A. 40 B. 48
C. 96 D. 12
Answer: Option A
Explanation:
A. ideal B. saturated
C. supersaturated D. azeotropic
Answer: Option D
Explanation:
Answer: Option C
Explanation:
A. Torr
B. Newton/m2
C. Parsec
Answer: Option C
Explanation:
B. remain unchanged.
Answer: Option B
(B)
1. One mole of methane undergoes complete combustion in a stoichiometric amount of air. The
reaction proceeds as CH4 + 2O2 → CO2 + 2H2O. Both the reactants and products are in gas phase.
ΔH°298 = - 730 kJ/mole of methane. Mole fraction ofwater vapour in the product gases is about
A. 0.19 B. 0.33
C. 0.40 D. 0.67
Explanation:
A. weight percent.
B. mole percent.
Answer: Option D
Explanation:
3. Compressibility factor of a real gas is the ratio of the actual volume to that predicted by ideal gas
law. As the pressure of the gas approaches zero, the compressibility factor approaches
A. ∞ B. 0
C. 1 D. 0.24
Answer: Option C
Explanation:
4. Cp equals Cv at
A. 0°C B. 0°K
C. 0°F D. 0°R
Answer: Option B
Explanation:
Both the freezing point as well as boiling point of sea water is more than that of
B.
distilled water.
The solution containing equal masses of two liquids 'X' and 'Y' has the same mole
C.
fraction of' 'X' and 'Y'.
Answer: Option D
(C)
A. Heat of vaporisation
B. Melting point
C. Heat of fusion
Answer: Option D
Explanation:
No answer description available for this question. Let us discuss.
2. The heat capacity of a solid compound is calculated from the atomic heat capacities of its
constituent elements with the help of the
A. Trouton's rule
B. Kopp's rule
C. Antonie equation
D. Kistyakowsky equation
Answer: Option B
Explanation:
A. 1 B. 2
C. 3 D. unpredictable
Answer: Option C
Explanation:
4. The increase in the temperature of the aqueous solution will result in decrease of its
D. molality.
Answer: Option C
Explanation:
A. NH3 B. CO2
C. H2S D. CH4
Answer: Option A
(D)
A. kg of solute/kg of solvent
Answer: Option D
Explanation:
C. 1 D. 10
Answer: Option C
Explanation:
A. Kirchoffs B. Maxwell's
C. Antonie D. Kistyakowsky
Answer: Option A
Explanation:
4. Which of the following has the smallest least effect on the solubility of a solute into the solvent ?
C. Temperature
D. Pressure
Answer: Option D
Explanation:
No answer description available for this question. Let us discuss.
A. 1
B. 2.42
C. 4.97
D. none of these
Answer: Option A
(E)
1. No cooling occurs, when an ideal gas undergoes unrestrained expansion, because the molecules
Answer: Option C
Explanation:
2. With increase in the solute concentration, the specific heat of aqueous solutions
A. increases
B. decreases
C. remains unchanged
D. either (a) or (b); depends on the type of solution
Answer: Option B
Explanation:
Answer: Option A
Explanation:
A. nature of solvent
B. concentration of solution
C. nature of solute
Answer: Option D
Explanation:
5. The molar composition of a gas is 10% H2, 10% O2, 30% CO2 and balance H2O. If 50% H2O
condenses, the final mole percent of H2 in the gas on a dry basis will be
A. 10% B. 5%
C. 18.18% D. 20%
Answer: Option D
(F)
1. The heats of vaporisation of CS2, C2H5OH &H2O are 26.8, 38.6 & 40.6 KJ/kg mole respectively.
The order of decreasing inter-molecular forces in these liquids is
Answer: Option A
Explanation:
2. A liquid is in equilibrium with its vapor at its boiling point. On an average, the molecules in the
liquid and gaseous phases have equal
A. kinetic energy.
C. potential energy.
D. total energy.
Answer: Option A
Explanation:
3. Pure aniline is evaporating through a stagnant air film of 1 mm thickness at 300 K and a total
pressure of 100 KPa. The vapor pressure of aniline at 300 K is 0.1 KPa. The total molar
concentration under these conditions is 40.1 mole/m3 . The diffusivity of aniline in air is 0.74xl0-
5 2
m /s.The numerical value of mass transfer co-efficient is 7.4 x 10-3. Its units are
A. m/s B. cm/s
C. mole/m2.s.Pa D. kmole/m2.s.Pa
Answer: Option C
Explanation:
4. If 1.5 moles of oxygen combines with aluminium to form Al2O3, then the weight of aluminium
(atomic weight = 27 ) used in this reaction is __________ gm.
A. 27 B. 54
C. 5.4 D. 2.7
Answer: Option B
Explanation:
A. stoke
B. poise
C. gm/cm sec.
Answer: Option D
(G)
1. One kg of saturated steam at 100°C and 1.01325 bar is contained in a rigid walledvessel. It lias a
volume of 1.673 m3. It cools to 98°C ; the saturation pressure is 0.943 bar ; one kg
of water vapour under these conditions has a volume of 1.789 m3. The amount of water vapour
condensed (in kg) is
A. 0.0 B. 0.065
C. 0.1 D. 1.0
Answer: Option B
Explanation:
2. Which of the following holds good for a solution obeying Raoult's law (i.e., an ideal solution)
(where, ΔH = heat of mixing, and ΔV = volume change on mixing ) ?
A. ΔH = 1 (+ ve)and Δ V = -ve
B. ΔH = 0
C. ΔV = 0
Answer: Option D
Explanation:
B. (P + a/V2)(V-b) = RT
C.
D.
Answer: Option C
Explanation:
A. normality B. molarity
C. molality D. formality
Answer: Option C
Explanation:
B. 50 - 200 microns
D. 10 - 50 Angstrom
Answer: Option A
(H)
1. Colligative properties of a dilute solution are those which depend entirely upon the
D. none of these.
Answer: Option A
Explanation:
2. For an ideal solution, the total vapor pressure varies __________ with thecomposition(expressed
as mole fraction).
A. inversely B. exponentially
C. linearly D. negligibly
Answer: Option C
Explanation:
No answer description available for this question. Let us discuss.
Atomic heat capacities of all solid elements decrease greatly with decrease in
B. temperature, approaching a value of zero at absolute zero temperature, when in the
crystalline state.
Generally, the heat capacities of compounds are lower in the liquid than in the solid
C.
state.
Answer: Option C
Explanation:
4. Measurement of the amount of dry gas collected over water from volume of moist gas is based on
the
A. Charle's law.
C. Avogadro's hypothesis.
D. Boyle's law.
Answer: Option B
Explanation:
Answer: Option A