws
Security 1 administrator and up to 7 users Bubble: Hardened Slotted black Standard
Password protection available Polycarbonate
Triggers Motion detection & alarm in/out Lens 4-9mm DC auto iris
USB Interface for IP address setup
NVR Software
Video/ Electrical Included IP recording software (SecureView) See INS-60SV12VA
Image Sensor 1/3” CMOS Digital Pixel System® SFT-07025
Active Pixels (HxV) 742 x 552 Supported by
Resolution 480TVL
Sensitivity 0.6 lux @ 30 IRE (F1.2)
Operating System NTSC/PAL selectable
Dynamic Range 120dB(max), 102dB (typical) Certifications RoHS Compliant, CE, & FCC
Signal To Noise Ratio 48 dB or more
Auto White Balance On / Off
Gain AGC max on / off
Accessories
Included 78V0020 - surface mount base for flush mount
Iris Control DC iris
Torx head screws with wrench
Video Output 1Vp-p composite 75 Ohms
Optional 78V0019 - wall mount arm
Power Supply 12VAC – 28VAC 50/60Hz, POE auto detect
Power Consumption < 6W
Audio 1 way line level audio in Optional Models
Requires external microphone & preamplifier DW59WI-P PAL preset equivalent version
10
5” Color Indoor /
IP/ETHERNET
Outdoor IP Dome
DW59I/DW59I-P Features
• 1/3” 540TVL CCD sensor
• Power over Ethernet, 24VAC auto
detect • GPIO port
• MJPEG / MPEG 4 compression • Motion detection
• 3-Axis wall or ceiling Mountable • Time/date stamp enabled
• IP 66 rated • 1 way audio
Technical
Connectors
Specifications
DW59I W/Base
(78V0020) (78V0019)
Ethernet/POE Ø140.1mm
Audio In Ø85.9mm
67.9mm
117mm
USB Reset
50mm
Alarm Power
Ø100mm
11
IP/ETHERNET 5” Color IP Dome
With SD Card Slot
D59SI/D59SI-P Features
• Power over Ethernet
• 12VDC/24VAC
• Video recording at the edge - acts • Motion detection of 96 independent
as a remote server or DVR. No data blocks with 5 levels of sensitivity
loss via ERS • Security for 4 users with 3 levels of
(refer to ERS application note) authority
• Composite video in Ethernet out • Time/date stamp enabled
(MJPEG/MPEG4) • Optional SDK available
• 3-axis wall or ceiling mountable
• Software upgradeable via SD card
or FTP
Technical Specifications
Environmental
Operating Temp 0°C ~ 50°C (32°F ~ 122°F)
Storage Temp -20°C ~ 70° C (-4°F ~ 158°F)
12
Single Channel
IP/ETHERNET
Video Server
With Serial & PTZ Control
SV11A-M4 Features
• MPEG 4 streaming with audio
• 10/100 baseT Ethernet
• Adjustable image size, bit-rate & quality
• Time stamp & text overlay
• Pan tilt zoom control, RS232, RS485
• 3 motion detection windows & I/O
Technical Specifications
LEDs
1 Network Tx/Rx
2 Heartbeat
122.9mm (4.84”)
3 Status
50mm (1.97”)
Video Audio
Connectors
1 DI+ Input
(Max. 50mA, 12VDC)
2 DI- Input
3 SW_COMMON Output
4 SW_NOPEN Output
5 RS485 B (-)
72.3mm (2.85”) 6 RS485 A (+)
SV11A-M4 Environmental
Electrical NTSC PAL Operating Temperature 0°C ~ 50°C (32°F ~ 122°F)
Viewer Operating Microsoft Windows 98 SE, ME, NT4.0, Operating Humidity 95% RH
System(s) 2000, XP
Viewer Browser Internet Explorer 5.0 or above
Mechanical
Server System RAM 16MB SDRAM
Dimensions (L x W x H) 122.9mm x 72.3mm x 50mm
ROM 2MB Flash ROM (4.84” x 2.85” x 1.97”)
Network Protocol UpNP, TCP/IP, HTTP, SMTP, FTP, Telnet, NTP, Weight 380g (0.84 lbs)
DNS, DDNS, CHCP
Serial Connectors 9 pin D-SUB RS232
Network Type 10 or 100 baseT fast Ethernet, auto adjusting
Modem PPP (dial-up, direct cable connection)
Modem Support PTZ exclusive Software
Video Modulation NTSC / PAL auto selectable PTZ Supported Protocols Pelco D
Video Resolution Max. 704 x 480 Max. 704 x 576 via Com Port Sony VISCA
Frames Per Second 30 fps at 176 x 120 25 fps at 176 x 144 Cannon’s VC-C1, VC-C3, VC-C4
30 fps at 352 x 240 25 fps at 352 x 288 Cohu
10 fps at 704 x 480 10 fps at 704 x 576 Dynacolor Dynadome
Video Compression (Mode) MPEG4 (short header) Alarm 1 Input Motion detection with percentage
Audio Capacity 24 kbps 1 Relay Out & sensitivity
3 color images per camera for
Power Supply 12VDC, 1.5A
pre-/postalarm
Power Consumption <4.5 Watts Automatic transfer of stored
I/Os 1 optical isolated 12VDC Max 50mA images via email of FTP
1 relay 24VDC 1A, 12.5VAC 0.5A SFT-06004 16-channel IP recorder software
Safety Standards
FCC, CE
13
IP/ETHERNET Four Channel Video
Server
SV42-MJ Features
• 4 analog camera inputs
• Built-in web server
• Intelligent motion detection • Video stream
- 30/25 fps for single input
• IPPP dial-in and dial-out via external
- 6 fps for quad
modem
• Pre & post alarm snapshots
• Adjustable network bandwidth
• Supports different speeds in
• Remote pan tilt zoom control
playback mode
• Flexible integration interface
Technical Specifications
Front Back
40mm (1.6”)
160mm (6.3”)
SV42-MJ Environmental
Electrical NTSC PAL Operating Temperature 0°C ~ 50°C (32°F ~ 122°F)
Viewer Operating Microsoft® Windows 98 SE, ME, NT4.0, Operating Humidity 95% RH
System(s) 2000, XP, Linux, Unix, Mac OS
Viewer Browser Internet Explorer 5.x or above
Netscape Navigator 4.x or above
Mechanical
Dimensions (L x W x H) 160mm x 146mm x 40mm (6.3” x 5.7” x 1.6”)
Server System RAM 32MB SDRAM
Weight 820g (1.8 lb)
ROM 4MB Flash ROM
Connectors 9 pin D-SUB, RS232 or RS485
Network Protocol TCP/IP, HTTP, SMTP, FTP, Telnet, NTP,
DNS, DDNS, DHCP, UpnP, PPPoE
Network Type 10baseT or 100baseT Fast Ethernet Software
Modem PPP (dial-up, direct cable connection) PTZ Supported Protocols Pelco D-protocol
Modem Support PTZ exclusive via Com Port Sony VISCA protocol
Video Inputs 4 BNC video inputs with 75 Ohms Cannon’s VC-C1, VC-C3, VC-C4
Video Resolution/ Speed 30 fps at 176 x 112 25 fps at 176 x 144 CGI command serial driver is supported
30 fps at 352 x 240 25 fps at 352 x 288 Alarm 4 Input Motion detection with percentage
10 fps at 704 x 480 10 fps at 704 x 576 & sensitivity
15 fps for quad 4 Relay Out Automatic transfer of stored
Video Compression (Mode) MJPEG images via e-mail or FTP with
Power Supply 12VDC event-triggered actions
Power Consumption 8W SFT-TBD IP recording software
I/Os 4 sensor inputs (max 12VDC 50mA)
4 relay outputs (24VDC 1A, 12.5VAC 0.5A) Safety Standards
FCC, CE
14
USB Photo Cameras for Identity
Systems
USB/PHOTO
ID BADGING
CAMERAS
Secure ID Border Patrol
Visitor Management Passports
Enrollment Driver’s Licenses
USB, High Resolution Color Camera for Photo Identity Systems 20/21K758USB-SYS
• CCD sensor provides optimal image quality
• All-digital design uses camera board’s digital BT656 output for input to USB board
• Still image capture with streaming video
• Flexible gooseneck arm allows for easy camera control
• Small footprint saves table space
• Megapixel and flash options
• USB 2.0 bus provides power and camera control
• Software Development Kit available
• Software
» WDM device drivers digital certification under Windows XP and Vista
» DirectX compliant
» TWAIN compliant
15
CMOS USB 2.0, 1.3
Megapixel Sensor
Color Board Camera
USB/PHOTO
ID BADGING
CAMERAS
24C1.3XUSB Features
• Progressive scan, 1.3 megapixel sensor
• 7.5fps at full 1280 x 1024 resolution
uncompressed
• Simplified cabling - video, power & full camera control over a single USB cable
• WDM driver, TWAIN, DirectX compatible
• Support for Windows XP, Windows Vista, & Windows 7 operating systems
• Complete SDK available
• I2C control available
Technical Specifications
J1 Pin Outs
22mm (0.87”)
1 GND
2 GND
3 GND
4 Data Positive
5 Data Negative
6 +5VDC
16
USB 2.0 CCD Board
Camera Family
With Microsoft Certified Drivers
USB/PHOTO
ID BADGING
CAMERAS
20/21K1XXUSB-C Features
• 1/4” IL CCD
• CCD iris
• Power consumption <1.3W
• Power supply 5VDC +5% not polarity protected
• Viewer display
USB 2.0, 30fps 720 x 480 pixels (NTSC)
USB 2.0, 720 x 576 pixels (PAL)
USB 1.1, 30fps 320 x 240 pixels
• Camera controls via USB bus software:
• Gamma • Back light compensation
• Gain • White balance mode (color only)
• Mirror mode • 14 fixed shutter speeds
• Interlaced/non interlaced • Contour enhancement
Technical Specifications
26.0 20K14XUSB-C Back Board 20K13XUSB-C / 20K15XUSB-C
3.8 9.2 9.2
4.0
Ø2.0
2 plcs.
