CE-Set-1
Civil Engineering
Engineering Engineering
General Aptitude Mathematics Mechanics Solid Mechanics
15% 10% 1% 4%
Fluid Mechanics
Open channel Flow 5%
Transportation
3% Construction Material
Engineering
8% and Management
2%
Environmental
Engineering
Structural Analysis 10%
4%
Steel Structures
7% Geomatics
Reinforced Cement Engineering
Concrete 7%
2% Irrigation and
Hydrology Geotechnical
5% Engineering
17%
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
1
ME-
CE-Set-1
CE ANALYSIS-2019_Feb-10_Morning
Level of Total
SUBJECT No. of Ques. Topics Asked in Paper(Memory Based)
Ques. Marks
Engineering 1 Marks: 2
Calculus, Differential equations Moderate 10
Mathematics 2 Marks: 4
Engineering 1 Marks: 1
Trusses and frames Easy 1
Mechanics 2 Marks: 0
1 Marks: 1
Fluid Mechanics Boundary layer Moderate 5
2 Marks: 2
1 Marks: 2
Solid Mechanics Simple stress and strain Moderate 4
2 Marks: 1
Construction 1 Marks: 0
Material and 2 Marks: 1 Building materials Easy 2
Management
Environmental 1 Marks: 2 Filtration, Disinfection, Air pollution,
Tough 10
Engineering 2 Marks: 4 Sedimentation( Stokes law)
Geomatics 1 Marks:1 Levelling, Curve, Triangulation survey,
Moderate 7
Engineering 2 Marks: 3 Chain survey
Geotechnical 1 Marks: 5
Bearing Capacity Tough 17
Engineering 2 Marks: 6
Irrigation and 1 Marks: 3
Direct Run off Moderate 5
Hydrology 2 Marks: 1
Reinforced 1 Marks: 2
Singly reinforced beam Moderate 2
Cement Concrete 2 Marks: 0
1 Marks: 3
Steel Structures Welding Moderate 7
2 Marks:2
Structural 1 Marks: 0
Slope and Deflection Moderate 4
Analysis 2 Marks:2
Transportation 1 Marks: 2
Geometric design , Traffic design Moderate 8
Engineering 2 Marks:3
Open channel 1 Marks: 1
Manning’s formula, Critical analysis Moderate 3
Flow 2 Marks:1
1 Marks: 5 Data interpretation, Height and distance,
General Aptitude Moderate 15
2 Marks:5 Grammar, Blood relation, Percentage
Total 65 100
Overall paper was medium level difficulty.
Faculty Feedback
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
2
ME-
CE-Set-1
Civil Engineering
General Aptitude
Q.1 - Q.5 Carry One Mark each.
1. If E = 10, J = 20, O = 30, T = 40, then what will be the value of P + E + S + T ?
(A) 51
(B) 120
(C) 82
(D) 164
[Ans. B]
2. The lecture was attended by quite _________ students, so the hall was not very __________.
(A) A few, quite
(B) Few, quiet
(C) A few, quiet
(D) Few, quite
[Ans. C]
H
ladder
H
5 45°
6m
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
3
ME-
CE-Set-1
(A) 15
(B) 25
(C) 30
(D) 35
[Ans. C]
5. They have come a long way in __________ must among the users.
(A) Created
(B) Create
(C) Creating
(D) Creation
[Ans. *]
7. In a college, total students are 300. Out of which 105 plays Cricket only, 70 plays Hockey
only, 50 plays Football only, 25 plays both Cricket and Hockey only, 15 plays both Hockey
and Football only, 30 plays both Cricket and Football only and rest of the students plays all
sports. What is the percentage of people who play at least two game?
(A) 50
(B) 25
(C) 23.30
(D) 28
[Ans. B]
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
4
ME-
CE-Set-1
8. P, Q, R, S and T are the member of same family. P is the brother of S. Q is wife of P. R and T
are children of the siblings P and S respectively
Which of the following STATEMENT is FALSE:-
(A) S is sister – in – law of Q
(B) S is brother of P
(C) S is aunt of R
(D) S is aunt of T
[Ans. D]
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
5
ME-
CE-Set-1
Technical
Q.1 - Q.25 Carry One Mark each.
1. In a rectangular channel ratio of velocity head to flow depth for critical flow condition is
(A)
(B)
(C)
(D) 1/2
4. A sample of air analyzed at °C and 1 atmosphere pressure is reported to obtain 0.02 ppm
of o . Assume the gram molecular mass of o as 46 and its volume at °C and 1
atmosphere as 22.4 litres per mole. The equivalent concentration (in microgram per
cubic meter).
5. In a plane sedimentation tank having dimension L=32m B=8m, H=4m, diameter of the
soild particles is 5 m then find the removal efficiency .
