14 Preliminary Supports
The Piping Designer can create Preliminary Supports in a support zone to which they have been given
access, the Support Designer can use these Preliminary Supports and convert them into Ancillary Supports.
To Create a Preliminary Support, click on the Preliminary button in the Create group on the SUPPORTS
tab.
Preliminary Supports are created in exactly the same way as Stand Alone Supports.
Login to the Training Project as Piping Designer typically A.PIPER password A and MDB A-PIPING
From the Model Explorer add pipe 150-A-3 and Structure PIPERACK to the 3D view.
ZONE-PRELIMINARY-SUPPORTS-AREA01
Click on the Preliminary button in the Create group and from the displayed gallery, select Anchor.
Copyright © 2015.
AVEVA Solutions Limited and its subsidiaries.
www.aveva.com
All rights reserved.
110
AVEVA Everything3D™ (2.1)
Supports TM-1818
Click the Position Through button to align the support with the
steelwork.
Copyright © 2015.
AVEVA Solutions Limited and its subsidiaries.
111
www.aveva.com
All rights reserved.
AVEVA Everything3D™ (2.1)
Supports TM-1818
Select Graphics from the Setting Group on the VIEW Tab, Select
the Representation Tab and 50% from the Obstruction
Pulldown and Apply and Cancel.
Copyright © 2015.
AVEVA Solutions Limited and its subsidiaries.
www.aveva.com
All rights reserved.
112
AVEVA Everything3D™ (2.1)
Supports TM-1818
Login to the Training Project as Support Designer typically A.SUPPORTMAN password A and MDB A-
SUPPORT
Alternatively the login User can be changed using the Training Setup, switch the user to A.SUPPORTMAN
from the Setup Tools tab on the Training Setup form, The Training Setup Form is available by Selecting
Setup from the Training group of the TOOLS Tab.
From the Model Explorer add Structure PIPERACK and pipe 150-A-3 to the 3D view.
Copyright © 2015.
AVEVA Solutions Limited and its subsidiaries.
113
www.aveva.com
All rights reserved.
AVEVA Everything3D™ (2.1)
Supports TM-1818
In the Supports Application make sure that the support creation zone in the Storage Area is set to ZONE-
PRELIMINARY-SUPPORTS-AREA01
Pick A-ANCHOR in the 3D view, select the Anchor type from the Stand Alone Supports gallery.
Select XAN07 from the Ancillary Selection form and click OK.
Copyright © 2015.
AVEVA Solutions Limited and its subsidiaries.
www.aveva.com
All rights reserved.
114
AVEVA Everything3D™ (2.1)
Supports TM-1818
From the Stand Alone Supports list, select Anchor rather than Guide.
Select XAN07.
Select the Guide type from the Stand Alone Supports gallery.
Copyright © 2015.
AVEVA Solutions Limited and its subsidiaries.
115
www.aveva.com
All rights reserved.
AVEVA Everything3D™ (2.1)
Supports TM-1818
Copyright © 2015.
AVEVA Solutions Limited and its subsidiaries.
www.aveva.com
All rights reserved.
116
AVEVA Everything3D™ (2.1)
Supports TM-1818
1. Using the above example add some typical Preliminary Supports to the Design and convert them to
Ancillary supports.
Copyright © 2015.
AVEVA Solutions Limited and its subsidiaries.
117
www.aveva.com
All rights reserved.