17.2 Top 8.0
1.5
Back Board
Top
4.0 4.3
1.4 .9 1.2
4.0 J1
5 GND
1.8 2.1
6 GND
typ. typ. 4.0
Environmental Software
Operating Temperature -15° C ~ 55° C (5° F ~ 13° F) Viewer • WDM device drivers
SFT-07019 • DirectX compliant
Operating Humidity 20 up to 93%RH
• TWAIN compliant (requires driver installation)
Storage Temperature -25° C ~ 70° C (-13° F ~ 158° F)
SDK (optional) Complete software development kit and
Storage Humidity Up to 98%RH support for OEMs
Recommended System Requirements
Hardware Pentium IV 2.3GHz +, 1GB hard drive,
Intel USB 2.0 Host controller
Software Windows 7 64 bit
Windows Vista 32 bit, and 64 bit
Windows XP Service pack 2 +,
DirectX 9.0c or above
17
CMOS USB 2.0., 1.3
Megapixel B&W Board
Camera
USB/PHOTO
ID BADGING
CAMERAS
24B1.3USB-C Features
• Progressive scan, 1.3 megapixel
CMOS sensor (square pixels)
• Sensor is optically centered within
lens mount holes • Extended integration time
• Streaming video or single frame (>0.5 sec.)
capture via hardware/software • WDM driver, DirectX, TWAIN
• Triggerable instantaneous snap compatible
shots • Support for Windows XP, Windows
• 24fps at full 1280 x 1024 resolution Vista, & Windows 7 operating
uncompressed video systems, Linux (coming soon)
• Simplified cabling - video, power • Complete SDK available
& full camera control over a single
USB cable
Technical Specifications
J100 J101 J300
1 +5V Optional 1 Trigger
2 D- 1 +5.3V 2 GND
3 D+ 2 GPIO 0
4 GND 3 GPIO 1
5 GND 4 GND
6 GND
Mechanical
Dimensions W x H x D 32mm x 32mm x 7.7mm (1.26” x 1.26” x 0.3”)
Weight <100g (3.5oz)
Lens Mounts Replace “X” in model number with desired
lens mount option:
Example: 5 = Metal M-12 Board 8 = Metal CS Board
change 24B1.3XUSB-C to
Electrical 24B1.3XUSB-C 24B1.35USB-C to select a
Image Sensor 1/2” CMOS 6.8mm x 5.4mm array M-12 Board Mount.
Active Pixels (HxV) 1280 x 1024, 5.2um square pixels
Frame Rate 24 fps at 1280 x 1024 un-compressed
30fps at 640 x 480 un-compressed
Sensitivity <1.0 Lux
Lenses (Recommended) 32SJ0818LD 8mm f1.8 M-12
Signal To Noise Ratio > 45dB
30SJ0818LD 8mm f1.8 CS
Gain Control Manual gain selectable via software
Connectors Molex 52991-0308-Mate
Synchronization Internal (X-tal controlled)
On board 53916-0304
Shutter Mode Electronic rolling shutter
Shutter Speed Selectable via software (½ – 1/5000 sec.)
Scan Mode Progressive scan Software
Control Communication Camera control via USB bus Viewer • WDM device drivers
SFT-07019 • DirectX compliant
Mirror Mode Selectable via software
• TWAIN compliant
Dynamic Range 68 db
SDK (optional) Complete software development kit and sup-
Video Output USB 2.0 (not USB 1.1 compliant) SFT-07019-SDK port for OEMs
Power Supply 5VDC via USB bus Recommended System Requirements
Power Consumption <110mA, <0.6W Hardware Pentium IV 2.3GHz +, 1GB hard drive,
Still Capture Via hardware or software Intel USB 2.0 Host controller
Streaming or single frame Software Windows 7 64 bit
Windows Vista 32 bit, and 64 bit
Environmental Windows XP Service pack 2 +,
Operating Temperature -15°C ~ 55°C (5° F ~ 131° F) DirectX 9.0c or above
Storage Temperature -25° C ~ 70° C (-13° F ~ 158° F)
Operating Humidity 20 to 93%RH, non-condensing Complementary Models
Storage Humidity Max. 98% RH 24B1.3XUSB-L 48mm x 32mm board with USB mini B
Packaging ESD safe package connector (minimum quantity required)
18
USB Digitizer Board
USB/PHOTO
ID BADGING
CAMERAS
60V002USB Features
• Inputs (multiplexed):
1x composite video, 1x S-Video
• Output: USB2.0, uncompressed image data streams
• Video formats: NTSC/RS-170, PAL/ CCIR
• Max resolution (NTSC/RS-170): 640 x 480 at 30Hz
• Max resolution (PAL/CCIR): 768 x 576 at 25Hz
• Driver for WDM, DirectX, TWAIN, VfW, LabView, and MIL
• Optional SDK
Technical Specifications
42mm (1.6”)
38mm (1.49”) J1 USB Out J100 Video In J6 Video In, Power In, Control In (Optional)
PIN FUNCTION PIN FUNCTION PIN FUNCTION PIN FUNCTION
J1 Ø 2.2mm 1 USB GND 1 VIDEO IN 1 +5V OUT 5 N/C
123456
(0.08”)
2 USB GND 2 GND 2 GND 6 GND
3 USB GND 3 YC/ SVBS 7 I2C
4 USB + 4 GND 8 I2C
42mm (1.6”)
5 USB -
Optional Y/C TBD
6 +5V
J100
2 1
19
Pan/Tilt/Zoom Auto
Focus True Day/Night
Dome Camera
20/21Z704T-PZ10 Features
• 100x zoom (10x optical/10x digital)
• User friendly OSD menu
CAMERAS
Technical Specifications
Joystick Remote Control (Optional) Pendant Mount (78V0027P)
Option (60ZRC200)
73.6
60ZRC200 Features
192.8mm
57.5
• Password protected
• Select up to 255 cameras from
115.7
One keyboard (Max. 99 PTZ units) 115.7mm
155.6mm
Safety Standards
CE, FCC
20
6” Pan/Tilt/Zoom
Auto Focus Dome
Camera
20/21Z704T-PZ30 Features
• User friendly installation
• 30x optical zoom (10x Digital)
CAMERAS
DOME
• Digital slow shutter for day & night operation
• Pan/tilt (max rotating speed is 360° per sec.)
• 127 preset positions
• Pelco-D, Pelco-P selectable & RS485 control
• Weather proof (IP 66), fan and heater
• Wall/ceiling mount bracket (option)
• Automatic flip
Technical Specifications
Joystick Remote Control Main Body (Without Sun-Shield)
Wall Mount
Option (60ZRC200) Bracket
(78V0017)
60ZRC200 Features
• LCD display and joystick control Ceiling
• 3 axis control via RS485 Mount
• Menu driven user configuration Bracket
• Password protected (78V0018)
• Select up to 255 cameras from
One keyboard (Max. 99 PTZ units)
21
5” Outdoor Dome With
True Day/Night Gen III
IR Filter Retraction
DW5V9TVB/DW5V9TVB-1 Features
• 1/3” high resolution Sony CCD imager
• True day/night Gen III with IR filter
CAMERAS
• Built-in heater
• DC-Drive auto iris
• Dip switch controllable features
• IP 67 rated
• 3 axis wall or ceiling mountable
Technical Specifications
DW5V9TVB DW5V9TVB-1
Ø143.64mm
80mm
46mm
Ø119mm
80mm
Ø100mm 83.5mm
22
4” Outdoor Tiltable
IR Dome Color
Camera With Audio
D4T9L3.6IR-A Features
• Vandal resistant metal housing
• Tiltable for difficult scenes
CAMERAS
DOME
• Resolution of 480TVL
• 1/3” Sony super HAD CCD
• Infrared lamp control
- Day/night
- Off/on
- Automatic
• Minimum lot sizes required
Note: Equipment with audio recording capabilities is intended to be used
only for legal and proper purposes. The customer assumes all liability
related to legal and proper use per VIS waiver FOR-03-021.
Technical Specifications
Ø 94mm
68.5mm
23
Fixed Dome Camera Series
TRUE DAY NIGHT and WIDE DYNAMIC RANGE features expand usability from bright morning sunlight through late
dusk. Videology’s dome cameras can maintain a full-scene through intensive sun glare or auto headlights.
