Anda di halaman 1dari 2

The Power of Small - Plasti-Block uses Modular Injection Molded Systems

Omachron’s modular extrusion systems extensively tested to produce Plasti-Block solid colored
rods and blocks. This new equipment is 95% smaller, uses 95% less energy, and is 75% less costly
than competitive machines. These are small, desktop systems from 1 hp to 20 hp that provide 10 to
600 lbs. per hour of melt flow.

Pontypool, Canada, January 29, 2019 --(PR.com)-- Plasti-Block brand uses a unique, modular extrusion
and injection molded systems based upon new screw, barrel and feed designs. These innovative systems
employ low-shear, high-mix, low-pressure, melt architecture with high precision, closed-loop computer
control driven by high-accuracy temperature and pressure-measurement subsystems.

The result is a compact arrangement that uses up to 95% less energy per pound of material processed and
can typically achieve a dimensionally stable product within 20 minutes of being turned on, thereby
minimizing the expense of startup and product changeover. A typical 5 hp system with the unique
auto-start sequence can easily be purged between colors with 10 to 20 pounds of material, and startup
typically requires 10 to 20 pounds of material until dimensionally stable product is being made.

These systems are small and the subsystem components are light enough to enable all maintenance to be
carried out by 1 or 2 people in minutes, not hours, without the need for a crane or other lifting equipment.

The Plasti-Block brand utilizes compact, low-pressure, low-power-consumption, low-capital-cost,


downstream equipment including dies for making thin film, sheet, profiles, tubing, pipe, corrugated pipe
and other new products. An important consequence of the low-shear, high-mix, low-pressure system is
that it results in geometrically accurate parts with little or no internal stress induced by the forming
process, yielding parts with excellent mechanical, physical, optical and chemical properties. Plasti-Block
(TM) plastic blocks, rods and other injection molded shapes can guarantee final manufactured parts to
have very tight tolerances.

An article describing innovations using to manufacture Plasti-Block products was recently featured in
Plastics Technology Products News. This article outlines the features and benefits of our amazing new
plastics processing technologies focusing on The Power of Small(TM).

www.ptonline.com/products/extrusion-compact-extruder-is-potent-energy-efficient

Page 1/2
PR.com Press Release Distribution Terms of Use
Contact Information:
Omachron Plastics Inc.
Nina Conrad
1-833-725-6257
Contact via Email
https://www.plastiblocks.com/

Online Version of Press Release:


You can read the online version of this press release at: https://www.pr.com/press-release/775614

Page 2/2
PR.com Press Release Distribution Terms of Use

Anda mungkin juga menyukai