Tank Material
X1 and X2 may be determined by multiplying HT by the ratios X1/HT and X2/HT respectively from the figure
X1/HT 0,39
X2/HT 0,78
Lateral seismic force height (to be obtained from the figure) X1 3120 mm
Lateral seismic force height (to be obtained from the figure) X2 6240 mm
π
TT entire weight of liquid is expressed by ρ TT 11068459 kg
4
PROJECT NUMBER TBD DATE
DOCUMENT NUMBER TBD TBD
TEKNOKON JOB NUMBER TBD REV 0
When D/Ht <1,333, value for T1 weight of effective mass of tank contents shall be calculated acc.formula:
[1,0 - 0,218 ]
When D/Ht ≥1,333, value for T1 shall be calculated according to formula:
tanh0,866
,
T1= 2555340 kg
0,23 tanh( )
T2= 7961901 kg
0,866
The lateral force coefficient G2 is determined as a function of G1 and the soil conditions at the tank site
The overturning moment due to seismic forces applied to the bottom of the tank shell;
$ % & ' ( &
%
& % M= 12097 kNm
#
102
)( 0,1*+, -.+ )
10 Wt (kN/m) The maximum force exerted by the tank shell and portion of roof supported by shell
9 tbs (mm) Thickness of bottom shell excluding corrosion allowance
Wb (kN/m) The maximum compression force at the bottom of the shell
Fa (Mpa) Maximum allowable stress
1,273#
)+ )$ & Wb= 20 kN/m
) *+
When 0 44 1, 83
*+
) *+
When 2 44 1, 33 & 7,5 )
*+
Unity Check Fa= 19 Mpa
Fa>Wb/tbs Acceptable Wb/tbs= 2 Mpa
Z (cm3) The required minimum sections modulus of primary stiffening ring (rim profile)
0 Hf (m) Height of tank shell including any freeboard provided above max. filling height
45 Vw (m/s) Wind gust velocity
56
3 0,058 4 Z= 0,000 cm3
45
A (mm^2) Compression Area shall be greater of Figure - 8 in EN 14015
50 Pc (mbar) Internal pressure and equal to design pressure
20 R (m) Radius of the tank
120 Sc (Mpa) Allowable compressive stress 120 Mpa for all steels
5,0 θ (in degrees) Slope of roof meridian at roof to shell connection
In accordance with Clause 12.1, Unanchored Tanks shall satisfy these criteria
Mpi < MDL+MDLR = 125664 < 11976
Safety Factor = 0,10
Mw+Mpi < MDL+MDLR+Mf = 127267 < 33205
Safety Factor = 0,26
Mw < MDL+MDLR = 1603 < 11976
Safety Factor = 7,47
MSL+Mpi < MDL+MDLR+Mf = 137761 < 33205
Safety Factor = 0,24