KENR7078-01
Normally open switch that is closed due to an applied condition, and will open again with a
172 GN Air Pressure/Joint Cutter 606 GY RH Turn Lamps CONN 8 P2 & R2 E-5 30
specific decrease in that condition. 325-PK-14 1 325-PK-14
173 YL Flasher 608 GN Rear Flood Lamps CONN 9 R34 & P34 B-8, E-5 31
177 RD Main Breaker 614 PU Dash Lamps CONN 10 R16 & P16 E-4 32 Wire
Pin Socket
181 GY Timer Module 619 GN Front Flood Lamps
The connectors shown in this chart are for harness to harness connectors.
Color
185 YL Air Compressor Control Circuits Connectors that join a harness to a component are generally located at or near Normally closed switch that will open with an increase of a specific condition.
Ground Circuits 751 GN Speed Switch to 1st Speed Solenoid the component. See the Component Location Chart.
20 Page, KWG
200 BK Main Chassis 777 PU Speed Switch to 2nd Speed Solenoid 2 200-BK-14
Basic Machine Circuits 810 BR Start Aid Switch
304 WH Starter Relay No. 1 Output 4983 BU Throttle Cont. Solenoid Normally closed switch that is open due to an applied condition, and will close again
Circuit Number Wire
306 GN Starter Relay Coil A919 BU Throttle Cont. Solenoid with a specific decrease in that condition. Identification
Key Switch to Relay #4 Throttle Switch
Gauge
307 OR A982 BR
308 YL Main Power Relay Coil A983 BU Throttle Cont. Solenoid
309 GY Alt. Output [R] Term. To Alternator Lamp C720 BU Neutral Start Relay
The circle indicates that the component has screw terminals and a wire can be disconnected Electrical Schematic Symbols And Definitions
321 BR Backup Alarm to Backup Alarm Pressure Switch C922 BR Water Spray Switch
Warning Horn Forward
from it.
322 GY
FUSE - A component in an electrical circuit that will open the circuit if too much current flows
through it.
No circle indicates that the wire cannot be disconnected from the component.
REED SWITCH - A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Sender and Solenoid Specifications SENDER - A component that is used with a temperature or pressure gauge. The sender
This indicates that the component has a wire connected to it that is connected to ground. measures the temperature or pressure. Its resistance changes to give an indication to the
Part No. Component Description Resistance (Ohms)¹
T gauge of the temperature or pressure.
030-2010 Sender- Engine Oil Pressure 10.5 ± 5.5
Engine Coolant Temperature Sender 5806 - 7246 @ 54.4°C
6N-5926 Sender-
Hydraulic Temperature Sender 524 - 586 @ 115.6°C
216-2035 Solenoid- Traction Control 30.3 RELAY (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
This indicates that the component does not have a wire connected to ground. It is grounded
2 Speed Switch It has a coil that makes an electromagnet when current flows through it. The electromagnet
1G-9759 Solenoid- 27.3 by being fastened to the machine.
Brake Switch can open or close the switch part of the relay.
Pull In: .66
160-7396 Solenoid- Throttle Cont.
Hold: 50
¹ At room temperature unless otherwise noted. CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will open the circuit if too
much current flows through it. This does not destroy the circuit breaker and it can be reset to
become part of the circuit again.
614-PU
HARNESS AS
144-9012
I I
200-BK
200-BK
200-BK
HOUR
123-WH
200-BK
123-WH
200-BK
123-WH
200-BK
123-WH
METER
6T-7337
185-YL
172-GN
2 1
AIR COMPRESSOR
- + - + - + - 200-BK - +
AIR COMPRESSOR
SWITCH
GROUND 8D-2676
ENG HOT 448-WH
SIG ENG SIG SIG SPEED SIG AIR DISTRIBUTION
2 1
SIG
OIL OIL
COOLANT TACH VALVE
PRESSURE TEMP
120-3964
406-PU 172-GN AIR DISTRIBUTION
2 1
440-BR
403-GN VALVE
200-BK
AIR DISTRIBUTOR
449-WH
441-OR SWITCH
1V-6652
200-BK
476-PU
403-GN
112-PU-6 112-PU-6 10 170-YL P15
2 1
112-PU-6
R15
FRONT
172-GN
STARTING KEY GAUGES/ 200-BK-16
AID WATER PUMP
START SPEED SENSOR
SWITCH 115-1914
FUSE FUSE
9D-3721 MOTOR
10 10 123-WH C922-BR
181-GY-18
A982-BR
R810-GN 148-WH
109-RD-6
WARNING 200-BK
FLASHER
HORN
FUSE FUSE LH LIGHT GP
G 200-BK C
G
10 10
109-RD-6
614-PU B
INDICATOR 605-YL A
LAMP
2N-2371/ WATER P10 R10
2V-7807 SPRAY
BRAKE
FUSE 619-GN
FUSE
105-BR
WORKING LAMP GP
10 15
R 200-BK
308-YL
155-PK
308-YL
OFF C
FUEL SPRAY WIRE GROUP COLOR DESCRIPTIONS
ON S STARTING AID FUSE
123-WH
307-OR WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.
ST B FUSE (PS360 ONLY)
173-YL
105-BR
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.
15 15 619-GN STARTING CIRCUIT.
110-GN-14
IGNITION
112-PU-6
SWITCH WORKING LAMP GP GROUND CIRCUIT.
9G-7641
BACK-UP ALARM TIRE INFLATION 200-BK STARTING AID CIRCUIT.
FUSE FUSE
GAUGES AND WARNING LIGHTS CIRCUIT.
15 15
WARNING BRAKE CONTROL CIRCUIT.
HORN TURN SIGNAL CIRCUIT.
