Anda di halaman 1dari 1

PT.

ZUG INDUSTRY INDONESIA


RUN SHEET
Run Sheet No.: :004/VII/RS/2014 WPS No. : 001/WPS/SMAW R1 Welding Process : SMAW Weld Date : 8 July 2014 Others Information
SOP No. : - Base Metal : SA 516 Gr. 70 Coupon No. : 004 Page : 1 of 1
Consumable Used Heating Electrical Parameter Unit : mm
No Process Welder ID Layer No Weld Time Total Filler Flux Gas (Average) Heat Input Wire feet speed Travel speed
Diameter Spec/SFA Class Brand Spec Class Brand Type % Mix Preheat (°C) Interpass (°C) Voltage Amphere AC DC Transfer Mode (mm/min) (mm/min)
1 SWAW Indra root 17 min 2.6 5.1 E7016 Kobelco N.A N.A N.A N.A N.A 32 - 20 73 - EP N.A 3020.68966 N.A 29

(Z 86) fill 14 min 3.2 5.1 E7016 Antlantic N.A N.A N.A N.A N.A 79 117 19 104 - EP N.A 3120 N.A 38

fill 13 min 3.2 5.1 E7016 Antlantic N.A N.A N.A N.A N.A 87 109 19 103 - EP N.A 2935.5 N.A 40

cap 12 min 3.2 5.1 E7016 Antlantic N.A N.A N.A N.A N.A 56 121 19 99 - EP N.A 2821.5 N.A 40

Note :

- Calculating Heat Input using formula in QW-409.1 (a)

- Dimension of test coupon = L. 270 x W. 280 x t. 12

1. Visual Examination 2. Non Destractive Examination


Defect Type Welding Area Examined by Approved by Type of Test : Radiography Test Tested by Approved by
Location Size (mm) Test Result : ACC
- - - Ade Ruhiyat Welding Engineer Abdul Djalal Welding Engineer
SEE ATTACHMENT

3. Destructive Examination
TENSILE TEST CHARPHY TEST BEND TEST
Speciment No Size Area Load Tensile Stress Speciment Defect Remarks
Speciment No Location No Energy
Width (mm) Thicness (mm) (mm2) (kgf) (kgf/mm) (Mpa) (PSI) No Type Size
- - - - - - - - - - - - - - - - - - -
SEE ATTACHMENT - - - - - - SEE ATTACHMENT
- - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - -

4. Judgement
PASS RE-TEST FAIL

Supervised by Accepted by Approved by

(QC Inspector) (QC. Engineer) (Welding Engineer)

Anda mungkin juga menyukai