Anda di halaman 1dari 161

ZTE GSM Feature Test

Specifications for Mobitel

Product Type Technical Description

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 1


Version Date Author Approved By Remarks
Zhang
V1.01 2010-11-18
Junbo
Zhang
V1.02 2010-12-30
Junbo

© 2010 ZTE Corporation. All rights reserved.


ZTE CONFIDENTIAL: This document contains proprietary information of ZTE and is not to be
disclosed or used without the prior written permission of ZTE.
Due to update and improvement of ZTE products and technologies, information in this document
is subjected to change without notice.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 2


TABLE OF CONTENTS

Product Type Technical Description ............................................................................................ 1

TABLE OF CONTENTS................................................................................................................... 3

1 Scope ........................................................................................................................... 8

2 Reference .................................................................................................................... 8
2.1 Applicable Documents ................................................................................................. 8
2.2 Standards................................................................................................................... 10

3 Abbreviations ........................................................................................................... 14

4 Features Test Specifications .................................................................................. 19


4.1 Full Rate (FR) Speech Codec.................................................................................... 19
4.2 Half Rate .................................................................................................................... 19
4.2.1 HR basic call test ......................................................... Error! Bookmark not defined.
4.3 Enhanced Full Rate (EFR) Speech Codec ................................................................ 20
4.3.1 EFR basic call test ....................................................... Error! Bookmark not defined.
4.4 Adaptive Multi-rate Codec (AMR) .............................................................................. 21
4.4.1 AMR FR and HR basic call test ................................... Error! Bookmark not defined.
4.5 Paging ........................................................................................................................ 22
4.5.1 CS Paging .................................................................................................................. 22
4.5.2 PS Paging (Optional) ........................................................................................... 23
4.6 Short Message Service (SMS) .................................................................................. 23
4.6.1 Short message service in idle mode ............................ Error! Bookmark not defined.
4.7 Emergency Call Handling .......................................................................................... 24
4.8 Support 64 Neighboring Cells .................................................................................... 24
4.9 A5/1 and A5/2 Ciphering Algorithm ........................................................................... 25
4.9.1 Call support A5/1 ciphering algorithm ........................................................................ 25
4.9.2 Call support A5/2 ciphering algorithm ........................................................................ 26
4.10 Cell Broadcast SMS ................................................................................................... 26
4.10.1 Add a new CBC message.......................................................................................... 26
4.10.2 Delete an existed CBC message ............................................................................... 27
4.11 Dual Transfer Mode ................................................................................................... 28
4.11.1 PS after CS call setup ................................................................................................ 28
4.11.2 CS call when PS transferring ..................................................................................... 29
4.12 Paging Coordination .................................................................................................. 30
4.13 Support of SDCCH/4 and SDCCH/8 ......................................................................... 31
4.13.1 Support of SDCCH/4 ................................................................................................. 31
4.13.2 Support of SDCCH/8 ................................................................................................. 31
4.14 SDCCH/SDCCH Handover........................................................................................ 33
4.14.1 SDCCH/SDCCH handover .......................................... Error! Bookmark not defined.
4.15 Flexible SDCCH Configuration .................................................................................. 33
4.16 Dynamic Configuration of SDCCH ............................................................................ 34
4.16.1 TCH convert to SDCCH ............................................................................................. 34
4.16.2 SDCCH convert to TCH ............................................................................................. 35
4.17 Basic Handover ......................................................................................................... 36
4.17.1 Intra-cell handover ..................................................................................................... 36
4.17.2 Inter-cell handover ..................................................................................................... 37
4.17.3 Inter-BSC handover (Optional) .................................... Error! Bookmark not defined.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 3


4.18 Directed-Shift Handover ............................................................................................ 37
4.19 Directed Retry ............................................................................................................ 38
4.20 Traffic Based Handover ............................................................................................. 39
4.21 Dynamic Handover Priority Algorithm ........................................................................ 40
4.21.1 Static handover priority .............................................................................................. 40
4.21.2 Dynamic handover priority ......................................................................................... 41
4.22 Traffic Hold at Channel Blocking ............................................................................... 41
4.23 Dynamic Half Rate Allocation .................................................................................... 42
4.24 Dynamic BTS Power Control ..................................................................................... 43
4.25 Dynamic MS Power Control....................................................................................... 45
4.26 Downlink Rapid Power Control .................................................................................. 45
4.27 AMR Power Control ................................................................................................... 46
4.27.1 AMR FR Dynamic Downlink Power Control .............................................................. 46
4.27.2 AMR FR Dynamic Uplink Power Control ................................................................... 48
4.27.3 AMR HR Dynamic Downlink Power Control ................ Error! Bookmark not defined.
4.27.4 AMR HR Dynamic Uplink Power Control ..................... Error! Bookmark not defined.
4.28 Static BTS Power Control .......................................................................................... 49
4.29 Discontinuous Transmission Downlink ...................................................................... 50
4.30 Discontinuous Transmission Uplink ........................................................................... 51
4.31 Coding Scheme CS1~CS4 ........................................................................................ 52
4.31.1 Coding scheme CS1 .................................................................................................. 52
4.31.2 Coding scheme CS2 .................................................................................................. 53
4.31.3 Coding scheme CS3 .................................................................................................. 54
4.31.4 Coding scheme CS4 .................................................................................................. 55
4.32 Modulation and Coding Scheme #1~#9 .................................................................... 56
4.32.1 Modulation and coding scheme #1 ............................................................................ 56
4.32.2 Modulation and coding scheme #2 ............................................................................ 56
4.32.3 Modulation and coding scheme #3 ............................................................................ 57
4.32.4 Modulation and coding scheme #4 ............................................................................ 58
4.32.5 Modulation and coding scheme #5 ............................................................................ 59
4.32.6 Modulation and coding scheme #6 ............................................................................ 60
4.32.7 Modulation and coding scheme #7 ............................................................................ 60
4.32.8 Modulation and coding scheme #8 ............................................................................ 61
4.32.9 Modulation and coding scheme #9 ............................................................................ 62
4.33 STM-1 Support on A Interface ................................................................................... 63
4.33.1 STM-1 Support on A Interface ..................................... Error! Bookmark not defined.
4.34 STM-1 Support on Ater Interface ............................................................................... 64
4.34.1 STM-1 Support on Ater Interface ................................. Error! Bookmark not defined.
4.35 STM-1 Support on Abis Interface .............................................................................. 65
4.36 2M High Speed Signaling Link .................................................................................. 66
4.37 TC Resource Dynamic Sharing ................................................................................. 66
4.38 PCU Resource Dynamic Allocation ........................................................................... 67
4.39 Abis over IP................................................................................................................ 67
4.40 Gb over IP .................................................................................................................. 68
4.40.1 BSC to support Gb over IP .......................................... Error! Bookmark not defined.
4.41 Remote Transcoder Support ..................................................................................... 69
4.42 Distributed Architecture of BTS ................................................................................. 70
4.43 MMR .......................................................................................................................... 70
4.43.1 Massive Measurement Report ..................................... Error! Bookmark not defined.
4.44 GSM/WCDMA Interworking Phase I ............................ Error! Bookmark not defined.
4.45 Flexible MAIO Management ...................................................................................... 74
4.45.1 Configure all cell with RF hopping with different BCCH but same MA list. Confirm
with different MAIO = 2, 4, 6 ........................................ Error! Bookmark not defined.
4.46 Synthesized Frequency Hopping ............................................................................... 75
4.46.1 Configure different hopping system ............................. Error! Bookmark not defined.
4.47 Support of 64 Frequencies Hopping .......................................................................... 76

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 4


4.48 Baseband Frequency Hopping .................................................................................. 78
4.48.1 Configure different hopping system ............................. Error! Bookmark not defined.
4.48.2 Configure different HSN ............................................... Error! Bookmark not defined.
4.49 Cell Selection ............................................................................................................. 79
4.50 Cell Reselection ......................................................................................................... 79
4.51 Immediate TCH Assignment ...................................................................................... 80
4.52 Call Re-establishment ................................................................................................ 80
4.52.1 Call Reestablishment ................................................... Error! Bookmark not defined.
4.53 MS Access Control .................................................................................................... 81
4.54 MAC Dynamic Allocation Mode ................................................................................. 82
4.55 Static Channel Management ..................................................................................... 83
4.56 Dynamic Channel Management ................................................................................ 83
4.56.1 Dynamic Channel Management .................................. Error! Bookmark not defined.
4.56.2 Threshold adjustment .................................................. Error! Bookmark not defined.
4.57 Idle Channel Measurement........................................................................................ 84
4.57.1 Idle Channel Measurement report in different periods Error! Bookmark not defined.
4.57.2 Allocation based on TRX priority ................................. Error! Bookmark not defined.
4.58 Enhancement on CS Channel Allocation .................................................................. 85
4.58.1 Channel Allocation Based on Reserved Channels ...... Error! Bookmark not defined.
4.59 Enhancement on PS Channel Allocation ................................................................... 86
4.59.1 Channel allocation on TRX priority .............................. Error! Bookmark not defined.
4.60 Initial Coding Scheme per Cell Settable .................................................................... 87
4.60.1 Set GPRS phone init coding = Cs2 and GPRS phones init code can be changed =
Yes. Confirm MS is using Cs2 for initial coding. The subsequent coding scheme
can be changed based on radio environment. ............ Error! Bookmark not defined.
4.60.2 Cell support EDGE. Set EGPRS phone init coding = MCS6 and EGPRS phones init
code can be changed = Yes. Confirm MS is using MCS6 for initial coding. The
subsequent coding scheme can be changed based on radio environmentError! Bookmark not defined.
4.61 8/11 bit Access Burst ................................................................................................. 88
4.61.1 8 bit access burst ....................................................................................................... 88
4.61.2 11 bit access burst ..................................................................................................... 89
4.62 Class A, B, C mobile stations(Optional) .................................................................... 90
4.63 One Phase Access .................................................................................................... 90
4.64 Two Phase Access .................................................................................................... 91
4.65 Timeslot Multiplexing ................................................................................................. 92
4.65.1 Uplink timeslot multiplexing for EDGE and GPRS..................................................... 92
4.65.2 Downlink timeslot multiplexing for EDGE and GPRS ................................................ 93
4.66 GPRS Link Adaptation ............................................................................................... 94
4.67 Delayed TBF Release in DL ...................................................................................... 95
4.68 Delayed TBF Release in UL ...................................................................................... 96
4.69 Downlink BVC Flow Control....................................................................................... 97
4.70 Downlink MS Flow Control......................................................................................... 98
4.71 EGPRS Packet Channel Request on CCCH ............................................................. 99
4.71.1 One phase access of EGPRS capable MS by EPCR on CCCHError! Bookmark not defined.
4.71.2 Forced two phase access of EGPRS capable MS by EPCR on CCCHError! Bookmark not defined.
4.72 EGPRS Activation per Cell ...................................................................................... 100
4.72.1 EGPRS Activation per cell ........................................... Error! Bookmark not defined.
4.73 Discontinuous Reception (DRX) .............................................................................. 101
4.74 MAC Extended Dynamic Allocation ......................................................................... 102
4.75 Flexible Priority Handling of Packet Data Channel .................................................. 103
4.75.1 EDGE dedicated channel ........................................................................................ 103
4.75.2 EDGE priority channel ............................................................................................. 104
4.75.3 GPRS priority channel ............................................................................................. 104
4.75.4 Default channel ........................................................................................................ 105
4.76 GPRS and EGPRS Channels Allocated Separately ............................................... 106
4.76.1 GPRS and EGPRS Channels Allocated Separately ... Error! Bookmark not defined.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 5


