Analogue/Digital
Teleprotection Equipment
TPS-NU, the new SELTA teleprotection equipment, is a flexible, reliable and cost-
effective solution for power line protection.
Main features
• Complete configurability of the commands • High programmability of the command
employment and commands priority (i.e. parameters (i.e. software timers)
operating mode “3+1” or “2+2”)
• Set-reset command (continuous commands)
• Management of indipendent and/or simul-
taneous commands • Alarms configurability
Power Power
Line Line
Carrier Carrier
High Voltage
Transformer
Power Line Power Line
ADM ADM
SOH SOH
Distance Distance
Protection TPS-NU TPS-NU Protection
TPS-NU TPS-NU
SDH network (E1 - 2 Mbit/s G.703)
Low-frequency channel (copper wires)
High Voltage
Transformer
Power Line
Power Line
MUX MUX
Voice Voice
and and
Data Data
Applications
Operating principle
For all the digital interfaces there are 20 available For all the analogue interfaces there are 9 available
bit sequences for the commands employment. frequencies for the commands employment.
Technical data
Performances
Command interfaces
Security and dependability: IEC 60834-1 compliant
Number of commands up to 4
Both with digital interfaces (optical fiber, E1, G.703, V.11) Number of inputs for each 2 (command transmission
and with analogue interfaces (analogue/digital PLC, high voltage interface and start criteria)
low-frequency channels) the system is able to respect Number of outputs for each 3 (main output and
with a wide margin the performances required by the high voltage interface 2 auxiliary outputs)
IEC60384-1 in terms of safety and dependability in the
different protection schemes (intertripping, pe missive Command input: opto-coupler
underreach, permissive overreach and blocking). Voltage range 8 ÷ 200 Vdc
Furthermore transmission time, security and dependability Current range 3 ÷ 20 mA
performance parameters are completely programmable
by the user for all the digital and analogue interfaces. Command output: solid-state relay
Contact type normally open
Max. switchable voltage 250 Vac/250 Vdc
Max. current 1A
Max. switchable power 250 VA
Electromechanical relays
Contact type switching free contact
Max. switchable voltage 250 Vdc
Max. current 2A
Max. switchable power 500 VAac
Transmission support mono-mode optical Transmission range level 0 ÷ -25 dBm (step 1 dB)
fiber (10/125 µm) Reception dynamic range 25 dB
Wavelength 1310 nm
Guaranteed attenuation 15 dB PLC channels
Low-frequency channels
Type 2/4 wires
Band 0 ÷ 4 kHz
SELTA reserves the right to apply modifications without any further notice
Impedance 600Ω bal./unbal.
or high impedance