Sintering is done to
a) Decrease final strength
b) Decrease strength
c) Increase final strength
d) None of the mentioned
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
In the zone melting method _____________ of the charge is melted at any one time. Fill up the
correct option for the blank space from the choices given below.
a) Large part
b) Small part
c) Solid part
d) Anionic part
17.
Which one of the following principle has been used in the zone melting method?
a) Impurities concentrate in the solid than in liquid phase
b) Impurities concentrate in the liquid phase than in gaseous phase
c) Impurities concentrate in the liquid phase than in the solid phase
d) Impurities concentrate in the gaseous phase than in the solid phase
18.
19.
Which of the following method is used to make powder for brittle metals?
a. Mechanical pulverisation b. Electrolytic process c. Chemical reduction d. Atomization
20.
(a) soft material (b) hard material (c) burnt material (d) dry material
21.
(a) high temperature stability (b) high mechanical strength (c) low elongation (d) low hardness
22.
Major ingredients of traditional ceramics
23.
24.
25.
26.
(a) strength without grain growth (b) lost cost (c) zero porosity (d) processing refractory ceramics
27.
(a) atomic diffusion (b) surface diffusion (c) bulk diffusion (d) grain growth
28.
The process producing a relatively coarse powder with a high percentage of oxide is
a. atomizing b. gaseous reduction c. granulation d.
carbonyl
29.
What is graphene?
A. A new material made from carbon nanotubes
B. A one-atom thick sheet of carbon
C. Thin film made from fullerenes
D. A software tool to measure and graphically represent nanoparticles
30.
31.
32.
33.
(a) Glass fibers (b) Carbon fibers (c) Aramid fibers (d) Cermets