Electrical
Section 2D - Accessory Wire Diagrams
Table of Contents 2
D
Boat Sensor....................................................................... 2D-2 Digital Speedometer Harness Test.............................2D-3
Boat Sensor Harness Test......................................... 2D-2 Digital Block Water Pressure (Optional Sensor)................2D-5
Digital Speedometer (Optional Sensor) ............................ 2D-3
Special Tools
DMT 2004 Digital Multimeter 91‑892647A01
TEMP
A mA COM V Hz
4516
Boat Sensor
The boat sensor harness connector is a junction location for sensors external of the engine operations. These external sensors
may include: depth, paddle wheel for low speeds, seawater temperature, fuel, and water levels and is most useful when
incorporating SmartCraft gauges, GPS, and chart plotter technologies.
a
1 18 34 51
67
68
GRY/DK BLU
b
69
70
17 33 50 66
48967
a - ECM connector
b - Boat sensor connector
a - Speedometer hose
b
b - Electrical cover
c - Digital speedometer
a sensor
d - Engine harness
connector
c d
49492
NOTE: All accessory sensor ground wires are 5 volts negative. They are spliced together and connect to the ECM at pin
10. All accessory sensor power wires are 5 volts positive. They are spliced together and connect to the ECM at pin 51.
Unless there are multiple sensor failures, the most likely failure would be at the splice point, connector, or between the
connector and the splice point.
d a- ECM connector
b- Speedometer sensor connector
c- Pin 1 (black/green)
c d- Pin 3 (white/orange)
e e- Pin 2 (purple/black)
b
1 18 34 51
67
a
68
69
70
66 48930
17 33 50
49494
1. Disconnect the digital block water pressure sensor from the engine harness digital block water pressure sensor connector.
2. Perform a visual inspection of the engine harness digital block water pressure sensor connector pins and the wires coming
from the connector. Look for broken, bent, or corroded pins.
3. Disconnect the engine harness from the ECM.
4. Use the DMT 2004 digital multimeter to perform an ohm check of the wiring between the engine harness boat sensor
connector and the ECM connector.
NOTE: All engine sensor ground wires are 5 volts negative. They are spliced together and connect to the ECM at pin 42.
All accessory sensor power wires are 5 volts positive. They are spliced together and connect to the ECM at pin 34. Unless
there are multiple sensor failures, the most likely failure would be at the splice point, connector, or between the connector
and the splice point.
d a - ECM connector
b - Digital block water pressure sensor
connector
c - Pin 1 (black/orange)
e d - Pin 3 (white/green)
c e - Pin 2 (purple/yellow)
b
1 18 34 51 a
67
68
69
70
17 33 50 66
48937