RESORTE
A través del análisis de los datos obtenidos podemos concluir que en el primer caso, mediante la ley
de Hooke el resorte ejerce una fuerza de restitución opuesta a la dirección del alargamiento y
proporcional a la cantidad de alargamiento.
Sabemos que el límite de elasticidad en un resorte nos indica que un cuerpo puede alargarse sin
perder sus características originales, pero al aplicar al resorte una masa que sobrepase ese límite de
elasticidad, el resorte tiende a deformarse y perder sus propiedades originales.
DESLIZAMIENTO.
La fuerza de rozamiento por el deslizamiento que sufre el cuerpo es proporcional a la fuerza normal
con la que se comprimen entre sí las superficies, y el coeficiente de proporcionalidad es el
coeficiente de rozamiento.
Al realizar la práctica nos percatamos que cuando se alcanza el deslizamiento inminente se produce
un cambio brusco y a partir de ahí la fuerza de rozamiento es más o menos constante, pero con
fluctuaciones.
RECOMENDACION
Al momento de utilizar el Dinamómetro debemos tomar en cuenta que este se encuentre calibrado
para la posición en que se lo vaya a utilizar pues los datos obtenidos tienen gran dependencia de ello
y si no se lo usa correctamente podemos obtener datos erróneos.
RESUMEN
DESLIZAMIENTO
In the laboratory practice about the sliding friction force, the behavior of a body with its friction
force was analyzed, in principle using the dynamometer to slide the body through a surface, in the
same way the weight of the body was manipulated increasing it with weights of a certain weight in
(gF); it was noticed as well as the traction force was increasing according to the weight of the body.
Then it was analyzed, with the same weight gain in the body, the necessary inclination so that the
body begins to slide along the contact surface, since it was discovered that for any weight the
degree of inclination of the surface does not vary, that is to say that the degree for the sliding of the
body does not depend on the weight of the body therefore the coefficient of friction would be the
same in an inclined plane when finding it by means of calculation, which is "tan (α)". And finally,
with different degrees of inclination of the surface, it was analyzed how the traction force was
changing according to the degree of inclination. We can say then that there are two types of friction
between the surfaces, which are the static and the kinetic that are in different ways but in the
practice of how to obtain them experimentally.
RESORTE
En esta experiencia mediante el uso de un resorte y varios cuerpos de masa “m” se determinó la
constante elástica k de dicho resorte. A través de tomar uno o varios de estos cuerpos a la vez y
ponerlos a oscilar, se calculó la constante elástica del resorte
In this experience through the use of a spring and various body of mass "m", its decided the elastic
constant k. Through taking one or several bodies at once and make them oscillate, the elastic spring
constant was calculated.