4.77 Multi Timeslot Supported in Extended Cell .............................................................. 107
4.78 EGPRS Link Adaptation .......................................................................................... 108
4.78.1 iBSC use higher protection coding scheme when MS send a lot of NACKError! Bookmark not defined.
4.79 Incremental Redundancy in UL ............................................................................... 109
4.79.1 Confirm MS use IR to retransmit uplink data to MS when packet data loss occurredError! Bookmark not
4.80 Extended uplink TBF mode ..................................................................................... 110
4.80.1 Extended uplink TBF mode ..................................................................................... 110
4.80.2 Enhanced Extended uplink TBF mode .................................................................... 111
4.81 Intelligent UL/DL timeslot adjustment ...................................................................... 112
4.82 Enhanced Multi-timeslot Support ............................................................................. 113
4.82.1 Enhanced Multi-timeslot Support(class 32 5+1) .......... Error! Bookmark not defined.
4.82.2 Enhanced Multi-timeslot Support(class 32 4+2) .......... Error! Bookmark not defined.
4.83 Enhanced Cell Reselection Procedure .................................................................... 114
4.84 IP SLA ...................................................................................................................... 115
4.85 Abis Triggered FR/HR Adaptation ........................................................................... 115
4.86 Dynamic FR/HR Adjustment .................................................................................... 117
4.86.1 AMR FR -> AMR HR due to traffic ........................................................................... 117
4.86.2 FR -> HR due to traffic ............................................................................................. 118
4.87 Service Based QoS ................................................................................................. 118
4.87.1 iBSC calculate the weight of different service type ..... Error! Bookmark not defined.
4.88 Streaming Service Policies ...................................................................................... 128
4.88.1 Cell with 2 x PDCH and initial MCS is set to 9. User 1 has QoS profile of 100kbit/s
GBR. Confirm only user 1 can get 2 x PDCH by using EDGE ME. Other users with
lower prioity is denied .................................................. Error! Bookmark not defined.
4.89 eMLPP ..................................................................................................................... 129
4.89.1 Force release of CS service .................................................................................... 129
4.89.2 Force handover of CS services ............................................................................... 130
4.90 Inter-BSC NACC (Optional) ..................................................................................... 131
4.91 Automatic BCCH Recovery ..................................................................................... 132
4.91.1 Confirm all BCCH TRX configuration are transferred to NBCCH TRXError! Bookmark not defined.
4.91.2 The MAX cells' amount of simultaneously handover is set to 1. Trigger 2 BCCH
reconfiguration at the same time ................................. Error! Bookmark not defined.
4.92 Interference Rejection Combining (IRC) .................................................................. 133
4.93 Co-BCCH ................................................................................................................. 133
4.93.1 Channel Allocation based on Dual-band Subcell .................................................... 133
4.93.2 Subcell HO - Passloss&TA ...................................................................................... 134
4.93.3 Subcell HO - C/I ....................................................................................................... 136
4.94 AMR Radio Link Timers ........................................................................................... 137
4.94.1 AMR FR Radio Link Timers ......................................... Error! Bookmark not defined.
4.94.2 AMR HR Radio Link Timers......................................... Error! Bookmark not defined.
4.95 TCH Migration to BCCH TRX .................................................................................. 138
4.95.1 TCH Migration to BCCH TRX ...................................... Error! Bookmark not defined.
4.96 Load Dependent Intelligent TRX Shutdown ............................................................ 139
4.97 Intelligent Timeslot Shutdown ...................................... Error! Bookmark not defined.
4.98 Intelligent TRX Shutdown Triggered by Main Power Failure (Optional) .................. 140
4.98.1 Intelligent TRX Shutdown Triggered by Main Power FailureError! Bookmark not defined.
4.99 Multi-layer Cell Structure ......................................................................................... 141
4.99.1 Basic Micro cell creation .......................................................................................... 141
4.99.2 Basic Macro cell creation ......................................................................................... 142
4.100 Concentric Circle Technology .................................................................................. 144
4.100.1 Handover based on Passloss&TA ........................................................................... 144
4.100.2 Handover based on C/I ............................................................................................ 145
4.101 Multi-band Networking ............................................................................................. 146
4.101.1 Cell re-selection from 900M to 1800M ..................................................................... 146
4.101.2 Cell re-selection from 1800M to 900M ..................................................................... 146
4.101.3 Cell handover from 900M to 1800M ........................................................................ 147

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 6


4.102 Clock Synchronization on GPS ............................................................................... 148
4.103 MS Specification Collection ..................................................................................... 149
4.103.1 MS Specification Collection ......................................... Error! Bookmark not defined.
4.104 Random Fill Bits ....................................................................................................... 150
4.105 Enhanced One Logical Cell with Multi RRU ............................................................ 151
4.105.1 Multi-Channel mode(1 TRX MCM) .............................. Error! Bookmark not defined.
4.106 RLC Acknowledged/Unacknowledged Mode .......................................................... 151
4.107 Data Traffic Channels .............................................................................................. 152
4.108 Quality of Service (QoS) .......................................................................................... 153
4.109 Queuing ................................................................................................................... 154
4.110 Star, Tree, and Chain Networking ........................................................................... 154
4.110.1 Star networking ........................................................................................................ 154
4.110.2 Tree networking ....................................................................................................... 155
4.110.3 Chain networking ..................................................................................................... 156
4.111 BTS Recovery .......................................................................................................... 157
4.112 Dry Contact Alarm(Optional).................................................................................... 158
4.112.1 Dry Contact Alarm ................................................................................................... 158
4.113 Backward Compatibility for BTS .............................................................................. 158
4.114 Monitoring Um Interface .......................................................................................... 118
4.115 Abis Interface Monitoring ......................................................................................... 119
4.116 Performance Data Measurement ............................................................................ 120
4.117 BSC Monitor Functions ............................................................................................ 122
4.118 BTS Software Loading ............................................................................................. 123
4.119 Cell Traffic Statistics ................................................................................................ 123
4.120 BSC Diagnostic Tests .............................................................................................. 124
4.120.1 Test Management .................................................................................................... 124
4.120.2 BSC board test ........................................................................................................ 125
4.120.3 BSC Version Information test .................................................................................. 126
4.121 BSC LMT ................................................................................................................. 126
4.122 Flexible EGPRS scheduling priority ............................. Error! Bookmark not defined.
4.123 Mandatory Handover ................................................... Error! Bookmark not defined.
4.124 Network-assisted Cell Change ................................................................................ 159
4.124.1 Intra BSC NACC .......................................................... Error! Bookmark not defined.
4.124.2 2G <-> 3G dedicated mode HO ................................... Error! Bookmark not defined.
4.125 Independent Threshold for Dynamic AMR HR-FR Conversion .. Error! Bookmark not
defined.
4.126 PS Channel Extension ................................................. Error! Bookmark not defined.
4.126.1 Cell handover from 1800M to 900M ............................ Error! Bookmark not defined.
4.127 Cell broadcast information ........................................... Error! Bookmark not defined.
4.127.1 Add a new CBC message............................................ Error! Bookmark not defined.
4.127.2 Delete an existed CBC message ................................. Error! Bookmark not defined.
4.127.3 Enquire existed CBC message .................................... Error! Bookmark not defined.
4.128 Multiple Cells Support .................................................. Error! Bookmark not defined.
4.129 Error! Bookmark not defined.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 7


ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 8
1 Scope
This test specification defines the test methods of the ZXG (generic name of all the ZTE GSM
products) release V09R2.3. It can serve as the test standard before BSS network access or
before commissioning.

Release V09R2.3 defines as Base Station Controller release V09R2.3 and SDR release V09R2.3.

Based on the Test Handbook for V09R1+, this test specification is modified and improved to fit
V09R2.3. And this specification will focus on the new features of V09R2.3

For Mobitel contract ZTE provides BSC type iBSC ZXG10 with V10R2 software version. All the
features that are affecting KPIs subjected to KPI monitoring in the POC period.