CAMERAS
12.70
Ø 7mm
Ø117mm
Ø 67.8mm Video (yellow)
BNC Jack
24.5mm
Ø 5mm
45mm
46mm
88mm
VCC (red)
83.5mm
Power IN (5.5x2.1)
(L=3000mm)
82.5mm
(3/4”) EMT
(3.35”) (3.35”)
85mm 85mm
Optional
78V0004 Stainless steel drop ceiling adapter 78V0004
77PND5B Black ceiling pendant mount
77PND5C White ceiling pendant mount
78V0003 Black plastic wall mount
78V0005 White plastic wall mount
Ø172.88mm
PF -½" - 14
Ø142.98mm Ø140.1mm
Ø85.9mm
156.08mm
67.9mm
188.08mm
117mm
135.48mm
50mm
24
Model Numbering System For Videology Dome Lines
Custom configure your dome. Choose one option from each column. Transfer the option's bold-type code to that column's box. String together (some boxes
may be blank) to arrive at your custom model number. ie. = D 5 S _ 7 WT L4 D _
3" Domes Only 3 = 3" dome 4" Domes Only Leave Blank 9 = color Leave Blank Varifocal 4" Dome Only Leave Blank Leave Blank Leave Blank
DW = silver V = vandal = internal 540 TVL, 1/3" = no special CV = c/s CI = c/s Leave Blank =no IP/Ethernet = NTSC = no audio
ring 4 = 4" dome resistant, fog synchronization image sensor features mount, no iris, mount, dc iris, = dual voltage
(over all) or 3.5 - 8mm 3.5 – 8mm 12VDC/24VAC I = IP/Ethernet P = PAL A = audio
4" Domes Only 5 = 5" dome black slotted L = line lock 8 = color T = true day/
D = charcoal 480 TVL, 1/4" night VA = manual VB = dc iris D = 12VDC S = SD card
gray ring 6 = 6" domes T = tilting image sensor board mount board mount
N = day/night 4 - 9mm 4 - 9mm
5" Domes Only 5" Domes Only 7 = color 5" Dome Only
D = white ring S = black 330 TVL, 1/3" W = (wdr) wide WA = manual WB = dc iris Leave Blank
slotted image sensor dynamic range, board mount board mount = dual voltage
DB = black ring (dps) digital 2.6 - 6mm 2.6 - 6mm 12VDC/24VAC
C = white 6 = color pixel system®
DW = white slotted 330 TVL, 1/4" XA = manual XB = dc iris D = 12VDC
ring, weather/ image sensor TW = true cs mount CS mount
vandal resistant F = fog day/night & 5.5 - 33mm 5.5 - 33mm
dome (over all) 4 = b&w (wdr) wide 6" Dome Only
570 TVL, 1/3" dynamic range YA = manual YB = dc iris Leave Blank
6" Domes Only V = vandal image sensor board mount board mount = dual voltage
DW = silver resistant, 3.3-12mm 3.3-12mm 12VDC/24VAC
ring, weather/ black slotted 3 = b&w
vandal resistant 570 TVL, 1/3" ZA = manual ZB = dc iris D = 12VDC
dome 6” Domes Only image sensor board mount board mount
V = vandal 9 - 22mm 9 - 22mm
resistant, fog 2 = b&w
Videology Dome Lines
1 = b&w Fixed
570 TVL, 1/3" L1.8 = 1.8mm L2 = 2.45mm
image sensor
L3 = 2.97mm L3.6 = 3.6mm
L4 = 3.8mm L6 = 6.0mm
Select models may not be available.
Please contact your Videology sales representative for details. L8 = 8.0mm L12 = 12.0mm
DOME
25
CAMERAS
Low Cost Forensic Camera
Continuous Blast-Resistant Recording
20/21NF744 Features
• Hardened high temperature
blast-resistant memory device
• Records and preserves images
captured prior to an explosion (such as
that caused by a suicide bomber)
• Stand alone self contained easy to install
video camera & recorder
CAMERAS
HOUSED
CCTV
Technical Specifications
20NF744 21NF744 Environmental
Electrical NTSC PAL Operating Temperature -15oC ~ 55oC (5oF ~ 131oF)
Image Sensor 1/3” IL CCD Storage Temperature -30oC ~ 80oC (-22oF ~ 176oF)
Picture Elements 768 x 492 752 x 582 Operating Humidity 20 to 93% RH
Resolution 480 TVL Storage Humidity Up to 98% RH
Sensitivity 0.5 LUX (50 IRE) f1.2 3200oK Lifetime MTBF > 150,000 hours
Frame Rate 1 fps (recording)
Packaging Metallized, conductive bags
30 fps (viewing) 25 fps (viewing)
Warning: Avoid aiming the camera at the sun or other extremely bright
Signal to Noise Ratio >48 dB (AGC off)
lights. The CCD image sensor may be damaged if exposed to very bright
Gamma 0.45 objects.
Gain Control AGC 36dB
Synchronization Internal (crystal controlled)
Scan Mode Interlaced Mechanical
Video Compression M-JPEG/MPEG4 (dual modes) Dimensions W x H x D 50.4mm x 50.4mm x 112.5mm
(1.98” x 1.98” x 4.43”)
White Balance AWB
Weight 321g (11oz)
Contour Enhancement On
Iris Controls Electronic/DC auto iris (optional)
Video Output Composite 1Vp-p CVBS @ 75Ω Accessories
Power Supply +12VDC (+/-10%) Included 12” barrel power cable with locking connector
Power Consumption <1.0W Optional RJ45 connector
ERS*
Videology has designed a proprietary file system for our network camera
family (hereinafter referred to as the VIDEO file system), which provides
for continuous, uninterrupted recording of video in a loop type fashion with
a guarantee of no data loss.
26
High Resolution
Overt Lens
CAMERAS
HOUSED
• 12VDC/24VAC with isolated transformer (brown out protected)
CCTV
• Rugged all metal housing
• Brilliant color performance
• Overt camera - 1/3” interline CCD, >480 TVL
• Covert camera - 1/4” interline CCD, >460 TVL
Technical Specifications
85mm (3.35”)
Electrical 102.6mm (4.04”)
20D739C 21D739C
Top Overt Camera NTSC PAL
Image Sensor 1/3” interline CCD Camera Dial
controls covert camera FOV
Active Pixels (H x V) 768 x 492 752 x 585 (up/ down/ left/ right)
Resolution >480 TVL
Sensitivity 0.5 lux at 30 IRE (AGC max)
Signal To Noise Ratio >48 dB
Gamma 0.45
Gain Automatic
Synchronization Internal
Covert lens
Backlight Compensation Default on FOV= 480
Contour Enhancement Default on Rotational= L900 R 900
White Balance Auto 2300 - 7500K U 900 D 900
Iris Signal Electronic or direct drive (auto detect)
Iris Controls ALC pot for direct drive iris Front 50mm (1.97”)
Back
Video Output Composite video 1Vp-p 75 Ohms Overt Covert
Power Supply 12 - 28VAC 50/60Hz
50mm (1.97”)
27
Near IR 940nm
Sensitive B/W CCTV
Camera With OSD
20/21E618 Features
• 940nm sensitivity allows use of undetectable
IR illumination. 40% more than most B/W
cameras
• 12VDC/24VAC
• OSD (on screen display) control
• 570 TVL (20/21E608)
CAMERAS
HOUSED
CCTV
Technical Specifications
Rear Panel 12VDC/24VAC
OSD Function
Iris Manual, DC
Shutter Fixed, manual, flk
BLC Off/On DC Iris Port
AGC Off/On
White Balance ATW, AWB, fixed, manual
Fixing screw back focus
Gain AGC/fixed (min – max)
Adjustment ring back focus
Camera ID Off/On
Mirror Off/On
Day/Night Auto, B/W, color
Accessories
Motion Off/On
Included Top/bottom mounting plate
Privacy Off/On
Optional 60P24VAC 24VAC power supply
Gamma 0.05 - 1.0
Language English, Korean, Chinese 1, Chinese 2, Japanese
Reset Yes/No
28
True Day/Night Zoom
Weatherproof IR
Color Camera
20/21VC724TDN Features
• True day/night Gen II with IR filter retraction on
CCD
• Maximizes sensitivity in B&W night scenes
• 1/3” Sony super HAD CCD, 550 TVL
• 2x digital zoom (external adjustment)
• 42 IR LEDs & 1 CDS sensor (130 FT range)
CAMERAS
HOUSED
• Built-in DC iris super digital noise reduction
CCTV
• Weather resistant IP 65 rating
• Aluminum housing with mount arm
Technical Specifications
Technical Specifications
20VC724TDN 21VC724TDN
Electrical Environmental
NTSC PAL
Image Sensor 1/3” Sony super HAD CCD Ambient Operating -10° C ~ 45° C (14° F ~ 113° F)
Active Pixels (HxV) 768 x 494 (380K) 752 x 582 (440K) Temperature
Resolution 550 TVL Storage Temperature -20° C ~ 65° C (-04° F ~ 149° F)
Scanning System 2:1 interlace
Scanning Frequency (HxV) 15.734 KHz x 59.94 Hz 15.625 KHz x 50 Hz Mechanical
Sensitivity Day .3 lux
Night 0.00 lux (IR LED on) – 130ft range Dimensions WxHxD 83mm x 160.4mm (3.26” x 6.31”)
Synchronization Internal Weight 3.2 kg (7.1 lbs)
Signal To Noise Ratio > 50dB (AGC off) Lens 3.8 – 9.5mm DCAI F1.2, 2x digital zoom
IR LED And CDS Sensor IR LED (850mm, 42 EA) Fan/Heater Built in
CDS sensor (1 EA) Construction Diecast aluminum
Gain AGC on/off Body Color Dark grey
Flickerless Mode On / off Application Indoor / outdoor
White Balance Auto
Back Light Compensation On / off
Day/Night Electronic (DSS), ICR (sensor type) Accessories
Digital Slow Shutter Max 32x (on / off)
Included Sun shield & wall bracket
Digital Zoom 2x (on / off)
Optional 60PR24V2.08 – 24VAC power supply
Digital Noise Reduction Auto
Video Output 1Vp-p (75 ohms, composite)
Power Supply 24VAC / 12VDC
Power Consumption .458mA Approbations CE, UL
29
Auto Focus True
Day/Night Color
Housed Camera
20/21Z704T-23X Features
