Bheemu Gadyal
Catia V5 Interview Question and Answers Bangalore, Karnataka, India
View my complete profile
Hi
After long time I am writing a blog again, here I am going to write ANSWERS to all my
question. Which I have asked in my earlier Blog CATIA V5 Interview Questions. Please
Followers Blog Archive
refer the link
▼ 2013 (1)
Q. What is the file extension of a part file? ▼ November (1)
Ans: File Extension of Part file is dot CATPart (.CATPart) Catia V5
Interview
Question
Q. Which are the Neutral file extensions we can use for the part file? and
Ans: IGES/igs, STEP/stp, STL, WRL, etc Answers
Q. Can you create a Block using a line/ Is it possible to extrude a Line or Open profile ► 2009 (4)
using PAD.
Ans:Yes, you can create a block using line. when you are extruding a line or any open
profile you can check thick option in Pad feature (to avoid Error message). You can Give
limit one , Limit Two and Thickness one and two. You will get Block from line and thin
sheet from any open profile.
Note: Don’t use this option to create a sheet metal part using part design.
Q. Application of Multi-pad.
Ans: Application of multi pad is to extrude profiles to different height we can use it . Please
ref the following figure-2.
Q. What the difference between Merge Rib ends and Merge ends in Rib option.
Ans: Merge rib ends will extend a solid along center curve up to the solid and merge ends
will extend a solid along profile end points to solid.
Q. What are the uses of coupling Curves and Guide curves in Loft/ Multi-section Solid.
Ans: Coupling curves are used to get number of edges on the solid and Guide curves are
used to get the shape to a solid.
http://bheemugadyal.blogspot.in/2013/11/catia-v5-interview-question-and-answers.html 1/3
11/24/2014 CATIA a Master Tool for Design.: Catia V5 Interview Question and Answers
Q. Is it possible to give a variable distance for a features in rectangular pattern.
Ans:Yes we can give a variable distance in Rectangular pattern. Select the option
Instances and Unequal spacing.
Q. what is the difference between ADD and ASSEMBLE in boolean operation. (I can
confuse any one for this question)
Ans: Please refer blog ADD and ASSEMBLE in boolean operation
Q. What is UFC?
Ans: UFC = User Feature Creation. Its again similar to Power copy
Q. Can you create Fillet with 12mm radius for a 10 X 10 X10 cube
Ans: YES use Edges to keep to create 12mm Radius fillet for 10 mm Block.
http://bheemugadyal.blogspot.in/2013/11/catia-v5-interview-question-and-answers.html 2/3
11/24/2014 CATIA a Master Tool for Design.: Catia V5 Interview Question and Answers
I hope you got all the answers for the questions. If anyone have any doubt please ask
here I ll try to answer your Questions...
No comments:
Post a Comment
Publish Preview
http://bheemugadyal.blogspot.in/2013/11/catia-v5-interview-question-and-answers.html 3/3