All the tools for the POC testing is provided by ZTE except speech quality (MOS) testing terminals.
Mobitel responsible for providing the network existing node inter relating senarios for the POC
testing. (Flex Gb, etc.)

2 Reference
2.1 Applicable Documents
[1] ZTE GSM Enhanced IP Abis FD

[2] ZTE GSM Flex A FD

[3] ZTE GSM IP over E1 FD

[4] ZTE GSM GPS syn(SDR) FD

[5] ZTE GSM Enhanced Handover Algorithm FD

[6] ZTE GSM Cell Broadcast SMS FD

[7] ZTE GSM Coverage Enhanced FD

[8] ZTE GSM AMR Enhancement FD

[9] ZTE GSM MMR FD

[10] ZTE GSM Packet Flow Context FD

[11] ZTE GSM A/Ater Interface Over Satellite FD

[12] ZTE GSM Gb Interface Over Satellite FD

[13] ZTE GSM TC Pool FD

[14] ZTE GSM BSS Support SIGTRAN Interface FD

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 9


[15] ZTE GSM congestion management & control FD

[16] ZTE GSM Enhanced 2G/3G Inter-working FD

[17] ZTE GSM EGSM Frequency Band Support FD

[18] ZTE GSM Abis Interface Over Satellite FD

[19] ZTE GSM IEEE 1588 V2 FD

[20] ZTE GSM 6 Cells Support FD

[21] ZTE GSM T1 Interface FD

[22] ZTE GSM IP Gb FD

[23] ZTE GSM Flex Ater FD

[24] ZTE GSM Gb/Ater Multiplexing FD

[25] ZTE GSM 1:8 Dynamic Multiplexing on Ater Interface FD

[26] ZTE GSM Flex Gb FD

[27] ZTE GSM Handover between Macro- and Micro-BTS FD

[28] ZTE GSM Dynamic Handover Priority Algorithm FD

[29] ZTE GSM Directed Retry Handover FD

[30] ZTE GSM SDCCH/SDCCH Handover FD

[31] ZTE GSM Multi-layer Cell Structure FD

[32] ZTE GSM Concentric Circle Technology FD

[33] ZTE GSM Multi-band Networking FD

[34] ZTE GSM GSM/UMTS Inter-working FD

[35] ZTE GSM Multi PLMN FD

[36] ZTE GSM Dynamic BTS Power Control FD

[37] ZTE GSM Dynamic MS Power Control FD

[38] ZTE GSM RAN Sharing FD

[39] ZTE Test Handbook for V09R1+_V1.08

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 10


2.2 Standards
All the following 3GPP standard documents are Release 7(2008 March).

[1] 3GPP TR 21.905 Vocabulary for 3GPP Specifications

[2] 3GPP TS 23.003 Numbering, addressing and identification

[3] 3GPP TS 23.008 Organization of Subscriber Data

[4] 3GPP TS 23.009 Handover Procedures

[5] 3GPP TS 23.032 Universal Geographical Area Description (GAD)

[6] 3GPP TS 23.060 General Packet Radio Service (GPRS) Service Description Stage 2

[7] 3GPP TS 23.110 UMTS Access Stratum Services and Functions

[8] 3GPP TS 23.122 Non-Access-Stratum functions related to Mobile Station (MS) in idle
mode

[9] 3GPP TS 23.172 Technical realization of Circuit Switched (CS) multimedia service
UDI/RDI fallback and service modification; Stage 2

[10] 3GPP TS 23.236 Intra-domain connection of Radio Access Network (RAN) nodes to
multiple Core Network (CN) nodes

[11] 3GPP TS 23.246 Multimedia Broadcast Multicast Service; Architecture and Functional
Description

[12] 3GPP TS 23.251 Network Sharing; Architecture and functional description

[13] 3GPP TS 23.930 Iu Principles

[14] 3GPP TS 24.007 Mobile radio interface signalling layer 3; General aspects

[15] 3GPP TS 24.008 Mobile Radio Interface Layer 3 Specification, Core Network
Protocols - Stage 3

[16] 3GPP TS 25.101 UE Radio Transmission and Reception (FDD)

[17] 3GPP TS 25.103 RF parameters in support of RRM

[18] 3GPP TS 25.133 Requirements for Support of Radio Resource Management (FDD)

[19] 3GPP TS 25.211 Physical channels and mapping of transport channels onto physical
channels (FDD)

[20] 3GPP TS 25.212 Multiplexing and channel coding (FDD)

[21] 3GPP TS 25.213 Spreading and modulation (FDD)

[22] 3GPP TS 25.214 Physical layer procedures (FDD)

[23] 3GPP TS 25.215 Physical layer – Measurements (FDD)

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 11


[24] 3GPP TS 25.301 Radio Interface Protocol Architecture

[25] 3GPP TS 25.302 Services provided by the physical layer

[26] 3GPP TS 25.303 Interlayer Procedures in Connected Mode

[27] 3GPP TS 25.304 UE Procedures in Idle Mode and Procedures for Cell Reselection in
Connected Mode

[28] 3GPP TS 25.305 Stage 2 Functional Specification of UE Positioning in UTRAN

[29] 3GPP TS 25.306 UE Radio Access Capabilities

[30] 3GPP TS 25.308 High Speed Downlink Packet Access (HSDPA): Overall Description;
Stage 2

[31] 3GPP TS 25.309 FDD Enhanced Uplink; Overall Description; Stage 2

[32] 3GPP TS 25.321 Medium Access Control (MAC) protocol specification

[33] 3GPP TS 25.322 Radio Link Control (RLC) protocol specification

[34] 3GPP TS 25.323 Packet Data Convergence Protocol (PDCP) Specification

[35] 3GPP TS 25.324 Broadcast/Multicast Control BMC

[36] 3GPP TS 25.331 RRC Protocol Specification

[37] 3GPP TS 25.346 Introduction of the Multimedia Broadcast Multicast Service (MBMS)
in the Radio Access Network (Stage-2)

[38] 3GPP TS 25.401 UTRAN overall description

[39] 3GPP TS 25.402 Synchronization in UTRAN; Stage 2

[40] 3GPP TS 25.410 UTRAN Iu Interface: General Aspects and Principles

[41] 3GPP TS 25.411 UTRAN Iu Interface Layer 1

[42] 3GPP TS 25.412 UTRAN Iu Interface Signalling Transport

[43] 3GPP TS 25.413 UTRAN Iu Interface RANAP Signalling

[44] 3GPP TS 25.414 UTRAN Iu interface data transport & transport signalling

[45] 3GPP TS 25.415 UTRAN Iu Interface user plane protocol

[46] 3GPP TS 25.419 UTRAN Iu Interface: Service Area Broadcast Protocol SABP (nil)

[47] 3GPP TS 25.420 Technical Specification Group UTRAN Iur Interface General Aspects
and Principles

[48] 3GPP TS 25.422 Technical Specification Group UTRAN Iur Interface Signaling
Transport

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 12


[49] 3GPP TS 25.423 UTRAN Iur Interface RNSAP Signaling

[50] 3GPP TS 25.425 UTRAN Iur Interface User Plane Protocols for Common Transport
Channel Data streams

[51] 3GPP TS 25.426 Technical Specification Group UTRAN Iur and Iub Interface Data
Transport & Transport Signaling for DCH Data Streams

[52] 3GPP TS 25.427 UTRAN Iub/Iur Interface User Plane Protocol for DCH Data Streams

[53] 3GPP TR 25.921 Guidelines and principles for protocol description and error handling

[54] 3GPP TR 25.922 Radio resource management strategies

[55] 3GPP TR 25.925 Radio interface for broadcast/multicast services

[56] 3GPP TR 25.992 Multimedia Broadcast Multicast Service (MBMS); UTRAN/GERAN


Requirements

[57] 3GPP TS 25.993 Typical examples of Radio Access Bearers (RABS) and Radio
Bearers (RBS) supported by Universal Terrestrial Radio Access (UTRA)

[58] 3GPP TS 26.102 Mandatory Speech Codec, AMR speech Codec; Interface to Iu and
Uu

[59] 3GPP TS 26.103 Technical Specification Group Services and System Aspects;
Speech codec list for GSM and UMTS

[60] 3GPP TS 29.060 Technical Specification Group Core Network, GPRS Tunneling
Protocol

[61] 3GPP TS 31.102 Characteristics of the USIM Application

[62] 3GPP TS 33.102 Technical Specification Group Services and System Aspects, 3G
Security, Security Architecture

[63] 3GPP TS 34.108 Common Test Environments for User Equipment (UE) Conformance
Testing

[64] 3GPP TS 34.123-2 User Equipment (UE) conformance specification; Part 2:


Implementation Conformance Statement (ICS) Performa specification

[65] 3GPP TS 44.018 Mobile radio interface layer 3 specification; Radio Resource Control
Protocol

[66] 3GPP TS 44.060 General Packet Radio Service (GPRS); Mobile Station (MS) - Base
Station System (BSS) interface; Radio Link Control/Medium Access Control (RLC/MAC) protocol

[67] 3GPP TS 44.118 Mobile radio interface layer 3 specification; Radio Resource Control
Protocol, Iu Mode

[68] 3GPP TS 45.005 Radio transmission and reception

[69] 3GPP TS 45.008 Radio subsystem link control

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 13


[70] ITU-T I.361 (11/1995) ITU-T Recommendation; B-ISDN ATM layer specification

[71] ITU-T Q.2110 (07/1994) ITU-T Recommendation B-ISDN ATM adaptation Layer -
Service Specific Connection Oriented Protocol (SSCOP)

[72] ITU-T Q.2140 (02/1995) ITU-T Recommendation; B-ISDN signalling ATM Adaptation
Layer - Service specific coordination function for signalling at the Network Node Interface (SSCF
at NNI)

[73] ITU-T Q.2150.2 (12/1999) ITU-T Recommendation; AAL type 2 signalling transport
converter on SSCOP