• 1/4” SONY high resolution super HAD CCD
• Built-in auto focus/auto iris
• 23x optical power zoom lens
• 10x digital zoom (max 230x)
• True day/night with retractable IR cut filter
• On-screen menu control (OSD)
CAMERAS
HOUSED
Technical Specifications
30
Auto Focus 27x
Optical Zoom Color
Module
20/21Z404-27X Features
• 1/4” SONY super HAD CCD
• Built-in auto focus/auto iris
• 27x optical power zoom lens
• 10x digital zoom (max. 270x)
• TDN (retractable IR cut filter) (optional)
• On-screen menu control (OSD)
CAMERAS
HOUSED
• 9 backlight compensation (BLC) zones
CCTV
• Video transmission distance adjustable (3 Step)
• RS-232C TTL interface
• Digital slow shutter (DSS) (0.001 Lux for better nighttime sensitivity
Technical Specifications
Technical Specifications
20Z404-27X 21Z404-27X
Electrical NTSC PAL
Image Sensor 1/4” SONY super HAD CCD
Total Pixels (HxV) 811 x 508 410K 795 x 596 470K Environmental
Active Pixels (HxV) 768 x 494 380K 752 x 582 440K Operating Temperature -50C ~ 500C (230F ~ 1220F)
Horizontal Resolution 480 TV lines Operating Humidity 20% ~ 60% RH
Scanning System 2:1 Interlace Storage Temperature -400C ~ 600C (-400F ~ 1400F)
Scanning Frequency (HxV) 15.734 kHz x 9.94 Hz 15.625 kHz x 50 Hz Storage Humidity 90% RH
Sensitivity Day Mode Min. illumination 1 lux (30IRE)
Night Mode 0.5 lux (30IRE)
Mechanical
DSS 0.001 lux (128FLD, 30IRE)
Dimensions W x H x D 48mm x 51.5mm x 86.6mm
Signal To Noise Ratio > 48dB (AGC Off) (1.9” x 2.0” x 3.4”)
AGC Auto/manual (0~255) Weight (Net) 205g (0.45 lb)
Synchronization Internal/line lock Lens 27x AF zoom video
Backlight Compensation 9 BLC zones (F1.6 (W), F3.2 (T) f=3.6~97.2mm)
White Balance Auto/push auto/outdoor/indoor/manual
Electronic Shutter Auto (8 steps)/flickerless
1/60 ~ 1/10,000s 1/50 ~ 1/10,000s
Safety Standards
FCC, CE
Flickerless Mode On/off
Digital Slow Shutter 2FLD~128FLD/ off
Focus Mode Auto/ manual
Mirror Mode On/off
Motion Detection On/off (4 programmable zones per screen)
Video Output 1.0 Vp-p (75 Ohm, composite)
Power Supply 12VDC (9V~15V)
Power Consumption 4.56W (max)
OSD Menu On/off
Control Communication RS-232C
Protocol PelcoD
31
Wide Dynamic Range
CMOS Color Camera
20/21B709W Features
• 1/3” high resolution sensor
• WDR To 120dB & optional true day/night
• OSD control
• Digital pixel system
• Flickerless modes
CAMERAS
HOUSED
CCTV
Technical Specifications
50mm (1.97”) 110mm (4.33”)
50mm (1.97”)
60mm (2.4”)
Technical Specifications
Mechanical
20B709W 21B709W Dimensions WxHxD 50 x 50 x 85mm (1.97” x 1.97” x 3.35”)
With Connectors & Mount 50 x 60 x 102.6mm (1.97” x 2.4” x 4.04”)
Electrical NTSC PAL Weight 217.5g (0.48 lbs)
Image Sensor 1/3” CMOS Digital Pixel System Lens Mounts C, CS
Active Pixels (HxV) 742 x 552 Connectors Power 12VDC/24VAC Terminal strip
Resolution 480 TVL Video Output BNC (rear)
Sensitivity 0.6 lux @ 30 IRE (F1.2) Iris DCAI (4pin)
0.08 lux (w/ DSS on)
Dynamic Range 120dB(max), 102dB (typical)
Signal To Noise Ratio 48 dB or more Accessories
Auto White Balance On/off (2500K – 9500K) Included 1 mounting plate: top or bottom
Auto Tracking WB On/off mountable
Gain AGC max on/off
Synchronization Internal/line lock
Gamma 0.45
Iris Control DC iris/Electric Certifications
Shutter Speed 1/60 to 1/100,000 1/50 to 1/100,000 RoHS Compliant
Video Output 1V p-p composite 75 Ohms CE & FCC in Process
Power Supply 12VDC/24VAC (Others Available Upon Request)
Power Consumption < 2.9W
Complementary Models
Environmental 20B709TW Optional WDR/TDN
Ambient Operating Temp -10°C ~ 55°C (-14°F ~ 122°F)
Storage Temp -20° ~ 70° C (-4°F ~ 158°F)
Operating Humidity < 90% non-condensing
Storage Humidity < 95% non-condensing
32
Housed Cameras
For complete line of cameras, visit us at www.videologyinc.com
Housed Cameras
High Resolution With Balanced Video (UTP) Output
Image Sensor 1/3” IL CCD Iris Control ALC Pot for direct drive iris
Horizontal Resolution >480 TVL Video Output Balanced video @ 100 Ohms
Sensitivity 0.5 lux 30 IRE (AGC max) Composite video (BNC for short range FOV setup)
Signal To Noise Ratio >48 db Power Supply 12 - 28VAC 50/60Hz
Gain Automatic/ manual 10.8 - 39VDC polarity independent
Synchronization Internal Power Consumption <3W
Back Light Comp. Default on Lens Mount C (includes adapter)/ CS mount
White Balance Auto 2300 ~ 7500K Weight 217.5 g (0.48 lbs)
20D739B NTSC Iris Signal Electronic (default) Dimensions (WxHxD) 50mm x 50mm x 85mm (1.97” x 1.97” x 3.35”)
Direct drive w/iris (auto detect)
21D739B PAL
True Day/Night Zoom Weatherproof IR
CAMERAS
HOUSED
Image Sensor 1/3” Sony super HAD CCD Day/ Night Electronic (DSS)/ ICR (sensor type)
CCTV
Active Pixels (HxV) 768 x 494 (380K) NTSC Digital Zoom 2x (on/ off)
752 x 582 (440K) PAL Signal To Noise Ratio > 50dB (AGC Off)
Resolution 550 TVL Camera Control RS-485 interface (Pelco-D)
Scanning Frequency 15.734 KHz x 59.94 Hz NTSC IR LED And CDS IR LED (850mm, 42 EA) CDS sensor (1 EA)
(HxV) 15.625 KHz x 50 Hz PAL Video Output 1Vp-p CVBS 75 ohms
Sensitivity Day 0.3 Lux Power Supply 12VDC/ 24VAC
Night 0.00 Lux (IR LED On) Power Consumption .458mA
White Balance Auto Lens 3.8 – 9.5mm DCAI F1.2, 2x digital zoom
20VC724TDN NTSC Gain AGC on/ off Weight 3.2Kg (7.1lb)
21VC724TDN PAL Synchronization Internal Dimensions (WxHxD) 83mm x 160.4mm (3.26” x 6.31”)
Back Light Comp. On/ off
True Day/Night
Image Sensor 1/3” Sony super HAD CCD Day Night Automatic
Resolution 550 TVL Power Indicator LED (rear)
Signal System 2:1 interlace Video Output 1Vp-p composite, 75 ohms
Sensitivity Day 0.3 lux at 30 IRE Power Supply 12VDC / 24VAC
Night 0.01 lux at 30 IRE Power Consumption <2.6W
Signal To Noise Ratio > 46dB Lens C (includes adapter), CS
Synchronization Internal/line lock Weight 408.2g (0.90 lbs)
20E709TDN3 NTSC Back Light Comp. On/ off Dimensions (WxHxD) 50mm x 60mm x 105.5mm
Iris Signal Video iris & DC auto iris 1.97” x 2.4” x 4.15”
21E709TDN3 PAL Iris Control AGC pot
20D739 NTSC Dimensions (WxHxD) 50mm x 50mm x 85mm (1.97” x 1.97” x 3.35”)
21D739 PAL
33
Compact Rugged Housed Cameras
For complete line of cameras, visit us at www.videologyinc.com
Active Pixels (HxV) 768x492 (NTSC), 752x585 (PAL) Contour Enhancement Horizontal/ vertical
CCTV
Horizontal Resolution 450 TVL (CVBS) 490 TVL (YC) White Balance Auto or push lock/ 3 fixed modes
Sensitivity 0.25 lux Iris Signal Electronic
Signal to Noise Ratio >46dB (AGC off) Shutter Speed Electronic, fixed from 1/50~1/100,000
Control I2C & dip switches Video Outputs Composite 1Vp-p CVBS, Y/C (S-video)
Gamma 0.45 or 1 Power Supply 8-16V DC, 12V DC nominal
Gain Automatic/ manual/ fixed via software Power Consumption <2.4W
20D779 NTSC Synchronization Internal or H&V lock Dimensions (WxHxD) 50mm x 50mm x 53mm
Mirror Mode On/ off Connectors 12-pin hirose/ BNC CVBS/ 4-pin mini din
21D779 PAL
Compact Rugged Color Camera
Image Sensor 1/4” IL CCD Back Light Comp. Default on (selectable via software)
Active Pixels (HxV) 510x492 (NTSC), 500x582 (PAL) White Balance Auto or push lock/ 3 fixed modes
Viewer Display Iris Signal CCD Iris default
(USB 2.0, 30fps) 720 x 480 pixels max Shutter Speed Automatic from 1/50 - 1/100,000 14 fixed
720 x 576 pixels max speeds via software
(USB 1.1, 30fps) 320 x 240 pixels max Power Supply 5VDC via USB bus
Sensitivity < 0.5 Lux Power Consumption < 1.3 W
Signal to Noise Ratio > 48 dB (AGC off) Dimensions (WxHxD) 50mm x 50mm x 49.6mm
Gamma 0.45 default (1.0 via Software) Included Software Camera Device Driver
20K74XUSB NTSC Gain Automatic/ fixed SFT-04040 Viewer (GUI)
21K74XUSB PAL Synchronization Internal User’s Manual
Mirror Mode Selectable via software Optional Software Complete software development kit & support
see USB family data sheet SFT-04040-SDK for OEMs
Control Via USB bus
Contour Enhancement Default on see USB family data sheet
21D689 CCIR
Compact Rugged B&W Camera
Image Sensor 1/3” IL CCD Back Light Comp. Off
Active Pixels (HxV) 768x492 (EIA)/ 752x582 (CCIR) Contour Enhancement Off
Horizontal Resolution >570 TVL Shutter Speed Electronic, fixed from 1/50 ~ 1/100,000
Sensitivity 0.05 lux at 50 IRE (F1.2) Video Output Composite 1Vp-p CVBS 75 ohms
