Battery only
Module 1L consists of :-
WARNING
The battery holder in the actuator
gearcase also protects the user from
the hazardous live connections inside
the actuator and therefore it must not
be damaged. The actuator must be
isolated or disconnected if the battery
holder has to be removed from the
actuator gearcase.
A unique circuit has been incorporated
into the battery function of the IQ,
effectively reducing the overall drain and
significantly increasing the battery life.
Tests show for a typical actuator, a
battery life of 7 years can be expected.
Allowing for a conservative margin,
Rotork recommend that the battery
should be replaced every 5 years.
Battery level status is indicated by an icon
on the actuator display.
Full details from the actuator name plate must be given when enquiring about or ordering spare parts
Workshop and Spare Parts Manual
IQ, IQM and IQML Mk 3 Range Actuators
Modules 1K, 1K/1 & 1L Battery
All mechanical sizes
Publication 002-047-00 Issue 06/13
Replace battery
Disconnect the existing battery and using the strap
provided pull out of its plastic holder.
Whilst the actuator is down for
maintenance it is recommended
Fit new battery into strap and push into its holder,
that its battery be changed.
reconnect.
The battery as fitted by Rotork
is generally a PP3 9 volt
Refit and tighten threaded plug after lightly greasing
Ultralife Lithium cell.
thread and checking sealing ‘O’ ring is serviceable.
For Hazardous area certified
units ONLY approved battery
types must be used.
BATTERY TYPES
For European hazardous area certified actuators (ATEX / IEC Ex) use a
lithium manganese dioxide battery as stated in Table 1 BELOW.
Table 1
Full details from the actuator name plate must be given when enquiring about or ordering spare parts