[74] ITU-T Q.2210 (07/1996) ITU-T Recommendation; Message transfer part level 3
functions and messages using the services of ITU-T Recommendation Q.2140

[75] ITU-T Q.2630.1 (12/1999) ITU-T Recommendation; AAL type 2 signalling protocol -
Capability Set 1

[76] ITU-T Q.2630.2 ITU-T Recommendation; AAL type 2 signalling protocol - Capability
Set 2

[77] ITU-T Q.704 (07/1996) ITU-T Recommendation; Signalling network functions and
messages

[78] ITU-T Q.711 (07/1996) ITU-T Recommendation; Functional Description of the


Signalling Connection Control Part

[79] ITU-T Q.712 (07/1996) ITU-T Recommendation; Definition and function of the
Signalling Connection Control Part message

[80] ITU-T Q.713 (07/1996) ITU-T Recommendation; Signalling Connection Control Part
formats and codes

[81] ITU-T Q.714 (07/1996) ITU-T Recommendation; Signalling Connection Control Part
procedures

[82] ITU-T Q.715 (07/1996) ITU-T Recommendation; Signalling Connection Control Part
user guide

[83] ITU-T Q.716 (03/1993) ITU-T Recommendation; Signalling Connection Control Part
performance

[84] ITU-T Q.782 (07/1996) ITU-T Recommendation; MTP level 3 test specification

[85] ITU-T Recommendation X.680 (07/2002) Information Technology - Abstract Syntax


Notation One (ASN.1): Specification of basic notation

[86] ITU-T Recommendation X.681 (07/2002) Information Technology - Abstract Syntax


Notation One (ASN.1): Information object specification

[87] ITU-T Recommendation X.691 (07/2002) Information technology - ASN.1 encoding


rules: Specification of Packed Encoding Rules (PER)

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 14


3 Abbreviations
APN Access Point Name

APSI Active Pattern Sequence Indicator

ATM Asynchronous Transfer Mode

BER Bit Error Rate

BM-SC Broadcast-Multicast Service Centre

BTS Base station

CFN Connection Frame Number

CFN Call Forwarding Number

C-ID Cell Identifier

CM Compressed Mode

CN Core Network

CN-CS Core Network Circuit Switched

CN-PS Core Network Packet Switched

CPICH Common Pilot Channel

CRC Cyclic Redundancy Check

CRNC Controlling Base Station Controller

C-RNTI Controlling Radio Network Temporary Identity

DBSS Drift BSS

DCCH Dedicated Control Channel

DCH Dedicated Transport Channel

DGANSS Differential Galileo and Additional Navigation Satellite Systems

DL Downlink

DRNC Drift Base Station Controller

D-RNTI Drift Radio Network Temporary Identity

D-RNTI Drift Radio Network Temporary Identifier

DRX Discontinuous Reception

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 15


DSCH Downlink Shared Channel

DT1 Data Form 1

E-DCH Enhanced Dedicated Channels

FACH Forward Access Channel

FDD Frequency Division Duplex

F-DPCH Fractional DPCH

FTP File Transfer Protocol

GAI Geographical Area Identifier

GANSS Galileo and Additional Navigation Satellite Systems

GGSN Gateway GPRS Support Node

GPS Global Position System

HS-DSCH High Speed - Downlink Shared Channel

HLR Home Location Register

HSDPA High Speed Downlink Packet Access

HSUPA High Speed Uplink Packet Access

ID Identifier

IE Information Element

IMSI International Mobile Subscriber Identity

ISCP Interference Signal Code Power

ISCP Interference Signal Code Power

LAC Location Area Code

LCR Low Chip Rate

MAC-c/sh Medium Access Control-Common Transport Channels/ DSCHs

MBMS Multimedia Broadcast Multicast Service

MGW Media Gateway Function

MM Mobility Management

MSC Mobile Switching Center

NAS Non Access Stratum

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 16


NRT Non Real Time

NI Network Identifier

NSEA Destination NSAP Service Endpoint Address Parameter

PC Power Control or Point Code

PCH Paging Channel

PDN Packet Data Network

PDU Protocol Data Unit

PMM Packet Mobility Management

PTM Point-to-multipoint

PTP Point-to-point

RAC Routing Area Code

RACH Random Access Channel

RAT Radio Access Technology

RCC Radio Resource Control

RL Radio Link

RLS Radio Link Set

RNSAP Radio Network Subsystem Application Part

RSCP Received Signal Code Power

RT Real Time

SBSS Serving BSS

SRB2 Signalling radio bearer 2

RX Receive or Reception

SAC Service Area Code

SCCP Signaling Connection Control Part

SDU Service Data Unit

SGSN Serving Gateway Support Node

SIR Signal-to-Interference Ratio

SLC Signaling Link Code

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 17


SLTA Signaling Link Test Message Acknowledgement

SLTM Signaling Link Test Message

SPC Signaling Point Code

SRNC Serving Base Station Controller

SRNS Serving RNS

SSCS Service Specific Convergence Sublayer

TB Transport Block

TCH Traffic Channel Handover

TDD Time Division Duplex

TDS Test Description Status

TE Test Equipment

TFCI Transport Format Combination Indicator

TFI Transport Format Indicator

TFS Transport Format Set

TGPSI Transmission Gap Pattern Sequence Indicator

TMGI Temporary Multicast Group Identifier

ToA Time of Arrival

TPC Transmit Power Control

TTI Transmission Time Interval

UDT Unit Data

UDT Uniform Data Transfer

UE User Equipment

UL Up-Link

UMTS Universal Mobile Telecom System

URA UTRAN Registration Area

USCH Uplink Shared Channel

USIM UMTS Subscriber Identity Module

UTRAN UMTS Radio Access Network

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 18


VC Virtual Circuit

VCC Virtual Channel connection

VCI Virtual Channel Identifier

VPI Virtual Path Identifier There are two methods to create a document in word template.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 19


4 Features Test Specifications
4.1 Full Rate (FR) Speech Codec
Test Item Full Rate (FR) Speech Codec
Test Networking
Precondition 1. check CN is healthy
2. check BSC is healthy
3. check SDR is healthy
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

Test Steps 1. Configure “Preferred Speech version (full)” as “Full


Rate version 1” in BSC Property interface of
configuration management.
2. Configure “Channel Select priority” is “Only Full Rate
Allowed” in Cell Property interface of configuration
management;
3. open A and CS signaling trace;
4. Make a voice call.
5. Check speech version in signaling trace.
6. Hold on for several minutes, and then hang up.
Anticipative Result 1. The conversation is normal;
2. assignment command include “FR version 1” in CS
signaling trace;
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.2 Half Rate


Test Item HR basic call test
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 20


5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure “Preferred Speech version (half)” as “half
Rate version 1” in BSC Property interface of
configuration management.
2. Configure “Channel Select priority” is “Only half Rate
Allowed” in Cell Property interface of configuration
management;
3. open A and CS signaling trace;
4. Make a voice call.
5. Check speech version in signaling trace.
6. Hold on for several minutes, listen the speech quality
(uplink and downlink) and then hang up.
Anticipative Result 1. “Assignment command” includes “channel Type:
TCH/H + ACCHs” and “Channel Mode: speech full
rate or half rate version 1” in CS signaling trace;
2. The call could be established successfully,
“Assignment completed” includes “GSM speech half
rate version 1” in SCCP signaling trace;
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.3 Enhanced Full Rate (EFR) Speech Codec


Test Item EFR basic call test
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure “Preferred Speech version (full)” as “Full
Rate version 2” in BSC Property interface of
configuration management.
2. Configure “Channel Select priority” is “Only Full Rate
Allowed” in Cell Property interface of configuration
management;
3. open A and CS signaling trace;
4. Make a voice call.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 21


5. Check speech version in signaling trace.
6. Hold on for several minutes, listen the speech quality
(uplink and downlink) and then hang up.

Anticipative Result 1. “Assignment command” includes “channel Type:


TCH/F + FACCH/F and SACCH/F” and “Channel
Mode: speech full rate or half rate version 2” in CS
signaling trace;
2. The call could be established successfully,
“Assignment completed” includes “GSM speech full
rate version 2” in SCCP signaling trace;
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.4 Adaptive Multi-rate Codec (AMR)


Test Item AMR FR and HR basic call test
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure “Preferred Speech version (full)” as “Full
Rate version 3” in BSC Property interface of
configuration management.
2. Configure “Channel Select priority” is “Only Full Rate
Allowed” in Cell Property interface of configuration
management;
3. open A and CS signaling trace;
4. Make a voice call.
5. Check speech version in signaling trace.
6. Hold on for several minutes, listen the speech quality
(uplink and downlink) and then hang up.
7. Repeat step 1~6 with half rate instead.
Anticipative Result 1. “Assignment command” includes “Channel Mode:
speech full rate or half rate version 3” in CS signaling
trace;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 22


2. The call could be established successfully,
“Assignment completed” includes “GSM speech full
rate version 3 or half rate version 3” in SCCP
signaling trace;
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.5 Paging

4.5.1 CS Paging
Test Item CS Paging
Test Networking As shown figure 1
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. BTS A and BTS B belong to LAC1, BTS C and BTS D
belongs to LAC2.
Test Steps 1. Paging for MS camping on LAC1;
2. Observe the paging message.
Anticipative Result 1. BTS A and BTS B receive paging message;
2. BTS C and BTS D don’t received paging message;
3. BSC send paging to BTS only the BTS belong to the
LAC.
4. In SCCP signaling trace, paging message with the correct
IMSI or TMSI of testing SIM can be found;