Signal to Noise Ratio 48 dB (AGC off) Power Supply Nominal 12V (9-15VDC)
Control 15 pin D-sub/ HD connector Power Consumption <1.5W
Gamma 1.0 fixed Dimensions (WxHxD) 50mm x 50mm x 53mm
Gain Manual/ AGC (option) Connectors 15 pin D-sub HD/ CVBS video out (BNC),
20D679 EIA Synchronization Internal/ HV/VD/ composite composite sync in (BNC)
34
Wide Dynamic Range
WVGA B&W CMOS
Board Camera
24B752XA Features
• Interlaced scan (analog)
progressive scan (digital)
• 752 x 480 pixels
• 1/3” B&W CMOS, BGA ruggedized automotive sensor
• 60 FPS (full resolution)
• Frame rate from 30 to 200 FPS (QCIF)
• Digital 8 or 10 bit parallel, serial (LVDS), or composite (analog) video outputs
• High dynamic range of 110dB
• “Area of interest” pixel utilization
CAMERAS
BOARD
Technical Specifications
†
28.7mm
28.7† † 14.4mm
ı4.4†
2.2mm
2.2† Diameter
Dišmeter†
3.3††
3.3mm x4
12.8mm
X4
J2†
14.3mm
15.8mm
ı4.3† ı2.8†
14.4mm
ı4.4†
28.7mm
ı5.8†
28.7†
5.2† Diameter
Dišmeter†
œensor† 3.3††
3.0mm
X x2
5.2†
Jı †
6.25mm
6.25†
3.5mm
3.5†
4mm (0.15”)
3.5mm
3.5†
15.2mm
ı5.2†
Technical Specifications
Environmental
Electrical 24B752XA 24B752XS
24B752XA Operating Temperature -40° C ~ 85° C -15° C ~ 55° C
BGA Ruggedized Sensor -40° F ~ 185° F 5°F ~ 131° F
Image Sensor 1/3” CMOS Storage Temperature -55° C ~ 125° C -25° C ~ 70° C
Active Pixels (H x V) 752 x 480, -67° F ~ 257° F -13° F ~ 158° F
6.0um square pixels Operating Humidity 20 to 93% RH
Binning 2x2 or 4x4 of full resolution Storage Humidity Up to 98% RH
Frame Rate 30 to 200 FPS (QCIF) Lifetime MTBF > 150,000 hrs
Sensitivity <0.1 lux out to 1.05um Packaging Anti-static bag
Signal To Noise Ratio > 45dB (AGC off)
Gain Control Automatic 20 dB (default) or
manual / fixed Mechanical
(selectable via software) Dimensions W x H x D 28.7mm x 28.7mm x 5.6mm
Synchronization Internal (1.13” x 1.13” x 0.22”)
(X-tal controlled) Weight <100g (<0.22 lbs)
Shutter Speed Automatic / fixed Lens Mount Replace “X” in model number with desired lens
(selectable via software) mount option:
Shutter Mode Global Example:
Scan Mode Interlaced (analog) or 2 = Metal 5 = Metal 8 = Metal
Change 24B752XA to M-12 Pinhole † †
M-12 Board CS Board †
progressive scan (digital) 24B7525A to select an
Dynamic Range 110 dB (high dynamic range) M-12 Board Mount.
Video Output Composite, LVDS,
8 or 10 bit digital
Power Input +5VDC to 15VDC
Power Consumption < 320mW at max data rate
100mW at standby mode
35
1/3” CMOS Wide Dynamic
Range Color Board Camera
With TotalFocusTM Lens
20B40W-F Features
• Sensitivity of 0.08 lux with digital slow shutter
• Superior wide dynamic range (120dB)
• Digital pixel system
• NTSC/PAL selectable
• OSD joystick or remote control
• Optional digital BT656 output or Y/C output
TotalFocusTM Lens
• Entire scene in focus - All the time!
- 3x motorized optical zoom
CMOS & CCD
Control Board
Technical Specifications
TotalFocus™ Lens*
20B40W-F Lens 2.9 – 8.5mm TotalFocus™
Electrical
Iris Auto (f1.9 – 360)
Image Sensor 1/3” CMOS
Focus Fixed – All in focus (near – far)
Total of Pixels (H x V) 742 x 552
Zoom 3x optical motorized / 10x digital
Horizontal Resolution 480 Horizontal TV Lines (color)
Lens Mount M-16 Board Mount
Scanning System 525 lines interlaced (NTSC)
625 lines interlaced (PAL)
Synchronization Internal / External Environmental
1.0Vp-p/75 ohm composite Operating Temperature -10° C ~ 50° C (14° F ~ 122° F)
Video Output
Optional digital output or Y/C Storage Temperature -20° C ~ 70° C (-4° F ~ 158° F)
Iris Control DC auto iris Operating Humidity Under 90% Non-condensing
0.08 Lux (DSS on) with f1.2 Lens Storage Humidity Under 95% Non-condensing
Sensitivity
0.6 Lux (DSS off) with f1.2 Lens
S/N Ratio > 48dB or more
Dynamic Range 120dB(max), 102dB (typical) Mechanical
Shutter Speed 1/60 - 1/100,000 (NTSC) Dimensions W x H x D 38mm x 38mm x 17.4mm (without lens)
1/50 - 1/100,000 (PAL) (1.49” x 1.49” x 0.68”)
OSD Function Controls Lens, WDR, WB, AGC, low light, Weight 109g (0.24 lb) with control board and lens
Synchronization, RS-485
OSD / TotalFocus™ Access Control Board (Joystick or RS-485)
IR Remote Control (60ZRCIR) Accessories
Control Board 5 positioning joystick with a center Push Included 4 pin w/ flying leads
TACTILE Switch OSD control board w/ RS485
AGC Control 0 - 34dB Optional IR remote control (60ZRCIR)
Supplied Voltage DC 12V (8V - 18V)
Power Consumption Max 2.7W * See 32V2985PF Data Sheet
36
1/3” CMOS Wide
Dynamic Range
Color Board Camera
20B40X Features
• Sensitivity of 0.08 lux with digital slow shutter
• Superior wide dynamic range (120dB)
• Digital pixel system
• NTSC/PAL selectable
• OSD joystick (optional)
• Optional digital BT656 output or Y/C output
• Auto white balance
Technical Specifications
CAMERAS
BOARD
Control Board (60ZRC01)
37
Mini CMOS Color
Camera Series
20/21B45 Features
• Sizes available
- 14mm x 14mm board camera
- 17mm x 17mm housed camera
• Low power 1/4” CMOS sensor with ultra wide temperature & vibration spec.
• Image sensor has twice the sensitivity of 1/3” Sony Ex-View
• NTSC/PAL (true two field) analog composite video output
• Optional models
- Balanced video output
- Computer controllable via I2C
- 5VDC dual board (coming soon)
CMOS & CCD
CAMERAS
BOARD
Technical Specifications
20/21B45 20/21B45M-12 20/21B45M (3.4mm lens not shown) Pin out diagram of J112
14mm 6.7mm 14.3mm 8mm
16.6mm 9.5mm 16.4mm 5.5mm 6 I2C - DAT
5 I2C - SCK
4 CVBSN
14mm
3 CVBSP
18.4mm
17.2mm
J112
3.5mm
18.4mm
3.8mm
17mm
6 5 4 3 2 1 2 GND
1 Vp-p
R2.0 R2.0
Full Rad 16mm Full Rad 10mm
2 places Ø15.1mm 2 places Ø15.1mm
18mm 12mm
Mechanical
Electrical 20B45 21B45 Dimensions W x H x D 20/21B45 14mm x 14mm x 6.7mm
(w/ connector) (0.55” x 0.55” x 0.26”)
20B45M 21B45M 20/21B45M 16.4mm x 17mm x 12mm
20B45M-12 21B45M-12 (0.64” x 0.67” x 0.47”)
NTSC PAL 20/21B45M-12 16.6mm x 17.2mm x 18mm
Image Sensor 1/4” CMOS (0.65” x 0.68” x 0.63”)
Active Pixels 640 x 480, 5.6μm x 5.6μm Weight 20/21B45 0.5g (0.01 oz)
Resolution 420TVL 20/21B45M 6.4g (0.23 oz)
Sensitivity 0.025 lux (50 IRE) F1.2 32000K 20/21B45M-12 6.9g (0.24 oz)
Signal To Noise Ratio 46dB (AGC On) Lens Mount 20/21B45 No lens mount
Gamma 0.45 default 20/21B45M M-12 pinhole board mount
Gain Automatic 36 dB (default) 20/21B45M-12 M-12 board mount
Synchronization Internal Please refer to Videology’s board mount lens guide for options
Back Light Compensation Default Off Communication Kit (Optional)
White Balance AWB (default) / fixed (selectable via software)
Software control I2C program kit includes:
Shutter Mode Electronic rolling shutter
I2C board, Program cable, DB25 serial cable,
Shutter Speed Auto exposure or fixed Camera control software
Scan Mode Interlaced Note: Must be ordered with I2C models
Contour Enhancement Default on
Mirror Mode Yes (selectable via software) Accessories
Horizontal Flip Yes (selectable via software) Included 60C1039 – 6 pin JST connector w/ flying leads
Dynamic Range 73.4 dB Optional Models
Iris Controls Electronic (No DC signal) 20/21B45B Board camera w/ balanced video output
Video Output CVBS (75 Ohms) 20/21B45P Board camera w/ computer controllable via I2C
Balanced video output (optional)
20/21B45MB Housed camera w/ M-12 pinhole mount,
Power Input 3V - 3.3V (max) balanced video output, 3.4mm lens
Power Consumption < 150mA 20/21B45MP Housed camera w/ M-12 pinhole mount,
Communication Control Serial I2C computer controllable via I2C, 3.4mm lens
Environmental 20/21B45MB-12 Housed camera w/ M-12 board mount,
Operating Temperature -40°C ~ 70°C (-40°F ~ 158°F) @ 3.3V balanced video output, no lens
Storage Temperature -40°C ~ 90°C (-40°F ~ 194°F) 20/21B45MP-12 Housed camera w/ M-12 board mount,
Operating Humidity 20% - 93% RH computer controllable via I2C, no lens
Storage Humidity Up to 98% RH 5V dual board coming soon
38
520TVL Color Board
Camera
With Push To Set White Balance
20E40XP Features
• 1/3” Sony super Had CCD
• Low light sensitivity (<0.1 lux)
• Push to set white balance
• 520 TVL
• OSD function (with optional OSD control board)
CAMERAS
BOARD
Note: Requires special board version with M-16 mount.
