SEVENTH Semester B. E. Degree (Autonomous) Semester End Examination, SEE, Dec 2018
Design of Steel Structures
Maximum Time: 3 Hours MODEL QUESTION PAPER-I Maximum Marks: 100
Instructions to Candidates:
(i) Answer FIVE FULL Questions.
(ii) Assume missing data if any.
(iii) Use of IS: 800 and SP 6(1) /Steel tables is
permitted.
c) Find the efficiency of the lap joint shown in Figure 1(c). Use HSFG M20 bolts of [10 Marks]
property class 8.8. Take ultimate tensile strength of steel as 410 MPa.
Figure 1(c)
OR
2. a) Explain Briefly, Limit State Design philosophy for Steel structures [06 Marks]
Figure 2(c)
3. a) What are the advantages and disadvantages of welded connections? [08 Marks]
b) An I section bracket is connected to a column by welds as shown in Figure 3(b). [12 Marks]
Determine the load W which can be safely carried. The permissible stress in the weld is
110 N/mm2. The size of weld is 10 mm.
Figure 3(b)
OR
4 a) Explain the types of welds. [05 Marks]
b) Two plates are connected to form a fillet joint using 6mm weld. Welding is provided on [15 Marks]
three sides with a lap of 300mm as shown in Figure 4(a). Find the strength of the joint.
If welding is provided on all four sides Figure 4(b), determine the strength of the joint.
Also find the percentage increase in the strength. Use Fe 410 steel with yield stress 250
MPa. Assume shop welding.
Figure 4(b)
b) Write a short note on failure of tension members with sketches. [06 Marks]
c) Design a single angle tension member to carry a design tensile load of 200 kN. Gusset [10 Marks]
plate is of 6mm thickness. Adopt 20 mm diameter black bolt for connection.
OR
6 a) Design a column using two ISHB sections to carry an axial service load of 3000 kN. [20 Marks]
The column is restrained against translation at both ends, but not restrained against
rotation. Unsupported height of the column = 4 m. Design a suitable lacing and batten
system. Design the simple slab base connection on a concrete pedestal of M30 grade.
Grade of steel is Fe410. Sketch the details.
7 a) Design a gusseted base and a on a concrete pedestal for a column to carry a factored [20 Marks]
axial load 3000kN. The column is ISHB 400@ 759.3 N/m with two cover plates 250 X
20mm on either side. The column is to be supported on concrete pedestal to be built
with M25 concrete.
OR
8. a) Write a short note on laterally supported beams. [04 Marks]
9 a) Explain upper bound, lower bound and uniqueness theorems. [10 Marks]
b) Determine the plastic moment capacity and shape factor of the section shown in Figure [10 Marks]
9(b)
Figure 9(b)
OR
10. a) Explain the plastic analysis of structures. What do you understand by “Plastic hinge”? [06 Marks]
b) With neat sketches, explain different mechanisms considered in plastic analysis of [04 Marks]
structures.
c) Analyze the continuous beam ABC subjected to working loads shown in Figure 10(c) [10 Marks]
and determine the plastic moment. Adopt load factor of 1.70.
30kN 30kN
20kN/
B 2 2 C
m
A 2M m m
6 6
M p
m m
pu
re Figure 10(c)
10
(c)
*******