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 23


4.5.2 PS Paging (Optional)
Test Item PS Paging
Test Networking As shown figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. BTS A and BTS B belong to LAC1, BTS C and BTS D
belongs to LAC2.
Test Steps 1. Two MS initiate PDP context activation;
2. Wait for the timeout of GPRS Ready Timer(default 1
minute);
3. Wait for the MS A access to standby state(delete all
the route and add a directed route to MS B;
4. MS B ping MS A.
Anticipative Result 1. The SGSN sends a paging message (P-TMSI, Area,)
to the MS, which can be seen in BSSGP and PS
signal trace.
2. The MS B response the page response message in
resource request of RLCMAC signal trace
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.6 Short Message Service (SMS)


Test Item Short message service in idle mode
Test Networking
Precondition 1. check CN is healthy
2. check BSC is healthy
3. check SDR is healthy
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Test SIMs have been subscribed SMS service in HLR
Test Steps 1. MSs register successfully in the cell, in IDLE mode;
2. The test MS sends a short message to another test

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 24


MS;

Anticipative Result 1. SMS can be sent and received successfully;


2. The SMS content of received MS is same with the
content of sent MS
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.7 Emergency Call Handling


Test Item Emergency Call Handling
Test Networking
Precondition 1. check CN is healthy
2. check BSC is healthy
3. check SDR is healthy
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure the cell to support emergency call.
2. Switch on the test MS without SIM card.
3. MS makes a emergency call.
Anticipative Result The emergency call can be made successfully and the
conversation is normal.
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.8 Support 64 Neighboring Cells


Test Item Maximum Internal neighbors
Test Networking As shown in Fig.1

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 25


4. MSs are ready;
5. ensure good radio environment;
Test Steps 1. Configure more than 32 “reselection and handover
adjacent cells” of cell A and the number of different
frequency for all neighboring cells should be no more
than 31;
2. MS registers in cell A successfully;
3. Observe the CS signaling trace, check System
Information;
4. MS make CS call in cell A;
5. MS move far away from cell A to any adjacent cell
until handover be triggered.
Anticipative Result 1. System Information with all neighboring cells
description of the cell A should be collected correctly.
2. MS could handover to neighboring cells normally.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.9 A5/1 and A5/2 Ciphering Algorithm

4.9.1 Call support A5/1 ciphering algorithm

Test Item Call support A5/1 ciphering algorithm


Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Enable authentication and encryption in MSC
2. Configure the cell to support A5/1 ciphering algorithm.
3. MS1 makes a voice call.
4. No need to modify parameters in MSC;
Anticipative Result 1. Call can set up successfully using ciphering algorithm
A5/1.
Message Flow

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 26


Test Description

Test Result

Parameters Setting Default parameters

4.9.2 Call support A5/2 ciphering algorithm

Test Item Call support A5/2 ciphering algorithm


Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Enable authentication and encryption in MSC
2. Configure the cell to support A5/2 ciphering algorithm.
3. MS1 makes a voice call.
4. No need to modify parameters in MSC;
Anticipative Result 1. Call can set up successfully using ciphering algorithm
A5/2.

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.10 Cell Broadcast SMS

4.10.1 Add a new CBC message

Test Item Add a new CBC message

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 27


Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. check default cell configuration and parameters in
BSC;
5. ensure good radio environment;
6. Configure cell A as CBC cell.

Test Steps 1. Open the CS and SCCP signaling windows using


BSC Signal Trace to record signaling;
2. Add a new CBC message in CBC management
module through OMCR
3. Set broadcast period, broadcast times as default
value and trigger broadcasting
4. Check if MS register in cell A could receive the CBC
SMS;
Anticipative Result 1. The parameters related to CBC SMS could be
configured normally.
2. The predefined CBC SMS could be received by MS
according to the parameter in OMCR
3. The content of CBC SMS is correct.

Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.10.2 Delete an existed CBC message

Test Item Delete an existed CBC message


Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. check default cell configuration and parameters in
BSC;
5. ensure good radio environment;
6. Configure cell A as CBC cell.

Test Steps 1. Open the CS and SCCP signaling windows using


BSC Signal Trace to record signaling;
2. Delete an existed CBC message in CBC management

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 28


module through OMCR
3. Check if MS register in cell A could not receive the
CBC SMS any longer since it deleted;
Anticipative Result 1. The deleted CBC SMS could not be received by MS
any longer since it deleted.
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.11 Dual Transfer Mode

4.11.1 PS after CS call setup


Test Item PS after CS call setup
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. ensure Cell support EGPRS service;
8. MS support DTM, for example Nokia 6120c, E66.

Test Steps 1 Double-click “cell” tablet to open cell property “GPRS Other
Params2” page, Set “Support DTM” as “YES”
2 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
Inspect and verify no any current alarms from OMC;
3 Open the CS, PS, RLCMAC, LLC, and BSSGP signaling
windows using BSC Signal Trace to record signaling;
4 First, MS make CS call and hold on;
5 Then, MS activate PDP context and FTP download file,
for example 500kB;
6 Deactivate PDP context;
Anticipative Result 1 SI13 in CS signaling trace and PSI13 in RLCMAC
signaling trace include DTM Support to indicate that cell

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 29


supports DTM;
2 In Step 3, CS call setup successfully;
3 In step 4, MS activate PDP context successfully and
FTP download successfully.
4 In step 5, MS deactivate PDP context successfully.
5 CS voice is normal.

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.11.2 CS call when PS transferring


Test Item CS call when PS transferring
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Cell support EGPRS service;
8. MS support DTM, for example Nokia 6120c, E66.

Test Steps 1 Double-click “cell” tablet to open cell property “EDGE


params” page, Set “Support DTM” as “YES”
2 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
Inspect and verify no any current alarms from OMC;
3 Open the CS, PS, RLCMAC, LLC, and BSSGP signaling
windows using BSC Signal Trace to record signaling
4 First, MS activate PDP context and FTP download file,
for example 500kB;
5 Then, MS make CS call;
6 Observe FTP download result;

Anticipative Result 1 SI13 in CS signaling trace and PSI13 in RLCMAC


signaling trace include DTM Support to indicate that cell
supports DTM;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 30


2 In step 3, MS activate PDP context successfully;
3 In step 4, CS call setup successfully, and voice is
normal;
4 FTP download successfully;

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.12 Paging Coordination


Test Item Paging Coordination
Test Networking As shown figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready.
6. ensure good radio environment;
Test Steps 1. Configure PagCoordination as yes in BSC property
page and synchronize the data
2. MS1 registers in test cell, perform PS service such as
file download;
3. Use SAGEM OT to trace the signal of MS1.
4. MS2 make a call to MS1. Observe the paging
message send on what type of channel.
Anticipative Result 1. MS1 registers in test cell successfully in step1;
2. In the SAGEM OT trace tools, paging message could
be observed sending on PDCH in step 4.
3. the call could be established in step 4.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 31


4.13 Support of SDCCH/4 and SDCCH/8

4.13.1 Support of SDCCH/4


Test Item Support of SDCCH/4
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MS is ready;
6. ensure good radio environment;
7. Cell A and Cell B are ready

Test Steps 1. Open CS and SCCP signaling windows using BSC


Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Configure “CcchConf” as “Ccch use one physical
channel,combile with SDCCH” in Basic Param1 of Cell
level for Cell A;
4. Configure cell A as the internal adjacent
handover/reselection cell” of cell B
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. Make a CS call on Cell A;
7. Make a CS call on Cell B, then make level of Cell B
lower than Cell A to cause handover.
Anticipative Result 1. Data synchronization operation successes;
2. Cs call is normal in step 6;
3. Handover from Cell B to Cell A successfully;
4. “Handover complete” message could be observed in
CS signaling trace.
Test Description

Test Result

4.13.2 Support of SDCCH/8


Test Item Support of SDCCH/8

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 32


Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MS is ready;
6. ensure good radio environment;
7. Cell A and Cell B are ready;
8. Cell A has 4 TRXs.

Test Steps 1. Open CS and SCCP signaling windows using BSC


Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Configure “CcchConf” as “Ccch use one physical
channel,combile without SDCCH” in Basic Param1 of
Cell level for Cell A;
4. Configure cell A as the internal adjacent
handover/reselection cell” of cell B
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. In “dynamic data management” page, block TRX 2, 3,
4 in cell A.
7. Make a CS call on Cell A;
8. Make a CS call on Cell B, then make level of Cell B
lower than Cell A to cause handover.

Anticipative Result 1. Data synchronization operation successes;


2. Cs call is normal;
3. Handover from Cell B to Cell A successfully;
4. “Handover complete” message could be observed in
CS signaling trace.
Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 33


4.14 Flexible SDCCH Configuration
Test Item Flexible SDCCH Configuration
Test Networking As shown in the figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Cell with 2 TRXs
Test Steps 1. Configure SDCCH channel on BCCH TRX
2. Make a call.
3. Configure SDCCH channel on Non-BCCH TRX
4. Make a call.
Anticipative Result 1. For step 2, call can be established successfully.
2. For step 4, call can be established successfully.
Test Description

Test Result

4.15 SDCCH/SDCCH Handover


Test Item SDCCH/SDCCH handover
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 34


Test Steps 1. Configure cell A as “Adjacent cell handover and
reselection” for Cell B.
2. Enable SDCCH handover.
3. MS A makes a USSD call occupied in cell B, seized
on SDCCH channel.
4. Move MS A from cell B to cell A until handover from
cell B to cell A ;

Anticipative Result 1. “Handover command” in CS signaling trace with


“Chosen Channel: (SDCCH)”.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.16 Dynamic Configuration of SDCCH

4.16.1 TCH convert to SDCCH


Test Item TCH convert to SDCCH
Test Networking As shown in the figure 1
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in the cell A , in IDLE mode;
Test Steps 1. Inspect and verify no any current alarms from OMC;
2. In “configuration management” page , double-click
“Cell” tablet to open cell property ,;
3. In prop-up “Service process additional params” page ,
set “CanSdcchDyn” as “YES”;
4. Right-click “BSC managed element” tablet and select
“Set module parameter”;
5. In prop-up “Handover parameters of BCCH and SD”
page , set “Dynamic config SDCCH” as “YES” ;
6. set “Scan SDCCH” as “10”;
7. set “TCH->SDCCH limit” as “2”;
8. set “SDCCH->TCH delay” as “0”;
9. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
10. In “dynamic data management” page, block SDCCH