Technical Specifications
MODE SWITCH 8 Pin Connector
JOYSTICK 1. +3.5V
2. GND
3. 2ND VIDEO
4. OSD KEY
5. RX
8 PIN
CONNECTOR 6. TX
2ND RS485 7. MOTION
VIDEO (PELCO D) 8. MODE SELECT
(MULTIFOCUS MODE)
20E40XP Environmental
Electrical NTSC PAL Operating Temperature -10°C ~ 55°C (14°F ~ 131°F)
Image Sensor 1/3” Sony Super HAD CCD Operating Humidity < 90% non-condensing
Total Pixels (HxV) 768 x 492 752 x 582 Storage Temperature -25°C ~ 70°C (13°F ~ 158°F)
Horizontal Resolution 520 TVL Storage Humidity 95% non-condensing
Sensitivity <0.1 lux (F1.2 30 IRE)
Signal to Noise Ratio >50dB (AGC off) Mechanical
Gamma Default 0.45/selectable settings Dimensions W x H x D 38mm x 38mm x 21.6mm double board
Synchronization Internal / external (1.49” x 1.49” x 0.85”)
Video Output 1Vp-p baseband video (75 ohm) Weight 36g (1.3 oz) without lens
Y/C (optional) Lens mounts Replace “X” in model number with desired lens
Power Supply 12VDC (10 - 16V) mount option:
Power Consumption 1.2W (max) Example: 2 = Metal 5 = Metal 8 = Metal
Change 20E40XP to M-12 Pinhole M-12 Board CS Board
20E405P to select an
OSD Function (With Optional Control Board) M-12 Board Mount.
Iris Manual, DC
Shutter Speed Auto, manual, flickerless
1/60 - 1/120,000s 1/50 - 1/120,000s
White Balance ATW, manual, AWC, push lock
ATW: 2,5000C ~ 9,5000C
Backlight Compensation Off/On/Low/High Option 42mm x 42mm single board
AGC Normal, Hi, Off (1 - 70)
Gain Auto/fixed
Motion Detection Off/On
Complementary Models
20E40P-F Includes TotalFocus™ & RS485 control board
Privacy Off/On
Note: Serial Interface or YC options are special requests
Mirror Off/On
Sharpness Off/On (0 - 31)
Reset Returns the level to default Accessories
Optional 60ZRC02 OSD control board
39
CMOS 1.3 Megapixel
Sensor Color Board
Camera
24C1.3XDIG Features
• Progressive scan, 1.3 megapixel sensor with RGB
color filter
• 15 fps at full 1280 x 1024 resolution uncompressed
• Mirror mode option
• Delivers 8-bit, or 10-bit digital YUV & RGB video output
• Software controllable features & functions via I2C
• Ultra small board 22mm x 26mm
• Flash trigger pin option
Technical Specifications
J1 Connector*
CMOS & CCD
01 GROUND 16 NC
CAMERAS
03 YUV0 CCIR656 18 NC
04 LSB0 (additional bit 10 bits)* 19 Data Clock
22mm (0.87”)
40
1/3” CCD Blue Sky
Family
20/21D10X 20/21D20X
20/21D35X 20/21D35XO
Blue Sky Features
• 1/3” CCD
- 1/3” IL CCD (Color)/ 1/3” Sony Ex-View® CCD (B&W)
• Single board cameras 20D10X/20D11X
• Signal To noise ratio >48dB (AGC Off) 38mm x 38mm
• Gamma 0.45
- 0.45 (1.0 selectable via software) model 20D35XO
• Internal synchronization
• Internal scan mode
• Backlight compensation & contour enhancement
• Power supply 12VDC (+10%/-20%)
CAMERAS
BOARD
Technical Specifications
20D20X/20D35X
32mm x 32mm
Color B&W
20D10X / 21D10X High Resolution (38mm x 38mm) 20D35X / 21D35X High Resolution (32mm x 32mm)
Resolution 480 TVL Resolution 570 TVL, Sony Ex-View®
Sensitivity 0.5 Lux (50 IRE) f1.2 32000K Sensitivity <0.005 Lux (50 IRE) f1.2 32000K
White Balance AWB Video output Composite 1Vp-p CVBS (75 ohms)
Video output Composite 1Vp-p CVBS (75 ohms) 20/21D35XB - Balanced Video Output
20/21D10XB - Balanced Video Output Iris Controls Electronic
20/21D10XA – audio option
Iris Controls DC auto / electronic
41
1/3” CCD B&W Board Cameras
For complete line of cameras, visit us at www.videologyinc.com
42
1/3” CCD Color Board Cameras
For complete line of cameras, visit us at www.videologyinc.com
CAMERAS
20D20X = No Auto Iris,
BOARD
32mm x 32mm
Round Color Dual Board Camera
Image Sensor 1/3" IL CCD White Balance Automatic/ fixed modes
Active Pixels (HxV) 512 x 492 (NTSC) / 512 X 582 (PAL) Power Supply 12VDC (+/- 10%)
Resolution 330 (TVL) Power Consumption < 0.8W
Sensitivity > 0.3 Lux (30 IRE) F1.2 Lens Mount N/A
Signal to Noise Ratio > 46 dB (AGC off) Dimensions (WxØxD) 17.16mm x 19.25mm x 14.29mm
Gamma 0.45 (.676’’ x .758’’ x.562”)
Gain Automatic 26 dB Iris Control Electronic (default)
20RD8 NTSC Synchronization Internal Video Outputs 1Vp-p 75ohms (AC coupled)
21RD8 PAL Back Light Comp. On/ off selectable Scan Mode Interlaced
OLP/IR Filter Single layer 0.81mm (depth)
Contour Enhancement Default on
43
1/4” CCD Color &
B&W Board Cameras
20/21K1X Features
• 1/4” IL CCD
• CCD iris 20K15X (Actual Size)
• Internal Synchronization 22mm x 26mm x 25mm
• Power consumption <0.8W w/o lens
• Power supply 5VDC +5% not polarity protected
• Camera controls via USB bus software:
• Gamma • Back light compensation
• Gain • White balance mode (color only)
• Mirror mode • 14 fixed shutter speeds
• Interlaced/non interlaced • Contour enhancement
CMOS & CCD
CAMERAS
BOARD
Technical Specifications
20K13X (NTSC) 21K13X (PAL) Mechanical
B&W High Resolution Sony Ex-view® Dimensions W x H x D 26mm x 22mm x 10.9mm (1.02” x 0.86 x 0.42”)
Active Pixels (HxV) 768 x 492 752 x 585 (without lens mount)
Sensitivity < 0.005 lux, near IR sensitive Lens Mount Replace “X” in model number with desired lens
Resolution > 520 TVL mount option:
Video Output Composite 1Vp-p CVBS (75 ohms) Example: To select an 2 = Metal M-12 5 = Metal M-12 8 = Metal CS
M-12 Board Mount Pinhole
44
CRT (Cathode-ray
Tube) Monitors
Color 14” CRT Monitors
B&W 9” / 12” CRT Monitors
Monitor Features
• 1000 TVL high resolution (B&W Only)
• BNC Loop through
• Hi Z 75 Ohm termination switch
