Step2: Click on the directory named “Windows” and click on the file named
”iverilog-0.7-setup.exe” and save it.
Double click on the saved .exe file and it will begin installing. Accept all the default values.
When it asks for “PATH” just ignore it and press “OK”. Also if it pops a window saying
“searching for …” just press ‘Cancel’. If it asks you to connect to the Icarus web-page, just click
‘No’. That’s pretty much it for installation!
Step4: Make your own directory to work and copy the relevant files into it!
i) From the windows, do: Start -> run -> cmd. This brings the command prompt.
Change directory to the right place (e.g., C:\iverilog directory) by doing “cd C:\iverilog” and
press Enter.
ii) To see the list of files, do “dir/p” <Enter> The executable files are in the C:\iverilog\bin
directory.
iii) Create your own directory and copy the iverilog.exe and vvp.exe files into them. Just do:
“mkdir MyOwnDir” <Enter>. Then do,
“copy C:\iverilog\bin\*.exe C:\iverilog\MyOwnDir “ <Enter>
iv) Also, copy the sample Verilog code into your directory. Do the following,
“copy C:\iverilog\*.vl C:\iverilog\MyOwnDir” <Enter>.
ftp://download.textpad.com/pub/textpad5.3/txpeng531.exe
Step3: Run the executable by double clicking and it will install itself.
Done!!!
i) do file->save as
ii) “Save as type” is “all files *.*”
iii) File format is “UNIX”
iv) Encoding is “ANSI”