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 35


and other trxs in cell A;
11. In “dynamic data management” page ,double-click
“BTS Dynamic data management” tablet;
12. In prop-up “Cell Channel Management” page, left-click
“cell channel statistics” tablet and check the value of
“SDCCH config”;
13. Make a voice call in cell A;
14. Hold on the dial for 1 minute;
15. repeat 12;
Anticipative Result 1. Date synchronization operation successes in step 9;
2. Block channel operation successes in step 10.
3. The dial could be established and the voice is normal
in step 13;
4. In step 12 , the value of “SDCCH config” is “8”
5. In step 15 , the value of “SDCCH config” is “16”;
Test Description
Test Result

4.16.2 SDCCH convert to TCH


Test Item SDCCH convert to TCH
Test Networking As shown in the figure 1
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in the cell A , in IDLE mode;
Test Steps 1. Inspect and verify no any current alarms from OMC;
2. In “configuration management” page , double-click
“Cell” tablet to open cell property ,;
3. In prop-up “Service process additional params” page ,
set “CanSdcchDyn” as “YES”;
4. Right-click “BSC managed element” tablet and select
“Set module parameter”;
5. In prop-up “Handover parameters of BCCH and SD”
page , set “Dynamic config SDCCH” as “YES”;
6. set “Scan SDCCH” as “10”;
7. set “TCH->SDCCH limit” as “2”;
8. set “SDCCH->TCH delay” as “0”;
9. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
10. In “dynamic data management” page, block SDCCH
and other trxs in cell A;
11. In “dynamic data management” page ,double-click
“BTS management” tablet;
12. In prop-up “Cell Channel statistics”, double-click cell A
and check the value of “SDCCH config”;
13. Make a voice call in cell A;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 36


14. repeat step 12;
15. In “dynamic data management” page, unblock
SDCCH in cell A;
16. Hold on the dial for 1 minute;
17. repeat step 12;
Anticipative Result 1. Date synchronization operation successes in step 9;
2. Block channel operation successes in step 10.
3. Unblock channel operation successes in step 15;
4. The dial could be established and the voice is normal
in step 13;
5. In step 12 , the value of “SDCCH config” is “8”
6. In step 14 , the value of “SDCCH config” is “16”;
7. In step 17 , the value of “SDCCH config” is “8”;
Test Description
Test Result

4.17 Basic Handover

4.17.1 Intra-cell handover


Test Item Intra-cell handover
Test Networking
Precondition 1. check CN is healthy
2. check BSC is healthy
3. check SDR is healthy
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Switch on the intra-cell handover function in ”Handover
Control Parameters” interface.
2. The test MS makes a voice call in the cell;
3. Making some interference to the test MS to satisfy the
intra-cell handover condition.
Anticipative Result The test MS will handover to another channel in the same
cell successfully.
Parameters Setting Default parameters

Message Flow

fTest Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 37


4.17.2 Inter-cell handover
Test Item Inter-cell handover
Test Networking
Precondition 1. check CN is healthy
2. check BSC is healthy
3. check SDR is healthy
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. MS attach to cell A,
2. Create cell A and cell B as “Adjacent cell handover
and reselection” for each other. Cell A and cell B are
under the same BSC.
3. Use the test MS to make a call in cell A.
4. Move the MS from cell A to the target cell B, and
perform a handover from cell A to cell B.
5. After 1 minute, move the MS back to cell A, and
perform a handover from cell B to cell A.
Anticipative Result 1. For step 4, the MS handover from cell A to cell B
successfully.
2. For step 5, the MS handover from cell B to cell A
successfully.
Parameters Setting Default parameters

Message Flow

fTest Description

Test Result

4.18 Directed-Shift Handover


Test Item Directed-Shift Handover
Test Networking
Precondition 1 check CN is healthy, see chapter Check Test
Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 38


5 MSs are ready;
6 ensure good radio environment;
7 MS registers successfully in cell, in IDLE mode;

Test Steps 1 Set the cell allow directed-shift handover


2 Configure cell B as ’Is handover forced neighbor cell’ for
Cell A.
3 Set ‘MaxLossThs’=150, ’ MaxTAThs’=40 ’P value of
force handover ‘=3 and ‘N value of force handover’=2 in
handover algorithm parameters interface
4 The available resource of target cell B must be higher
than the parameter ‘HoForceResThs’ (40% as default) ;
5 The difference of Rx_level between source cell and
target cell must be higher than the parameter
MaxForceHoDiff’ (9 as default);
6 Open signal trace;
7 MS make a call in source cell A;
8 Move MS towards cell A and cell B till directed-shift
handover to cell B.

Anticipative Result 1. There is in Handover Performed message in SCCP


signaling trace, and the cause is Better cell.
2. There is “handover complete” in CS signaling trace.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.19 Directed Retry


Test Item Direct Retry
Test Networking As shown Fig. 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Switch on the directed retry function in cell A
2. Configure cell B as “Adjacent cell handover and
reselection” of cell A;
3. Block all the TCH channels in cell A;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 39


4. Make a CS call in the field of cell A;
5. Check the channel is occupied in cell B;

Anticipative Result 1. The call can be directed to cell B successfully and the
conversation is normal in cell B.
Test Description

Test Result

4.20 Traffic Based Handover


Test Item Traffic Based Handover
Objectives To verify the handover based on traffic load successfully
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in cell, in IDLE mode;
8. Configure cell A as 900M, cell B as 1800M
Test Steps 1. Configure cell B as “Adjacent cell handover and
reselection” for Cell A, and cell B is upper layer;
2. Allow automatic handover based on traffic of cell A;
3. Adjust 'Layer control value for handover on traffic' to
2(upper layer);
4. Adjust 'Frequency control value for handover on traffic' to
DCS1800;
5. Set 'TrafficThs ' in handover control parameters interface
(for example from default value 70% to 1%);
6. MS A make a call occupied in cell A;
7. MS B make another call in cell A, meeting with the traffic
handover threshold, MS A handover to cell B. MS B
occupied in cell A.

Anticipative Result 1. “Channel Activation” to activation TCH in source cell can


be found the cell is the 900M cell;
2. “Handover Command” can be found in CS signal, and

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 40


including the target cell description, the target cell is
1800M cell;
3. “Handover Performed” can be found in SCCP signal,
and the handover cause is ‘reduce load in serving cell’.
Test Description

Test Result

4.21 Dynamic Handover Priority Algorithm

4.21.1 Static handover priority


Test Item Static handover priority
Test Networking
Precondition 1 check CN is healthy, see chapter Check Test
Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;

Test Steps 1 Configure cell B and cell C as “Adjacent cell handover


and reselection” for Cell A
2 Priority of cell B is higher than that of cell C. (for
example: Cell B’s priority is 6 and cell C’s priority is 5)
3 Disable dynamic priority
4 Rx_level of cell C > Rx_level of cell B > Rx_level of cell
A
5 MS make a call occupied in cell A
6 MS handover successfully , and target cell is cell B due
to priority
7 Adjust Rx_level of each cell to make Rx_level of cell
B > Rx_level of cell C > Rx_level of cell A, repeat step
5-6.
Anticipative Result 1 BSC select appropriate target cell (Cell B) after
evaluate the priority. (priority 1 is higher than priority 0)
Message Flow
Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 41


Parameters Setting Default parameters

4.21.2 Dynamic handover priority


Test Item Dynamic handover priority
Test Networking
Precondition 1 check CN is healthy, see chapter Check Test
Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
Test Steps 1 Configure cell B and cell C as “Adjacent cell handover
and reselection” for Cell A
2 Priority of cell B is higher than that of cell C. (for
example: Cell B’s priority is 6 and cell C’s priority is 5)
3 Set “ResourceThs” of serving cell as “25”.
4 Enable dynamic priority;
5 Rx_level of cell B > Rx_level of cell C > Rx_level of cell
A
6 Set “Difference of dynamic priority” as default value 1
7 Make some calls, idle channel percentage of cell B is
lower than 50%;
8 MS make a call occupied in cell A
9 MS handover successfully , and target cell is cell C due
to evaluate the load of all target cells
10 Adjust Rx_level of each cell to make Rx_level of cell
C > Rx_level of cell B > Rx_level of cell A, repeat step
7-8.

