1. ___________ is a bunch of computers that are linked together to share data and resources. 2. It is one of the three basic types of networks that is confined to a relatively small area.
A. LAN B. MAN C. WAN
3. Internet is an example of ____. A. LAN B. MAN C. WAN 4. It is a small, simple, inexpensive device that joins multiple computers together. A. HUB B. ETHERNET SWITCH C. ROUTER 5. It is a device that gathers the signals from devices that are connected to it, and then regenerates a new copy of each signal. A. HUB B. ETHERNET SWITCH C. ROUTER 6. an internetworking system capable of joining together two networks that use different base protocols. A. NETWORK GATEWAY B. NETWORK INTERFACE C. NETWORK FIREWALL 7. Small physical devices that join multiple networks together.
A. MODEM B. ROUTER C. BRIDGE
8. If the IP address of the router is 192.168.1.1, which of the following is a correct IP configuration?
A. 192.168.1.1 B. 192.168.0.1 C. 192.168.1.2
9. A type of data cable used in computer networking.
A. UTP Cable B. Standard Cable C. LAN Cable
10. An 8-pin plug or jack is commonly used to connect computers onto Ethernet-based local area networks (LAN). A. RJ - 45 B. RJ - 11 C. UTP Cable 11. A small, hand-held device used to strip the electrical insulation from electric wires.
A. Crimping Tool B. Scissor C. Wire Stripper
12. A device that is used to test the strength and connectivity of a particular type of cable or other wired assemblies.
A. LAN Tester B. Crimping Tool C. Multitester
13-20. Give the color arrangement of T-568 A cable standard. ____ _____ ____ _____ ____ _____ ____ _____ 21-28. Give the color arrangement of T-568 B cable standard. ____ _____ ____ _____ ____ _____ ____ _____ 29 - 30. Give the 2 types of Ethernet Cable 31. What type of Ethernet cable is shown in the picture? 32. This cable is used to connect a computer to a hub, switch or a router. ___________ 33 – 38 Arrange the steps in making a lan cable. 1. Cut into the plastic sheath about 1 inch (2.5 cm) from the end of the cut cable. 2. Pinch the wires between your fingers and straighten them out as shown. The color order is important. 3. Use scissors to make a straight cut across the 8 wires to shorten them to 1/2 Inch (1.3 cm) from the cut sleeve to the end of the wires. 4. Unwind or untwist and pair the similar colors. 5. CRIMPING THE CABLE ... carefully place the connector into the Ethernet Crimper and crimp tightly. 6. Carefully push all 8 colored wires into the connector. 39 - 40 What should be the correct sequence of LED light indicator if you are testing a crossover cable? A. 1–2 B. 1 – 3 C. 1 – 1 2–6 2–6 2–2 3–1 3–1 3–3 4–4 4–4 4–4 5–5 5–5 5–5 6–3 6–2 6–6 7–7 7–7 7–7 8–8 8–8 8–8