• Metal housing
• Finger grip inserts
• Regulatory compliance:
UL, CSA, CUL, FCC, FDA, CE, (LVD)
Technical Specifications
40VM14H 14” Color Monitor 40VM9H 9” B&W Monitor
Screen Size 14” Diagonal Screen Size 8.74” Diagonal
Resolution > 400 TVL Resolution >1000 TVL
MONITORS
MODULES
Scanning Frequency 15,750HZ +/- 450Hz (NTSC) Scanning Frequency Horizontal 15,750Hz / Vertical 60Hz (EIA)
15,623Hz +/- 600Hz (PAL) Horizontal 15,625Hz / Vertical 50Hz (CCIR)
Video Input Composite 1Vp-p 75 Ohm loop through BNC via Video Input Composite 1Vp-p 75 Ohm loop through BNC via
impedance switch impedance switch
Video Output Composite 1Vp-p CVBS 75 ohms Video Output Composite 1Vp-p CVBS 75 ohms
Power Source 90VAC ~120VAC (60/50Hz) Power Source 90V ~ 120VAC (60/50Hz)
Power Consumption 80W max Power Consumption <25W (EIA/CCIR)
Environmental Environmental
Operating Temperature -10°C ~ 50°C (14°F ~ 122°F) Operating Temperature 10°C ~ +40°C (14°F ~ 105°F)
Operating Humidity 30%~80% (no condensation) Operating Humidity 30% ~ 80% (no condensation)
Mechanical Mechanical
Dimensions (H x W x D) 395mm x 350mm x 340mm Dimensions (H x W x D) 222.25mm x 215.9mm x 254mm
(15.55” x 13.78” x 13.39”) (8.75” x 85” x 10”)
Weight 13 kg (28.66 lbs) Weight 6.8 kg (15 lbs)
Safety Standards UL, LVD, CE, RoHS Safety Standards UL, LVD, CE, RoHS
45
LCD Video Display
Modules
2.36” - 17” LCD Modules
Module Features
• Screen sizes from 2.36” to 17”
• NTSC/PAL auto selectable
• TFT active matrix
• Wide viewing angles
• Horizontal flip
• Mirror mode
• Low power requirements
Technical Specifications
6 ´/&'0RGXOH
3LFWXUH6L]H ´GLDJRQDO %ULJKWQHVV FGP
5HVROXWLRQ+[9 [SL[HOV %DFNOLJKW /('
/&'7\SH 7)7DFWLYHPDWUL[5*%GHOWD ,QSXW6LJQDO 9SSFRPSRVLWHYLGHRDW2KPV
'RW3LWFK:[+ [ 9LHZLQJ$QJOH /HIW5LJKW8S'RZQ
5HVSRQVH7LPH 7UPV7IPV ,QSXW9ROWDJH 9'&
&RQWUDVW5DWLR 3RZHU&RQVXPSWLRQ :PD[
MONITORS
MODULES
6 ´/&'0RGXOH
3LFWXUH6L]H ´GLDJRQDO %ULJKWQHVV FGP
5HVROXWLRQ+[9 [SL[HOV %DFNOLJKW &&)/
/&'7\SH 7)7DFWLYHPDWUL[5*%GHOWD ,QSXW6LJQDO 9SSFRPSRVLWHYLGHRDW2KPV
'RW3LWFK:[+ PP[PP 9LHZLQJ$QJOH /HIW5LJKW8S'RZQ
5HVSRQVH7LPH 7UPV7IPV ,QSXW9ROWDJH 9'&ULSSOH9SSPD[
&RQWUDVW5DWLR 3RZHU&RQVXPSWLRQ :PD[
6 ´/&'0RGXOH
3LFWXUH6L]H ´GLDJRQDO %ULJKWQHVV FGP
5HVROXWLRQ+[9 [SL[HOV %DFNOLJKW &&)/
/&'7\SH 7)7DFWLYHPDWUL[5*%VWULSH ,QSXW6LJQDO 9SSFRPSRVLWHYLGHRDW2KPV
'RW3LWFK:[+ PP[ 9LHZLQJ$QJOH /HIW5LJKW8S'RZQ
5HVSRQVH7LPH 7UPV7IPV ,QSXW9ROWDJH 9'&ULSSOH9SSPD[
&RQWUDVW5DWLR 3RZHU&RQVXPSWLRQ :PD[
6 ´/&'0RGXOH
3LFWXUH6L]H ´GLDJRQDO %ULJKWQHVV FGP
5HVROXWLRQ+[9 [SL[HOV %DFNOLJKW &&)/
/&'7\SH 7)7DFWLYHPDWUL[5*%'HOWD ,QSXW6LJQDO 9SSFRPSRVLWHYLGHRDW2KPV
'RW3LWFK:[+ PP[PP 9LHZLQJ$QJOH /HIW5LJKW8S'RZQ
5HVSRQVH7LPH 7UPV7IPV ,QSXW9ROWDJH 9'&
&RQWUDVW5DWLR 3RZHU&RQVXPSWLRQ :PD[
6 ´/&'0RGXOH
3LFWXUH6L]H ´GLDJRQDO %ULJKWQHVV FGP
5HVROXWLRQ+[9 [SL[HOV %DFNOLJKW &&)/
/&'7\SH 7)7DFWLYHPDWUL[5*%VWULSH ,QSXW6LJQDO 69LGHR
'RW3LWFK:[+ PP[PP 9LHZLQJ$QJOH /HIW5LJKW8S'RZQ
5HVSRQVH7LPH PV ,QSXW9ROWDJH 9'&ULSSOH9SSPD[
&RQWUDVW5DWLR 3RZHU&RQVXPSWLRQ :PD[
46
LCD Video Display
Monitors
5.6” - 17” LCD Monitors
Monitor Features
• Screen sizes from 5.6” to 17”
4.0” test monitor also available
• NTSC/PAL auto selectable
• TFT active matrix
• Wide viewing angles
• Horizontal flip
• Mirror mode
• Low power requirements
Technical Specifications
5.6” LCD Monitor 45M056XR
Picture Size 5.6” diagonal Brightness 200 cd/m²
Resolution (H x V) 960 x 234 pixels Backlight CCFL
LCD Type TFT active matrix RGB stripe Input Signal 1Vp-p composite video at 75 Ohms
Dot Pitch (W x H) 0.119mm x 0.357mm Viewing Angle Left 750, Right 750, Up 550, Down 550
Response Time Tr: 15ms Tf: 20ms Input Voltage 12VDC + 10%
Contrast Ratio 150: 1 Power Consumption 7W (max)
MONITORS
MODULES
Resolution (H x V) 960 x 234 pixels Backlight CCFL
LCD Type TFT active matrix RGB stripe Input Signal 1Vp-p composite video at 75 Ohms
Dot Pitch (W x H) 0.135mm x 0.416mm Viewing Angle Left 600, Right 600, Up 400, Down 550
Response Time 40ms Input Voltage 12VDC /24VAC
Contrast Ratio 350: 1 Power Consumption 7.5W (max)
47
LCD Video Display
Monitors
19” - 32” LCD Monitors
Monitor Features
• Screen sizes from 19” to 32”
• NTSC/PAL auto selectable
• TFT active matrix
• Wide viewing angles
• Wall mountable with VESA standard bracket
• Horizontal flip
• Mirror mode
• Low power requirements
Technical Specifications
19” LCD Monitor 45M19H / 45M19H-1 gray or white options
Picture Size 19" diagonal Brightness 400 cd/m2 (45M19H-1 300 cd/ m2)
Resolution (H x V) 1280 x 1024 pixels (SXGA) Backlight CCFL
LCD Type TFT active matrix RGB stripe Input Signal BNC, RCA, S-video, D-sub (45M19H-1 BNC)
Dot Pitch (W x H) 0.294mm x 0.294mm Viewing Angle Left 800, Right 800, Up 600, Down 800
Response Time 16ms Input Voltage 12VDC/ 90-260VAC 60Hz/ 50Hz adaptor
Contrast Ratio 800:1 Power Consumption 36W (max)
MONITORS
48
TotalFocusTM Lens
32V2985P F
Lens Features
The TotalFocus™ lens is advanced technology, which
simplifies field of view adjustment. The TotalFocus™
lens-camera board combination creates a clear image
from close up to infinity all the time. Most CCTV lenses are varifocal and only have a
single plane of focus. Objects in front or behind the focal point appear blurred. The
TotalFocus™ lens offers excellent depth of field so that all objects near and far remain
in focus.