Anticipative Result 1 BSC select appropriate target cell (cell C) after evaluate
the load of all target cells
Message Flow
Test Description

Test Result

Parameters Setting Default parameters

4.22 Traffic Hold at Channel Blocking


Test Item Traffic Hold at Channel Blocking

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 42


Test Networking

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;

Test Steps 1 Configure cell B as the neighbouring cell of cell A;


2 Make a call in the cell A;
3 In dynamic management, delay block the channel
where the call is on;
4 Check the status of the channel which is delay blocked
in step 3
Anticipative Result 1 For step 3, the call will be handovered to cell B. The call
can continue without broken in cell B.
2 For step 4, the channel status should be manually
blocked.
Test Description

Test Result

4.23 Dynamic Half Rate Allocation


Test Item Dynamic Half Rate Allocation
Test Networking

Precondition 1. Check CN is healthy, see chapter Check Test


Environment;
2. Check BSC is healthy, see chapter Check Test
Environment;
3. Check SDR is healthy, see chapter Check Test
Environment;
4. Check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. Ensure good radio environment;
7. Ensure CN support half speech coding;
Test Steps 1. Open the CS and SCCP signaling windows using
BSC Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Double-click “BSC function” tablet to open “BSC
function” property page;
4. In “Radio basic property” tablet, set “Dynamic HR
enable” as “yes”;
5. In “others” tablet, set “Preferred Speech version (half)”
as “half Rate version 1”, set “Preferred Speech
version (full)” as “full Rate version 1”;
6. Double-click “cell” tablet to open cell property page;
7. In “channel allocation control params” tablet, set the

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 43


corresponding “Channel Type” to “According to
channel select order of MSC, when prefer TCHF and
congest change to prefer TCHH” according to the MS
priority;
8. In cell “base params1” tablet, set “Dynamic HR
support indication” as “yes”, set “Use cell dynamic HR
parameter” as “yes”, Set “Threshold for a single TRX
switched from FR to HR” as “1”and “Threshold for a
single TRX switched from AMR FR to AMR HR’;
9. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
10. In the cell, use mobile phone 1 , 2 which support half
rate to make calls in order;
11. In “dynamic data management” page, inquire the
channels statement.
Anticipative Result 1. Data synchronization operation successes;
2. Calls could be established and the voice is normal;
3. In step 11, mobile phone 1 occupy FR channel, and
mobile phone 2 occupy HR channel;
4. “Assignment Completed” message of TCH containing
indication of HR version 1 for the call of mobile phone
2 could be observed in SCCP signaling trace.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.24 Dynamic BTS Power Control


Test Item Dynamic BTS power control
Test Networking
Precondition 1 check CN is healthy, see chapter Check Test
Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MS is ready and registers successfully in serving cell, in
IDLE mode;
6 cell supports BTS Dynamic Downlink Power Control ;
7 close dynamic uplink power control indication;
8 Pn means BTS maximum transmit power in serving cell;
9 PWRREDSTEP_0 and PWRINCSTEP_0 mean
decreasing or increasing step length of power control,

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 44


default value is 2;
10 according to feature description, the value range of DL
power level is 0-63 and DL quality level is 0-7,,
corresponding meanings as FD stated;
Test Steps 1 On “configuration management” page, double-click
“cell” tablet to open “power control1” window, select
“other property” page;
a)set downlink power control allowed to “yes”
b)modify the parameter BSTXPWRMIN_0 to value 15,
means BTS minimum permitted transmit power is Pn-
30dB in serving cell;
c)modify the parameters PWRREDSTEP_0 and
PWRINCSTEP_0 to value 4db and 4db;
2 On “power control1” window, select “power adjust
threshold” page, set the parameters
PCDLINCLLEVTHS_0, PCDLREDLEVTHS_0, P and N
such as value 34,42,1,1.(means when P samples
among N satisfy : DLRx_lev< PCDLINCLLEVTHS_0,
cause BTS downlink power increasing; OR: DLRx_lev>
PCDLREDLEVTHS_0, cause BTS downlink power
decreasing);
3 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
4 Make a CS call in serving cell, hold on.
5 Keep the MS away from or close to BTS constantly;
6 Observe the measurement result in CS signaling trace;
Anticipative Result 1 The signaling “power control indication” can be found in
CS signaling trace and the Radio Link Direction of
Power Control is downlink direction.
2 Before power control indication, BS power is 00 in
measurement result;
3 When making MS close to BTS, DL Power dynamically
decrease , the decreasing step length is 4db as setting
value;
4 When making MS away from BTS, DL Power
dynamically increase to hold the call, the increasing
step length is 4db as setting value.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 45


4.25 Dynamic MS Power Control
Test Item Dynamic MS Power Control
Test Networking
Precondition 1 check CN is healthy, see chapter Check Test
Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MS is ready and registers successfully in serving cell, in
IDLE mode;
6 MS MAX power level is 05 such as NOKIA6120c;
Test Steps 1 On “configuration management” page, double-click
“cell” tablet to open cell basic parameter3 page, set the
parameter ‘MsTxPwrMaxCch’ as default value 5;
2 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
3 Make a CS call in serving cell, hold on.
4 Open the signaling trace, observe the measurement
result in CS signaling trace;
5 Modify the parameter ‘MsTxPwrMaxCch’ to value 4,
repeat step 2-4;
6 Modify the parameter ‘MsTxPwrMaxCch’ to value 6,
repeat step 2-4;
Anticipative Result 1 When ‘MsTxPwrMaxCch’=5, MS power level is 05 in the
first measurement result;
2 When ‘MsTxPwrMaxCch’=4, MS power level is 05 in the
first measurement result;
3 When ‘MsTxPwrMaxCch’=6, MS power level is 06 in the
first measurement result;
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.26 Downlink Rapid Power Control


Test Item Downlink Rapid Power Control

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 46


Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

Test Steps 1. Set the cell power control params as default value;
2. Switch on the downlink rapid power control in the cell;
3. Configure the cell with at least two TRXs;
4. Make a call in the non-BCCH TRX in serving cell, hold
on;
5. Keep MS close to the BTS , wait a few minutes to
observe the power decreasing when DL level is high;
6. Observe the measurement result and power control
indication in CS signaling trace;

Anticipative Result 1. The signaling “power control indication” can be found


in CS signaling trace and the Radio Link Direction of
Power Control is downlink direction.
2. ‘BTS power level’ in measurement report changed
with variable steps as default value.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.27 AMR Power Control

4.27.1 AMR Dynamic Downlink Power Control


Test Item AMR Power Control
Sub-Item AMR FR Dynamic Downlink Power Control
Objectives To verify the function of AMR FR dynamic downlink power
control is normal
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 47


2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. cell supports AMR Dynamic Downlink Power Control ;
6. testing phones are ready supported AMR (eg. NOKIA
6120c);
7. check the code type priority class is “priority
class1(P1):AMR FR, P2:EFR, P3:FR, P4: AMR HR,
P5:HR” on CN side;
Test Steps 1. On “configuration management” page, double-click
“cell” tablet to open “power control1” window, select
“other property” page,
a) set downlink power control allowed to “yes”;
b)set the parameters “ BSTXPWRMIN_2”
“PCMININTERVAL_2” “PWRINCSTEP_2”
“PWRREDSTEP_2” as default value;
2. On “power control1” window, select “power adjust
threshold” page, set the parameters
“PCDLINCLLEVTHS_2”, “PCDLREDLEVTHS_2”,
“PCDLINCLQUALTHS_2”, “PCDLREDQUALTHS_2”, P
and N as default value;
3. Double-click “bsc function” tablet to select “other
params” page, set the “PreferSpeechVer” as “No
preferred version”;
4. Double-click “cell” tablet to select “other params” page,
set “ChanSelectPrio_0” and “ChanSelectPrio_1” to “No
change”;
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. Make a CS call in serving cell, hold on.
7. Keep the MS away from or close to BTS constantly;
8. Save Abis, A interface signal trace, observe the
measurement result and power control indication in CS
signaling trace
Anticipative Result 1. In step5, “synchronize modified data” is successful;
2. “GSM speech coding algorithm version3” “Channel
rate and type (Full rate TCH/Bm)” message could be
found in “Channel Activation”
3. “ Set of AMR codec modes: 12.2kbit/s codec rate is
part of the subset” can be found in the message

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 48


“ASSIGN COMMAND” in CS signaling trace;
4. The signaling “power control indication” can be found
in CS signaling trace and the Radio Link Direction of
Power Control is downlink direction.
5. In step7, downlink Power dynamically decrease or
increase, the step length is 2db as setting default
value;
Test Description

Test Result

4.27.2 AMR Dynamic Uplink Power Control


Test Item AMR Power Control
Sub-Item AMR FR Dynamic Uplink Power Control
Objectives To verify the function of AMR FR dynamic uplink power
control is normal
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. cell supports AMR Dynamic uplink Power Control ;
6. testing phones are ready supported AMR (eg. NOKIA
6120c);
7. check the code type priority class is “priority
class1(P1):AMR FR, P2:EFR, P3:FR, P4: AMR HR,
P5:HR” on CN side;
Test Steps 1. On “configuration management” page, double-click
“cell” tablet to open “power control1” window, select
“other property” page,
a) set uplink/downlink power control to default
“yes/no”;
b)set the parameters “ MSTXPWRMAX_2”
“MSTXPWRMIN_2” “PCMININTERVAL_2”
“PWRINCSTEP_2” “PWRREDSTEP_2” as default
value;
2. On “power control1” window, select “power adjust
threshold” page, set the parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 49


“PCULINCLLEVTHS_2”, “PCULREDLEVTHS_2”,
“PCULINCLQUALTHS_2”, “PCULREDQUALTHS_2”, P
and N as default value;
3. Double-click “bsc function” tablet to select “other
params” page, set the “PreferSpeechVer” as “No
preferred version”;
4. Double-click “cell” tablet to select “other params” page,
set “ChanSelectPrio_0” and “ChanSelectPrio_1” to “No
change”;
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. Make a CS call in serving cell, hold on.
7. Save Abis, A interface signal trace, observe the
measurement result and power control indication in CS
signaling trace
Anticipative Result 1. In step5, “synchronize modified data” is successful;
2. “GSM speech coding algorithm version3” “Channel
rate and type (Full rate TCH/Bm)” message could be
found in “Channel Activation”
3. “ Set of AMR codec modes: 12.2kbit/s codec rate is
part of the subset” can be found in the message
“ASSIGN COMMAND” in CS signaling trace;
4. The signaling “power control indication” can be found
in CS signaling trace and the Radio Link Direction of
Power Control is uplink direction.
5. In step6, uplink Power dynamically decrease or
increase, the step length is 2db as setting default
value;
Test Description

Test Result

4.28 Static BTS Power Control


Test Item Static BTS Power Control
Objectives To verify if Power control by OMC is normal
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 50


3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in cell, in IDLE mode;
8. RU support BTS Static Power Level adjust ;

Test Steps 1. modify static BTS power control parameter;


2. measure power output via spectrum analyser

Anticipative Result 1 The BTS Static Power should be modified successfully;