5, gm⁄cc gm cm s m s
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
6
ME-
CE-Set-1
7. If f is the friction factor and G is gradient then what will be the percentage increment in
breaking distance if %G is increased by 2 times, ___________
f
f
6
f
f
C
f
8. Normal strain at a plane is 0.003 and 0.002. Find the normal strain on a plane of maximum
shear stress.
[Ans. *]Range: 0.0025 to 0.0025
ormal strain
5
9. Which is correct?
sin4x tanx
lim ( ) and lim ( )
sin x x
sin4x tanx
lim ( ) and lim ( )
sin x x
sin4x tanx
C lim ( ) and lim ( )
sin x x
sin4x tanx
lim ( ) and lim ( )
sin x x
[Ans. D]
10. In disinfection unit for 99% efficiency with a chlorine dosage of 37mg/l yields the model
e t time required in min, min for a flow rate 6 m hr, if width
1m and depth=1.5m. Calculate the length in ‘m’.
11. The probability of the flood of magnitude m s is to occur ones is 0.25. What is the
return period of the given flood?
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
7
ME-
CE-Set-1
13. A concentrate load of 500kN applied on a elastic half space. What will be the ratio of
increase in vertical normal stress at 2m 4m depth as per boussinesq theory
14. If the percentage air voids is zero, specific gravity of solid is 2.65, majeure content is 10% ,
unit at of water is g m , then dry density of soil in g m
15. Laplace equation for a isotropic soil medium if flow is in x and z direction and head is H
17. Maximum number of vehicle in 5minute period during peak hour is 160. If total flow in
peak hour is 1000vechicle , so the 5 minute peak hour factor will be__________
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
8
ME-
CE-Set-1
26. B=5m, slope=0.001. for a uniform flow and depth 2m and velocity 2m/s manning
Moughness coefficient =? (Rectangular channel)
(A) 0.002
(B) 0.050
(C) 0.033
(D) 0.017
27. A survey line measured to be 285.5m length with a tape of nominal length 30m. On
checking, the true length was found to be 0.05m too short. If line lay on a slope of 1 in 10.
The reduced length of line for plotting survey work
(A) 285
(B) 283.6
(C) 285.6
(D) 284.5
28. A 6 eh hour. Find probability that time headway will be between 6 to 10 seconds
for 2 successive vechicle.
30. A 1-D domain is discretized into N sub ordinate of width x with node number i=0, 1, 2,
…… and the time scale is discretized in steps of t, the forward time and centered space
finite differentiate approximation at ith node and nth time step, for partial differential
equation
v v
t x
v v v v v
[ ]
t x
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
9
ME-
CE-Set-1
v v v v v
[ ]
t x
v v v v v
C [ ]
t x
v v v v v
[ ]
t x
34. For a given become shown below. What is the nominal cover provided as per IS-456 2000.
8mm∅
5 mm
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
10
ME-
CE-Set-1
35. Calculate the vertical reaction forces , and for the given truss.
m
m
m
36. The average free flow speed is 60kmph and jam density is 120 vehicle/hour. The
maximum flow on the road will be _____________
37. Tie bar of 12mm diameter are provided in cement concrete slab. The working tensile and
stress on the bar is 230MPa, average bond stress between tie bar and concrete 2MPa ,
Joint gap between slab is 10mm. by ignoring the tolerance factor and bondless. Find the
length of tie bar in mm.
38. If a retaining wall is subjected to inclined surcharge then find the correct statement for
active earth pressure on wall
(A) act at H from base at angle with horizontal
(B) act H/2 from base at angle with horizontal
(C) act at H/2 from base at angle with horizontal
(D) act at H/3 from base at angle with horizontal
[Ans. D]
39. A square footing having width 4m and depth 1m is placed on soil whose ultimate bearing
capacity is 600kpa, 8 75, depth factor d d and unit wait of 5 m
What will be safe bearing capacity for same square footing if placed 2m below the G/L for
fos=3
[Ans. *]Range: 270 to 270
4
6 5 ( ) 4 5 4 8 75
For 2m depth
q
q
os
( 4 )
q
os
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
11
ME-
CE-Set-1
5 4 5 4 8 75 5
q 5
7 m
40. Find the safe slope angle for Fos=1.5 for a slope on which seepage is occurring parallel to
the free surface at lope. Saturated unit wt m effective friction angle od
soil °
Unit at of water 9 8 m
[Ans. *]Range: 10.63 to 10.63
41. Find the net ultimate pull out load for RCC pile having m 6 unit cohesion of
clay m adhesion factor=0.5
[Ans. *]Range: 1328.25 to 1328.25
pallout load rictional load
̅C
5 6 ( 5 6 )
4
44 7 84 78
8 85
Don’t Wait! Know Your GATE Rank with GATE Rank Predictor. Predict Now, http://bit.ly/grp2019
: 080-4061 1000, info@thegateacademy.com ©Copyright reserved. Web:www.thegateacademy.com
12