9. Select Monitor Function 3. TROUBLE CODES ARE DISPLAYED
Mode A maximum of 3 trouble codes are displayed in order of occurrence. Applicable cartridge of select monitor. <Ref. to 1-6 I If a particular trouble code is not properly stored [G1100].> in memory (due to a drop in ABSCM&H/U power NOTE: supply, etc.) when a problem occurs, the trouble For basic handling of the select monitor, refer to its code, followed by a question mark “?”, appears on Operation Manual. the select monitor display. This shows it may be an unreliable reading. A: LIST OF FUNCTION MODE 1. ANALOG DATA ARE DISPLAYED Display screen Contents to be monitored Wheel speed detected by the Front FR wheel speed Right ABS sensor is displayed in km/h or mile/h. Wheel speed detected by the Front FL wheel speed Left ABS sensor is displayed in km/h or mile/h. Wheel speed detected by the Rear S4M0076A RR wheel speed Right ABS sensor is displayed in km/h or mile/h. I *a* refers to the troubles in order of occurrence Wheel speed detected by the Rear Left (Latest, Old, Older and Reference). RL wheel speed ABS sensor is displayed in km/h or mile/h. Display screen Contents to be monitored Stop light switch monitor voltage is dis- The most recent trouble code appears Stop light switch Latest played. on the select monitor display. Refers to vehicle acceleration detecting The second most recent trouble code G sensor output Old by the analog G sensor. It appears on appears on the select monitor display. voltage the select monitor display in volts. The third most recent trouble code Older appears on the select monitor display. 2. ON/OFF DATA ARE DISPLAYED A specified period of time proceeding Reference trouble code appears on the select Display screen Contents to be monitored monitor display. Stop light switch Stop light switch signal Valve relay signal Valve relay signal 4. CLEAR MEMORY Motor relay sig- Motor relay signal Display screen Contents to be monitored nal ABS signal to ABS operation signal from ABS control Function of clearing trouble code and Clear memory? TCM module to TCM freeze frame data. ABS warning light ABS warning light 5. ABS SEQUENCE CONTROL Valve relay moni- Display Valve relay operation monitor signal Contents to be monitored Ref. to tor screen Motor relay moni- ABS Perform ABS sequence con- Motor relay operation monitor signal <Ref. to 4-4 tor sequence trol by operating valve and ABS operation signal from ABS control [W14D2].> control pump motor sequentially. CCM signal module to TCM (ABS operation signal monitor)
78 DIAGNOSTICS [T9A6] 4-4 9. Select Monitor Function Mode
6. FREEZE FRAME DATA
NOTE: I Data stored at the time of trouble occurrence is shown on display. I Each time trouble occurs, the latest information is stored in the freeze frame data in memory. I If freeze frame data is not properly stored in memory (due to a drop in ABSCM power supply, etc.), a freeze frame data, preceded by a question mark “?”, appears on the select monitor display. This shows it may be an unreliable reading. The value of the freeze frame data will be written over, and the memory cannot be cleared. Display screen Contents to be monitored Wheel speed detected by the Front FR wheel speed Right ABS sensor is displayed in km/h or mile/h. Wheel speed detected by the Front FL wheel speed Left ABS sensor is displayed in km/h or mile/h. Wheel speed detected by the Rear RR wheel speed Right ABS sensor is displayed in km/h or mile/h. Wheel speed detected by the Rear Left RL wheel speed ABS sensor is displayed in km/h or mile/h. Power (in volts) supplied to ABSCM power ABSCM&H/U appears on the select voltage monitor display. Refers to vehicle acceleration detected G sensor output by the analog G sensor. It appears on voltage the select monitor display in volts. Motor relay moni- Motor relay operation monitor signal tor Stop light switch Stop light switch signal ABS signal to ABS operation signal from ABS control TCM module to TCM (Output signal) ABS operation signal from ABS control ABS-AT control module to TCM (ABS operation signal monitor) ABS operation ABS operation signal signal