7T-0969 F
135-BU
F P7 R7
200-BK C
200-BK 614-PU B
322-GY 606-GY A
RH LIGHT GP
R810-GN
C922-BR
619-GN
606-GY
605-YL
614-PU
200-BK
307-OR
308-YL
309-GY
476-PU
441-OR
406-PU
449-WH
614-PU
322-GY
608-GN
112-PU-6
110-GN-14
181-GY-18
403-GN
A982-BR
109-OR-6
121-YL
155-PK
135-BU
128-PK
123-WH
105-BR
173-YL
324-BU
1 2 3 4 5 6 7 8 9 10 11 12 R1 1 2 3 4 5 6 7 8 9 10 11 12 P2
P34 1 2 R16 6 5 4 3 2 1 SYMBOL DESCRIPTION
P3 R4
R810-BR
109-RD-6
112-PU-6
322-GY
606-GY
105-RD
322-GY
128-PK
307-OR
308-YL
309-GY
476-PU
441-OR
449-WH
614-PU
406-PU
619-GN
403-GN
A982-BR
155-PK
181-GY
614-PU
110-GN
200-BK
173-YL
123-WH
4
605-YL
C922-BR
3 614-PU
LEFT TURN/TAIL 2
1
200-BK
605-YL CIRCUIT NOT CONNECTED
R36 P36
WORKING LAMP GP
ELECTRICAL CONNECTION
9X-4381
608-GN TO MACHINE STRUCTURE
HARNESS AS.-ENGINE 200-BK
C922-BR
110-GN
200-BK
1 105-RD 9 9 441-OR 605-YL
KENR7078-01
441-OR
112-PU-6
2 200-BK R37 P37 R
403-GN 10 10 403-GN 200-BK
CONN 1 3 308-YL 200-BK 123-WH 11 11 123-WH LIGHT
4 403-GN 449-WH 12 12 449-WH FLASHER SWITCH
CIRCUIT GROUPING
5 8V-2514 3K-1650
20 Page, Color 2, KWG
A 123-WH 3
REAR SPEED TURN
6 SENSOR BK B 200-BK SWITCH
2 1
49 +BATTERY TURN SIGNAL 1
123-0960 WH C 449-WH CONN 3 1V-6652 2
DESIGNATION
C TURN INDICATOR
R30 P30 P8 R8 537-GN 49A SIGNAL LAMPS 4 C
ENGINE OIL 476-PU 403-GN 1 1 30B +BATTERY HAZARD 5
C PRESS. SENDER ° 105-RD 105-RD 2 2 105-RD 31 GROUND
302010
HYD 200-BK 3 3 200-BK C2 TUV INDICATOR HAZARD
TEMP SENDER 777-PU 4 4 777-PU SWITCH
751-GN 5 5 751-GN 3T-4405
SHIELD
6N5926
309-GY 6 6 309-GY
306-GN 7 7 306-GN A982-BR
°T 810-BR 8 8 R810-BR
ENGINE COOLANT 330-YL 9 9 330-YL
TEMP SENDER
6N5926 R43
1
P43
A919-BU
308-YL
A919-BU
10
11
10
11
308-YL
A919-BU
200-BK 200-BK
ABBREV COLOR
112-PU-6
181-GY
A983-BU 12 12 A983-BU
441-OR 2 4983-BU
DISCONNECT SW
°T CONN 4 5 2
476-PU
THROTTLE CONT.
SOLENOID CABLE AS.
7N-0718
177-RD-6 109-RD-6
NEUTRAL RD RED
200-BK
BK-00
441-OR RELAY #1
WH WHITE
200-BK
P9 R9 87a 3
3E-5239
CABLE AS. 306-GN
CABLE AS.
CABLE AS.
BK-00 324-BU
307-OR
OR ORANGE
200-BK
308-YL RD-00 RD-00 330-YL
GY GRAY
RD-20 B 200-BK STARTER PLUG
6T-6343
3
PUMP C +
24V_RESISTOR RELAY 1 2 1 2 RELAY 2 SPEED
239-5818 R21 R42 155-2269 GLOW PLUGS 181-GY 112-PU-6 -
118-3534 15 SWITCH
WH 1 181-GY 4D-1836 PU PURPLE
CABLE AS.
419-YL
RD-00
200-BK-12 2
155-PK
BR BROWN
304-WH-6 +AUX IN BK 200-BK OPEN FOR
200-BK
S
200-BK
330-YL
LOW SPEED
CABLE AS
GND CABLE AS
-PWR GND IN BK 3 A983-BU
6-RD
RD-6
777-PU
FRAME NEUTRAL START BATTERY +OUT 4
RD
GN GREEN
MTR BAT BREAKER A919-BU
321-BR
CABLE AS
STRAP AS
108-1032
60 171-2208 -OUT 5
5Y-1423
177-RD-6
60 A BK A982-BR NEUTRAL
BK-00
177-RD-6
PLUG
B765-BR
N910-GN 308-YL 6
BU BLUE
GLOW PLUG START
MOTOR BREAKER 5 2
101-RD-6
128-PK
T TRACTION CONTROL 2 SPEED BRAKE 171-2208 TIMER MODULE R59 P59 LOW SPEED NORMALLY CLOSED RELAY #2 5 2
200-BK
INTERLOCK
322-GY
216-2035 SWITCH SWITCH 177-RD-6 160-7395 1 30 87 4 3E-5239
ENG COOL. R22 87 4 BRAKE
7V-9275
200-BK
TEMP. SW 155-PK ALARM 87a 3
CABLE AS.
243-3629-01
777-PU
GND
200-BK
751-GN TO 243-3548 WARNING
ENGINE HORN
FRAME BLOCK SWITCH 200-BK
324-BU 3T-2357
12 11 10 9 8 7 6 5 4 3 2 1