a.Plumbing system
b.Environment
c.Canal
d. None of these
Waste pipe is classified into two ways, according
to the type it serve, direct waste as one terminal
solidly joined to the plumbing system, whereas
indirect waste has terminal drain pipes simply
empty into the;
a.Plumbing system
b.Environment
c.Canal
d. None of these
Pipe fitting are intended to make change
direction, turn and offset, but their use must be
planned carefully so that waste within the line
have free passage, the fitting use in vertical to
horizontal changes of direction is:
a-anaerobic
b-parasitic
c-saprophytic
d-pathogenic
The bacteria in sewage are mostly:
a-anaerobic
b-parasitic
c-saprophytic
d-pathogenic
The pipe that is remarkable for hot water lure
installation:
a. Copper pipes
b. Brass pipes
c. Stainless pipes
d. Synthetic pipes
The pipe that is remarkable for hot water lure
installation:
a. Copper pipes
b. Brass pipes
c. Stainless pipes
d. Synthetic pipes
A state of complete physical mental and social
well-being and not merely the absence of disease
or infirmity.
a. Health
b. Vital statistics
c. Fitness
d. Statics
A state of complete physical mental and social
well-being and not merely the absence of disease
or infirmity.
a. Health
b. Vital statistics
c. Fitness
d. Statics
The rate of flow of liquid measured per unit of
time, usually gpm or lps.
a. Capacity
b. Static rate
c. Flow rate
d. Pump rate
The rate of flow of liquid measured per unit of
time, usually gpm or lps.
a. Capacity
b. Static rate
c. Flow rate
d. Pump rate
Corrosion in pipe, what is the by-product of
chemical reaction of oxidation in forming ferrous
oxide or rust is covered by the action of:
a. Carbon dioxide
b. Sulfur oxide
c. Methane gas
d. All of these
Corrosion in pipe, what is the by-product of
chemical reaction of oxidation in forming ferrous
oxide or rust is covered by the action of:
a. Carbon dioxide
b. Sulfur oxide
c. Methane gas
d. All of these
What is that receptacle installed at corner wall that
collect rain water from a balcony
a. Downspout
b. Bee-hive roof drain
c. Roof drain
d. Scupper drain
What is that receptacle installed at corner wall that
collect rain water from a balcony
a. Downspout
b. Bee-hive roof drain
c. Roof drain
d. Scupper drain
Disinfection of drinking water is done to remove
a. Bacteria
b. Color
c. Odor
d. Turbidity
Disinfection of drinking water is done to remove
a. Bacteria
b. Color
c. Odor
d. Turbidity
10. A type of valve which should be used only
wide open or fully closed
Gate valve
b. Globe valve
c. Reducing valve
d. Throttle valve
10. A type of valve which should be used only
wide open or fully closed
Gate valve
b. Globe valve
c. Reducing valve
d. Throttle valve
11. Drinking fountain or bubbler when they are
located in the building may be connected to the
pipe that terminate into:
a. Soil pipe
b. Waste pipe
c. Wet vent
d. Vent tank
11. Drinking fountain or bubbler when they are
located in the building may be connected to the
pipe that terminate into:
a. Soil pipe
b. Waste pipe
c. Wet vent
d. Vent tank
11. The non-soluble materials which is the end
product after biological action of bacteria in waste
and what settles at the bottom of the septic tank is
called:
Scum
b. Sledge
c. Sludge
d. smudekne
11. The non-soluble materials which is the end
product after biological action of bacteria in waste
and what settles at the bottom of the septic tank is
called:
Scum
b. Sledge
c. Sludge
d. smudekne
12. How do you connect pump in series?
a. Different RMP
b. Same gpm
c. Same horsepower
d. Different pressure
12. How do you connect pump in series?
a. Different RMP
b. Same gpm
c. Same horsepower
d. Different pressure
13. Determine the water nature through acidity or
alkalinity is;
pH value
b. color meter
c. pH meter
d. none of the above
13. Determine the water nature through acidity or
alkalinity is;
pH value
b. color meter
c. pH meter
d. none of the above
14. The volume of a liquid passing through a cross
section of a stream in unit time is called:
a. Steady flow
b. Uniform flow
c. Continuous flow
d. discharge
14. The volume of a liquid passing through a cross
section of a stream in unit time is called:
a. Steady flow
b. Uniform flow
c. Continuous flow
d. discharge
15. Instrument used to measure the water flow
a. Venturi meter
b. Pressure gauge
c. Dynamometer
d. Pitot tube
15. Instrument used to measure the water flow
a. Venturi meter
b. Pressure gauge
c. Dynamometer
d. Pitot tube
16. Pour index horsepower is how many foot lbs
per minutes
a. 30,000
b. 33,000
c. 33,333
d. 30,333
16. Pour index horsepower is how many foot lbs
per minutes
a. 30,000
b. 33,000
c. 33,333
d. 30,333