Detects the presence of the radio 4 SACCH multiframes. That is T100 RADIO-LINK-TIMEOUT link by detecting SACCH frames 1.92 seconds if the SACCH is every 480 ms. completely absent. Used for re-transmission on the T200 Data link timer data link. The value varies 155 ms for FACCH depending on the message type.
Timer used to limit the amount of
T301 Alerting (ringing) timer 20 seconds time a user has to answer a call. Time the network waits after sending a CM SERVICE T303 Mobility Management REQUEST until receiving a 10 seconds connection timer response. This occurs before initiating call clearing procedures towards the MS. Time the network waits after transmitting a DISCONNECT T305 Release timer 10 seconds message until receiving a RELEASE message. Time the network waits after transmitting a DISCONNECT message while in-band T306 In-band tones release timer 10 seconds tones/announcements are provided, until receiving a RELEASE message. Time the network waits after sending a RELEASE message until receiving a RELEASE COMPLETE message. This T308 Release timer 10 seconds occurs before re-transmitting the RELEASE or releasing the Mobility Management connection. Time the network waits after receiving a CALL CONFIRMED message until receiving a T310 Call proceeding timer ALERTING, CONNECT, or 10 seconds DISCONNECT message before initiating clearing procedures towards the MS. Time the network waits after transmitting a CONNECT T313 Connect acknowledge message until receiving the 10 seconds timer CONNECT ACKNOWLEDGE message before performing clearing procedures with the MS.
Time the network waits after
sending a MODIFY message during call mode changes, until T323 Modify complete timer receiving a MODIFY 10 seconds COMPLETE or MODIFY REJECT message before initiating call clearing procedures. Time the network waits after sending the IMMEDIATE ASSIGNMENT or IMMEDIATE T3101 Immediate assignment ASSIGNMENT EXTENDED 1 second timer message until the main signalling link is established before releasing the newly allocated channels. Time the network waits after transmitting a HANDOVER COMMAND message until receiving HANDOVER COMPLETE or HANDOVER FAILURE or the MS re- T3103 Handover timer establishes the call before the old 2 seconds channels are released. If the timer expires and the network has not received a correctly decoded L2 (format A or B) or TCH frame, then the newly allocated channels are released. Time the network waits after sending the PHYSICAL INFORMATION message until receiving a T3105 Physical information correctly decoded L2 (format A 50 ms repetition timer or B) or TCH frame. This occur before re-transmitting the PHYSICAL INFORMATION message or releasing the newly allocated channels. Time the network waits after transmitting an ASSIGNMENT COMMAND message until receiving the ASSESSMENT T3107Channelassignment timer 3 seconds FAILURE message or the MS re- establishes the call before releasing the old and the new channels. Time the network waits after sending T3109Signalingdisconnection the CHANNEL RELEASE 5 seconds timer message before disconnecting the signalling link. Time the network waits after T3111Channeldeactivation after disconnecting the signalling link 500 ms disconnection timer before deactivating thechannel. Time the network waits after transmitting the PAGING REQUEST message until receiving the PAGING T3113 Paging timer RESPONSE message. This 5 seconds occurs before re-transmitting the PAGING REQUEST (if the maximum number of re- transmissions have not been exceeded). The location update timer is set to zero, periodic location update by the MS are disabled. If the MS T3212 Location update timer camps to the BCH and decodes zero = infinite time a new MCC or MNC from the one it last camped on, it should perform a location update. Time the network waits after sending the TMSI REALLOCATION COMMAND until receiving TMSI T3250 TMSI reallocation timer 5 seconds REALLOCATION COMPLETE. This occurs before aborting the procedure and releasing the Radio Resource connection. Time the network waits after an AUTHENTICATION REQUEST until receiving T3260 Authentication response AUTHENTICATION 5 seconds timer RESPONSE. This occurs before aborting the procedure and releasing the Radio Resource connection.