SECTION 1. IDENTIFICATION
Product Identifier Injector Cleaner, Gas Treatment
Other Means of 55-733PRES, 55-713PRES, 55-610F1, 55-613F1, 55-727PRES
Identification
Recommended Use Please refer to Product label.
Restrictions on Use None known.
Manufacturer/Supplier Recochem Inc., 850 Montee de Liesse, Montreal, QC, H4T 1P4, Compliance and Regulatory
Identifier Department, 905-878-5544, www.recochem.com
Emergency Phone No. CANUTEC, 613-996-6666, 24 Hours
SDS No. 1824
Signal Word:
Danger
Hazard Statement(s):
Flammable liquid and vapour.
May be fatal if swallowed and enters airways.
Causes skin and eye irritation.
May cause respiratory irritation.
May cause drowsiness or dizziness.
May cause genetic defects.
Suspected of causing cancer.
May cause damage to organs (nervous system) through prolonged or repeated exposure if inhaled.
Precautionary Statement(s):
Prevention:
Obtain special instructions before use.
Do not handle until all safety precautions have been read and understood.
Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking.
Keep container tightly closed.
Ground and bond container and receiving equipment.
Use explosion-proof electrical, ventilating, and lighting equipment.
Use only non-sparking tools.
Take precautionary measures
Product Identifier:
against static discharge.
Injector Cleaner, Gas Treatment - Ver. 1 SDS No.: 1824
Do not breathe fume, mist, vapours, spray.
Date of Preparation: April 25,after
2017handling.
Wash hands and skin thoroughly
Date of Last
Use only Revision:
outdoors or in a well-ventilated area. Page 01 of 10
Avoid release to the environment.
Wear protective gloves, eye protection, face protection.
Ground and bond container and receiving equipment.
Use explosion-proof electrical, ventilating, and lighting equipment.
Use only non-sparking tools.
Take precautionary measures against static discharge.
Do not breathe fume, mist, vapours, spray.
Wash hands and skin thoroughly after handling.
Use only outdoors or in a well-ventilated area.
Avoid release to the environment.
Wear protective gloves, eye protection, face protection.
Response:
IF SWALLOWED: Immediately call a POISON CENTRE or doctor.
Do NOT induce vomiting.
IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water or shower.
Call a POISON CENTRE or doctor if you feel unwell.
If skin irritation occurs: Get medical advice or attention.
Take off contaminated clothing and wash it before reuse.
IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Call a POISON CENTRE or doctor if you feel unwell.
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do.
Continue rinsing.
Call a POISON CENTRE or doctor if you feel unwell.
If eye irritation persists: Get medical advice or attention.
In case of fire: Use appropriate foam, carbon dioxide, dry chemical powder, water spray or fog to extinguish.
Collect spillage.
Storage:
Store in a well ventilated place. Keep cool. Keep container tightly closed. Store locked up.
Disposal:
Dispose of contents/container in accordance with applicable regional, national and local laws and regulations.
Other Hazards
None known.
Source: Health Canada - Technical Guidance on the Requirements of the Hazardous Products Act and the Hazardous
Products Regulations WHMIS 2015 Supplier Requirements - pg 117
Product Identifier: Injector Cleaner, Gas Treatment - Ver. 1 SDS No.: 1824
Date of Preparation: April 25, 2017
Date of Last Revision: Page 03 of 10
Suitable Extinguishing Media
Carbon dioxide, dry chemical powder, appropriate foam, water spray or fog.
Unsuitable Extinguishing Media
None known.
Specific Hazards Arising from the Product
Flammable liquid and vapour. Can ignite at room temperature. Releases vapour that can form explosive mixture with
air. Can be ignited by static discharge. Can accumulate static charge by flow, splashing or agitation. Liquid can float on
water and may travel to distant locations and/or spread fire. See Section 9 (Physical and Chemical Properties) for flash
point and explosive limits. Closed containers may rupture violently when heated releasing contents.
In a fire, the following hazardous materials may be generated: irritating chemicals; toxic chemicals; very toxic carbon
monoxide, carbon dioxide.
Special Protective Equipment and Precautions for Fire-fighters
Review Section 6 (Accidental Release Measures) for important information on responding to leaks/spills.
See Skin Protection in Section 8 (Exposure Controls/Personal Protection) for advice on suitable chemical protective
materials.
Product Identifier: Injector Cleaner, Gas Treatment - Ver. 1 SDS No.: 1824
Date of Preparation: April 25, 2017
Date of Last Revision: Page 04 of 10
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Control Parameters
ACGIH TLV® OSHA PEL AIHA WEEL
Chemical Name TWA STEL TWA Ceiling 8-hr TWA TWA
Stoddard solvent 100 ppm Not 100 ppm Not
established established
Naphthalene 10 ppm A3 Not 10 ppm 15 ppm
established
n-Nonane 200 ppm Not 200 ppm Not
established established
1,2,4-Trimethylbenzene 25 ppm Not 25 ppm Not
established established
Hydrotreated kerosene 200 mg/m3 Not Not Not
A3 established established established
Solvent naphtha 10 ppm 15 ppm 400 ppm 15 ppm
Distillates (petroleum), hydrotreated Not Not Not Not
middle established established established established
Appropriate Engineering Controls
General ventilation is usually adequate. For large scale use of this product: use local exhaust ventilation, if general
ventilation is not adequate to control amount in the air. Use non-sparking ventilation systems, approved explosion-proof
equipment and intrinsically safe electrical systems in areas where this product is used and stored. Control static
electricity discharges which includes bonding of equipment to ground. Use only non-combustible, compatible materials
for walls, floors, ventilation system, air cleaning devices, pallets, shelving. Provide eyewash and safety shower if
contact or splash hazard exists.
Individual Protection Measures
Eye/Face Protection
Wear chemical safety goggles.
Skin Protection
Wear chemical protective clothing e.g. gloves, aprons, boots.
Respiratory Protection
Not normally required if product is used as directed. For non-routine or emergency situations: wear a NIOSH
approved air-purifying respirator with an appropriate cartridge.
Chemical Name NOEC Fish EC50 Fish NOEC Crustacea EC50 Crustacea
Stoddard solvent Not available Not available
Naphthalene 1.8 mg/L Not available
(Oncorhynchus
mykiss (rainbow
trout); 3 days; fresh
water)
n-Nonane Not available Not available
1,2,4-Trimethylbenzene Not available Not available
Hydrotreated kerosene Not available Not available
Solvent naphtha Not available Not available
Persistence and Degradability
No information was located.
Bioaccumulative Potential
No information was located.
Mobility in Soil
No information was located.
Other Adverse Effects
There is no information available.
Product Identifier: Injector Cleaner, Gas Treatment - Ver. 1 SDS No.: 1824
Date of Preparation: April 25, 2017
Date of Last Revision: Page 08 of 10
There is no information available.
Product Identifier: Injector Cleaner, Gas Treatment - Ver. 1 SDS No.: 1824
Date of Preparation: April 25, 2017
Date of Last Revision: Page 10 of 10