Home Learning Center Forum ▾ Coops Breeds Gallery Reviews Sponsors Store
Login
Search
Advanced Search Forgot Password? Remember Me ✔
Lind's Incubator
By: ThreeBoysChicks
Lind's Incubator - After looking at all of the great home made incubators on BYC and paying extra
charges for small quantities of chicks. I decided I was going to get started and build my own incubator
so that I can purchase hatching eggs and hatch my own babies..
2/15/2009 - I made two additional adjustments. First, I remounted the fan so it was blowing on an
angle out over the light to circulate air better. I have three thermostats and the farthest corner is
99 - 100 degrees and the closest to the heat source is 99 - 101. Second, (thanks to idea
from gopherboy) I put two tall jars of water in the bator to help stabilize the temps when it is opened.
Working great. The orange thing behind the water heater thermostat is a Nerf Dart. I wanted
something to keep it out away from the wall and the Nerf Dart was laying on the floor in the basement.
bantam eggs got rolling around and got up against the cage around the light bulb, I think they got too
hot. Second, when the humidity was raised, the duct tape that was holding the inside piece of plexiglas
came loose and fell off sometime during the day and fell down on top of the eggs and heat source, Related Articles
again, getting them too hot.
See All Articles
This was a great test hatch and the following corrective measures were taken. First, when using to
Hatch, I put up a piece of hardware cloth that prevents rolling eggs or chicks from getting to close to Step by Step Guide to ASSISTED Hatching
the heat source. Second, use gorilla glue to attach the plexiglas to the inside of the bator and then Last edited: 8/14/14
http://www.backyardchickens.com/a/linds-incubator[2015-08-14 17:51:10]
Lind's Incubator - BackYard Chickens Community
12/27/2008 - I built an incubator. I must thank MissPrissy and SpeckledHen. It was their threads,
which were so great that encouraged me to fall into the trap. There is no stopping me now. I am going
to be a hatching fool.
MissPrissy - http://www.backyardchickens.com/forum/viewtopic.php?id=8510
SpeckledHen - http://www.backyardchickens.com/forum/viewtopic.php?id=43984
It did not take that much time to assemble once I had the parts. The wiring, which I was most
concerned about was not hard at all. Again, great instructions. The hardest part in my mind was
bending that hardware cloth which is sharp and frustrating.
I have been shopping for parts and pieces for the last couple of months.
http://www.backyardchickens.com/a/linds-incubator[2015-08-14 17:51:10]
Lind's Incubator - BackYard Chickens Community
Still to purchase
Water Wiggler - Still searching for one.....
Corks
The light ficture is used as a heat source. A cage of hardware cloth is around it to keep something
from getting burned. The night light is used so that when the heat source is off, we can still see the
eggs and thermostats. The PC fan is used to circulate the heat around in the cooler. The Hot Water
heater thermostat is used to control the temperature. The pie plate in the bottom is used to hold
water to increase humidity when required.
http://www.backyardchickens.com/a/linds-incubator[2015-08-14 17:51:10]
Lind's Incubator - BackYard Chickens Community
Comments (1)
http://www.backyardchickens.com/a/linds-incubator[2015-08-14 17:51:10]
Lind's Incubator - BackYard Chickens Community
Why Join BackYard Chickens? The Basics Of Raising Poll: Why raise backyard
Membership is FREE - Get Chickens - Raising Chickens chickens?
Started! 101
Currently, there are 1778 Active Users (245 Members and 1533 Guests)
› Need help with gender reveal PLEASE! 2 seconds ago › Australorp by Ozarkred › My Chicken Pages- Jace and Bubbles
› are my hens too young to start eating corn on cob › New Hampshire by goofychickens › Rosie's story blog
26 seconds ago
› Wyandotte by ZeBeeSue › Colossal and Related Structures
› The Migratory/Ornamental Waterfowl INFO Thread
40 seconds ago › Silkie by kherokee › 3 Hens and Rhonda
› Wheezing and Gasping. Three chicks down out of › Serama by kherokee › Simple Guide to Chicken Injuries
Eleven!! HELP!! 51 seconds ago › HealthPro EBB-1 "Watch-Me-Grow" Digital Baby Scale › spoiled city chickens
› *Hidden Nature* A Shapeshifting RP 57 seconds ago with... by gentila
› Lapetit
› Help there is some thing living undeer my coop › 5 Gallon Double Wall Fount by WYNot
› My Birthday Present Coop
1 minute ago › Orpington by Hiyaherc
› Sunni and Stephen - The House Chickens
› Treats 1 minute ago › Ancona by hippiestink
› The beginnings of my flock
› Is this a dud hen? 1 minute ago › Welsummer by youngchooklover
› BREEDING FOR PRODUCTION...EGGS AND OR
MEAT. 2 minutes ago
View: New Articles | All Articles
› "Every jailbird deserves a prison yard" 2 minutes ago View: More Reviews
m
Mobile d
Desktop
© 2015 BackYard Chickens is powered by Huddler Lifestyle | FAQ | Support | Privacy/TOS | Site Map
http://www.backyardchickens.com/a/linds-incubator[2015-08-14 17:51:10]