Technical Specifications
LENSES
f=2.9-8.5mm F1.9 - 360 TotalFocus™
32V2985PF
Wiring Diagram
Focal Length 2.9mm – 8.5mm
Max. Aperture Ratio 1: 1.9 - 360
Max. Image Format 6(D) x 4.8(H) x 3.6(V)
Operation Iris Auto (F1.9 – 360)
Focus Fixed
Zoom 3x optical motorized
1 Brown Control (-)
Object Size at 25cm 2.9mm 55cm x 35.3cm 35.3cm x 24.6cm
1/3” 1/4” 2 Red Control (+)
8.5mm 15 cmx 11.1cm 11.1cm x 8.3cm
Coating Multi & Single 3 Yellow Drive (+)
Angle of View D 121.40 – 41.50 89.10 – 31.20 4 Orange Drive (-)
H 1/3” 95.50 – 33.30 1/4” 70.50 - 250
V 70.50 - 250 52.40 – 18.80
0 0
Operating Temperature -10 C ~ 50 C
Back Focal Length (In Air) 5.97 – 11.4mm
Flange Back Length 9.0mm
Mount Ø16mm
Dimensions (L x W x H) 31.9mm x 39.7mm x 31.4mm
Weight 24g
Effective Lens Aperture Front Ø 14.0mm
Rear Ø 6.2mm
† 06/21/09 PDS-32V2985PF Rev A
49
Board Mount Lenses
Fixed Focal M-9, M-12 & Pinhole
For 1/3” and Smaller Sensors
Model No. Focal Aperature Diagonal Field Of Operation Back Focal Dimensions Weight Minimum Object
Length View (degrees) Length (mm) Distance**
(mm) (F-Stop) 1/4” 1/3” Iris Focus (mm) (D) (L) (g) (cm)
Fixed Focal M-12 Mount (for 12mm diameter, 0.5 pitch lens mount)
32S1830N (fish eye) 1.78 3 128 170 No Iris Manual 6.7 31 24.6 11 40
32S2120N 2.1 2 116 160 No Iris Manual 5.4 17 18.5 7 8
32S2520N 2.5 2 104 140 No Iris Manual 5.5 15 18.3 6 40
32S2920N 2.97 2 95 130 No Iris Manual 6.1 14.9 15 5 15
32S0320N 3.0 2 90 120 No Iris Manual 5.6 14 15.4 5 40
32S3620N 3.6 2 73 92 No Iris Manual 5.7 14 15.2 5.5 30
32S3820N 3.8 2 72 90 No Iris Manual 5.8 14 16.7 6 20
32S0420N 4 2 61 81 No Iris Manual 5.9 17 19 6.3 40
32S4318N 4.3 1.8 59 78 No Iris Manual 4.0 14 15.4 5 50
32S0618N 6 1.8 46 60 No Iris Manual 8.2 15 16.2 5 60
32S5818N 5.8 1.8 43 54 No Iris Manual 8.2 15 16.2 5 40
32S0620N 6 2 41 54 No Iris Manual 7.5 13 19 5 40
32S0820N 8 2 29 39 No Iris Manual 8.2 13 19 6 50
32S1220N 12 2 19 28 No Iris Manual 9.2 13 16 3 50
32S1620N 16 2 15 20 No Iris Manual 7 13 19 5 50
32S25025N 25 2.5 10 14 No Iris Manual 11 24.8 21.9 19 45
Fixed Focal M-9 Mount (for 9mm diameter, 0.5 pitch lens mount)
32SN1913N 1.9 2 113 150 No Iris Manual 5.5 14 16.1 4.5 40
32SN2920N 2.9 2 97 120 No Iris Manual 5.5 14 16.1 4.5 40
32SN0320N 3.0 2 97 120 No Iris Manual 5.6 14 15.37 4.5 40
32SN3620N 3.6 2 70 92 No Iris Manual 5.7 14 15.35 5.5 40
32SN4318N 4.3 1.8 60 78 No Iris Manual 5.5 14 13.1 5.6 40
32SN0825N 8 2.5 31 40 No Iris Manual 8.5 14 14.3 5.5 40
LENSES
50
Board Mount Lenses
Fixed Focal M-12, M-14
For 1/3” and Smaller Sensors
Model No. Focal Aperature Diagonal Field Of Operation Back Focal Dimensions Weight Minimum
Length View (degrees) Length (mm) Object
Distance**
(mm) (F-Stop) 1/4” 1/3” Iris Focus (mm) (D) (L) (g) (cm)
LENSES
51
C & CS Mount Lenses
1/3” and Smaller Sensors
Model No. Focal Aperature Diagonal Field Of Operation Back Focal Dimensions Weight Minimum Object
Length View (degrees) Length (mm) Distance**
(mm) (F-Stop) 1/4” 1/3” Iris Focus (mm) (D) (L) (g) (cm)
Varifocal CS Mount
30V1634P 1.6-3.4 1.4 wide: 167.5 wide: 183.9 DC-AI Manual 11.9 - 6.95 40 52 105 12
tele: 74.5 tele: 98
30V2810P 2.8-10 1.4 wide: 78 wide: 104 DC-AI Manual 7.8 - 17 40 60.3 61 20
tele: 27 tele: 36
30V2812P 2.8-11.5 1.4 wide: 92.7 wide: 134 DC-AI Manual 9.75 - 20.5 34.4 61 98.5 12
tele: 23.4 tele: 32
30V3308M 3.3-8 1.4 wide: 74.4 wide: 99.02 Manual Manual 9.34 33 39.7 95 30
tele: 33.2 tele: 44.2
30V3308N 3.3-8 1.4 wide: 74.3 wide: 99.02 No Iris Manual 9.34 33 39.7 92 30
tele: 33.2 tele: 44.2
30V3508M 3.5-8 1.4 wide: 69.6 wide: 88.5 Manual Manual 8.64 - 14.16 37.6 48.1 93 30
tele: 32.8 tele: 43.5
30V3508P 3.5-8 1.4-1.96 wide: 69.6 wide: 88.5 DC-AI Manual 8.64 - 14.16 36 48.1 76.6 30
tele: 32.8 tele: 43.5
30V0550M 5.0-50 1.3 – 1.9 wide: 50.2 wide: 66.8 Manual Manual 9.61 – 13.20 39.5 55.5 88 30
tele: 5.2 tele: 6.9
30V0550P 5.0-50 1.7 wide: 47.3 wide: 63 DC-AI Manual 7.6 - 11 44.5 66 140 70
tele: 5.2 tele: 6.9
30V5533M 5.5-33 1.6 wide: 46.8 wide: 63.9 Manual Manual 10.3 - 13.0 42 54.5 148.5 30
tele: 8.1 tele: 11.0
30V5533P 5.5-33 1.6 wide: 46.8 wide: 63.9 DC-AI Manual 10.3 - 13.0 42 54.5 144.5 30
tele: 8.1 tele: 11.0
30V0770P 7.0-70 1.8 wide: 36.2 wide: 50.7 DC-AI Manual 13.25 - 18.39 48 82.2 201.5 30 - 100
LENSES
52
Megapixel Lenses
M-12, & CS Mounts
Note: All lenses are IR corrected so the image stays in focus both day and night
Model No. Format Focal Aperture Resolution Diagonal Field Of Operation Back Focal Dimensions Weight Minimum
Length View (degrees) Length (mm) Object
Distance
(mm) (F-Stop) 1/2” 1/3” Iris Focus (mm) (D) (L) (g) (cm)
LENSES
32SK0220L
2/3” 2 2.0 ≤2 mp 185 175 Fixed Manual 6.17 30 25.2 18 8
Fisheye
Varifocal CS Mount
tele 28 tele 37
30VH4510ML 1/2" 4.5-10 1.6 ≤5 mp Manual Manual 6.97-11.8 33 39.7 68 10
wide 60 wide 80.5
tele 58.9 tele 38.8
30VH0408PL 1/2" 4-8 1.4 ≤2 mp DC-AI Manual 9.6 - 14.7 38.6 4.7 15.2 30
wide 116.4 wide 76.8
53
24 Channel & 9
Channel Camera
Power Supplies
60P2424-1/60P2409 Features
The 60P2409 camera power supply provides a unique
series of features which allow easier installation,
greater reliability and unequalled flexibility— all for a very economical price. It is ideal
in any multi-camera installation, avoiding the need to tie up one electrical outlet per
camera, and providing significant advantages over multiple plug-in transformers in
safety, convenience, neatness and cost.
Technical Specifications
60P2424-1 60P2409
Dimensions 285.75 x 285.75 x 95.25mm Dimensions 187.32 x 211.14 x 92.07mm
(WxHxD) (11.25” x 11.25” x 3.75”) (WxHxD) (7.38” x 8.31” x 3.63”)
Weight 5.9kg (13 lbs) Weight 2.82kg (6.2lbs)
Camera Outputs 24 Camera Outputs 9
Each output protected by a 1.1 Each output protected by a 1.1
Amp self-resetting SmartFuse Amp self-resetting SmartFuse
Positive Thermal Coefficient (PTC) Positive Thermal Coefficient (PTC)
Power (max) 12 Amps (max) Power (max) 4 Amps (max)
Voltage Input 110/120V AC Voltage Input 110/120V AC
Voltage Output 24V AC† Voltage Output 24V AC†
Current Output 12 Amps (max)† Current Output 4 Amps (max)†
LEDs LED indicator light for AC power LEDs LED indicator light for AC power
ACCESSORIES
SUPPLIES
POWER
54
Low Vision Image
Processing (LVIP) Board
With USB Output
60V001-USB Features
• Specifically designed for low vision video
magnification systems
• Custom interfacing to enable the LVIP to be
seamlessly integrated into existing products
• Full color & high contrast black & white images in normal or reverse
video
• S-video (Y/C) input/ output
• USB 1.1/2.0 output
• Control board interface via I2C bus
Technical Specifications
42mm (1.6”)
38mm (1.49”) J1 USB Out J4 RS232 J6 Video In, Power In, Control In J5 Video Out
Ø 2.2mm PIN FUNCTION PIN FUNCTION PIN FUNCTION PIN FUNCTION PIN FUNCTION
(0.08”)
1 USB GND 1 GND 1 C IN 5 Ser CLK 1 CVBS B U
654321
J1 J4
321
(For Communications
5 USB - With 20Z404 Camera) 5 Y R V
J6 6 +5V 6 GND GND GND
87654321
ACCESSORIES
Power Supply 5VDC (256MB preferred)
DirectX 9.0c or later
SUPPLIES
POWER
Windows XP Service Pack 1
Controls (Service Pack 2 preferred)
Control Communication via I2C bus Windows 2000 Service Pack 4
Image mode (full color, hi contrast monochrome), Capture mode Full D1 MPEG2 P4 – 2.4GHz or above
false color combination, normal or reverse video,
640 x 480 MPEG2 P4 – 2.0GHz or above
black level, brightness and contrast
352 x 288 MPEG1 P4 – 1.5GHz or above
Multiple false color applications Hard Disk 5400RPM
Control Communication via RS232 W/ AF Zoom Camera 20Z404 (7200RPM preferred)
128MB of RAM
Initialization (white balance, mirror mode, shutter
(256MB preferred)
speed), zoom level and zoom range
Windows XP Service Pack 1
(Service Pack 2 preferred)
Mechanical Windows 2000 Service Pack 4
Dimensions WxHxD 42mm x 42mm x 0.6mm (1.6” x 1.6” x 0.23”) Verify your system has the latest USB 2.0 host driver from Microsoft® only.
Weight 11.33g (0.025 lbs) This product is not guaranteed to operate with a USB 2.0 host driver from
OWC.
Accessories
Cable (J1 Connector) 60C1062 (optional) USB 2.0 to 6 pin JST
Cable (J5 Connector) 60C1039 (included) 6-pin JST unterminated
Cable (J6 Connector) 60C1041 (included) 8-pin JST unterminated
55
Videology Imaging Solutions, Inc. U.S.A.
37M Lark Industrial Parkway
Greenville, RI 02828
Tel: 401-949-5332
Fax: 401-949-5276