2 The output power should be adjusted correctly.
Test Description

Test Result

4.29 Discontinuous Transmission Downlink


Test Item DL DTX
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in cell, in IDLE mode;
8. Cell support DL DTX;
Test Steps 1. Check system information of BTS
2. Turn OFF UL DTX at the cell of MO side
3. Use two MSs to make a MO and a MT Call test in the
cell, make the call holding;
4. talking at MO side, then stop talking repeatedly;
5. Listen the speech quality at MT side and confirm no
“click” sound during DL DTX ON <-> OFF
6. Observe the measurement report of MT DTX
indication in CS signaling trace;
7. Make inter cell HO triggered by DL level with N/P
voting is 10/10 & weight = 3. Confirm BSC make a
HO after 10 x DL level_SUB (not level_full) and the
weight is applied
8. Turn OFF DL DTX in the cell of MT side and repeat
above. Confirm DTX is always OFF when talking or
not talking at MO. Handover is triggered when 10 x

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 51


DL level full is fulfilled, weight is not applied

Anticipative Result 1. System information is correct. When DL DTX is ON,


SI indicate it is ON.
2. when stop talking at MO side,MT measurement
report Indicate DL DTX is used in CS signaling trace.
3. BSC make a HO after 10 x measurement result with
average DL level of 10 x measurement report with
weight < defined threshold
4. When DL DTX is off, DL DTX indicator is always off.
BSC use the Rx level_full to judge the HO, weight has
no effect
5. Please calculate the average DL RX level of 10 x
measurement report and the threshold on the test
result. Compare with and without DTX
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.30 Discontinuous Transmission Uplink


Test Item UL DTX
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in cell, in IDLE mode;
Test Steps 1. Set cell support UL DTX (DtxUplinkBcch=1);
2. Check system information of BTS
3. Use two MS make a MO and a MT Call test in the
cell, make the call holding;
4. Talking to MO then stop repeatedly;
5. Listen the speech quality at MT side and confirm no
“click” sound during UL DTX ON <-> OFF
6. Observe the measurement report of MO DTX
indication in CS signaling trace;
7. Set the inter cell HO trigger by using DL level with N/P
voting is 10/10 and weight = 5. Confirm BSC make a
HO after 10 x DL level_SUB (not level_full) and the

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 52


weight is applied
8. Turn OFF UL DTX (Dtxuplinkbcch = 2) in the cell of
MO side and repeat above. Confirm UL DTX is
always OFF when talking or not talking at MO side.
Handover is triggered when 10 x UL level full is
fulfilled, weight is not considered.

Anticipative Result 1. System information is correct. When UL DTX is ON,


SI indicate it is ON. When UL DTX is off, SI indicate it
is OFF
2. when stop talking at MO side,MO measurement
report indicate UL DTX can be used in CS signaling
trace
3. BSC make a HO after 10 x measurement result with
weak UL level
4. When UL DTX is off, UL DTX indicator is always off.
BSC use the Rx level_full to judge the HO
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.31 Coding Scheme CS1~CS4

4.31.1 Coding scheme CS1


Test Item Coding scheme CS1
Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports GPRS is ready;
5 Ensure good radio environment;
6 Cell only supports GPRS service.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, double click on
“cell” tablet to open cell property page;
3 Set the GPRS initial coding scheme as CS1

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 53


4 Set “GPRS phones init code can be
changed(InitAttachExch_1)” as “No”;
5 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6 MS performs attach and PDP activation in the cell;
7 MS performs ping testing (20 packets) in the cell;
8 Observe the BSC Signal Trace.
Anticipative Result 1 “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2 The coding scheme in “Uplink Assignment” message in
RLC/MAC signaling trace is “CS-1”;
3 No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.31.2 Coding scheme CS2


Test Item Coding scheme CS2
Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports GPRS is ready;
5 Ensure good radio environment;
6 Cell only supports GPRS service.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, double click on
“cell” tablet to open cell property page;
3 Set the GPRS initial coding scheme as CS2;
4 Set “GPRS phones init code can be
changed(InitAttachExch_1)” as “No”;
5 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6 MS performs attach and PDP activation in the cell;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 54


7 MS performs ping testing (20 packets) in the cell;
8 Observe the BSC Signal Trace.
Anticipative Result 1 “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2 The coding scheme in “Uplink Assignment” message in
RLC/MAC signaling trace is “CS-2”;
3 No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.31.3 Coding scheme CS3


Test Item Coding scheme CS3
Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports GPRS is ready;
5 Ensure good radio environment;
6 Cell only supports GPRS service.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, double click on
“cell” tablet to open cell property page;
3 Set the GPRS initial coding scheme as CS3;
4 Set “GPRS phones init code can be
changed(InitAttachExch_1)” as “No”;
5 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6 MS performs attach and PDP activation in the cell;
7 MS performs ping testing (20 packets) in the cell;
8 Observe the BSC Signal Trace.
Anticipative Result 1 “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2 The coding scheme in “Uplink Assignment” message in

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 55


RLC/MAC signaling trace is “CS-3”;
3 No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.31.4 Coding scheme CS4


Test Item Coding scheme CS4
Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports GPRS is ready;
5 Ensure good radio environment;
6 Cell only supports GPRS service.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, double click on
“cell” tablet to open cell property page;
3 Set the GPRS initial coding scheme as CS4
4 Set “GPRS phones init code can be
changed(InitAttachExch_1)” as “No”;
5 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6 MS performs attach and PDP activation in the cell;
7 MS performs ping testing (20 packets) in the cell;
8 Observe the BSC Signal Trace.
Anticipative Result 1 “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2 The coding scheme in “Uplink Assignment” message in
RLC/MAC signaling trace is “CS4”;
3 No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 56


4.32 Modulation and Coding Scheme #1~#9

4.32.1 Modulation and coding scheme #1


Test Item Modulation and coding scheme #1
Test Networking
Precondition 1. Check CN is healthy, see chapter Check Test
Environment;
2. Check BSC is healthy, see chapter Check Test
Environment;
3. Check SDR is healthy, see chapter Check Test
Environment;
4. A MS which supports EGPRS is ready;
5. Ensure good radio environment;
6. Cell supports EDGE service.
Test Steps 1. Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2. In “configuration management” page, double click on
“cell” tablet to open cell property page;
3. In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme” and
“EGPRS downlink init.coding scheme” as “MCS1”;
4. In “EDGE params” tablet, set “EGPRS phones init
code can be changed(InitAttachExch_1)” as “No”;
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. MS performs attach and PDP activation in the cell;
7. MS performs ping testing (20 packets) in the cell;
8. Observe the BSC Signal Trace.
Anticipative Result 1. “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2. The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC
signaling trace is “MCS-1”;
3. No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.32.2 Modulation and coding scheme #2


Test Item Modulation and coding scheme #2
Test Networking
Precondition 1. Check CN is healthy, see chapter Check Test
Environment;
2. Check BSC is healthy, see chapter Check Test
Environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 57


3. Check SDR is healthy, see chapter Check Test
Environment;
4. A MS which supports EGPRS is ready;
5. Ensure good radio environment;
6. Cell supports EDGE service.
Test Steps 1. Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2. In “configuration management” page, double click on
“cell” tablet to open cell property page;
3. In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme” and
“EGPRS downlink init.coding scheme” as “MCS2”;
4. In “EDGE params” tablet, set “EGPRS phones init
code can be changed(InitAttachExch_1)” as “No”;
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. MS performs attach and PDP activation in the cell;
7. MS performs ping testing (20 packets) in the cell;
8. Observe the BSC Signal Trace.
Anticipative Result 1. “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2. The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC
signaling trace is “MCS-2”;
3. No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.32.3 Modulation and coding scheme #3


Test Item Modulation and coding scheme #3
Test Networking
Precondition 1. Check CN is healthy, see chapter Check Test
Environment;
2. Check BSC is healthy, see chapter Check Test
Environment;
3. Check SDR is healthy, see chapter Check Test
Environment;
4. A MS which supports EGPRS is ready;
5. Ensure good radio environment;
6. Cell supports EDGE service.
Test Steps 1. Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2. In “configuration management” page, double click on
“cell” tablet to open cell property page;
3. In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme”,
“EGPRS downlink init.coding scheme” as “MCS3”;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 58


4. In “EDGE params” tablet, set “EGPRS phones init
code can be changed(InitAttachExch_1)” as “No”;
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. MS performs attach and PDP activation in the cell;
7. MS performs ping testing (20 packets) in the cell;
8. Observe the BSC Signal Trace.
Anticipative Result 1. “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2. The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC
signaling trace is “MCS-3”;
3. No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.32.4 Modulation and coding scheme #4


Test Item Modulation and coding scheme #4
Test Networking
Precondition 1. Check CN is healthy, see chapter Check Test
Environment;
2. Check BSC is healthy, see chapter Check Test
Environment;
3. Check SDR is healthy, see chapter Check Test
Environment;
4. A MS which supports EGPRS is ready;
5. Ensure good radio environment;
6. Cell supports EDGE service.
Test Steps 1. Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2. In “configuration management” page, double click on
“cell” tablet to open cell property page;
3. In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme” as
“EGPRS downlink init.coding scheme”;
4. In “EDGE params” tablet, set “EGPRS phones init
code can be changed(InitAttachExch_1)” as “No”;
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. MS performs attach and PDP activation in the cell;
7. MS performs ping testing (20 packets) in the cell;
8. Observe the BSC Signal Trace.
Anticipative Result 1. “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2. The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC
signaling trace is “MCS-4”;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 59


3. No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.32.5 Modulation and coding scheme #5


Test Item Modulation and coding scheme #5
Test Networking
Precondition 1. Check CN is healthy, see chapter Check Test
Environment;
2. Check BSC is healthy, see chapter Check Test
Environment;
3. Check SDR is healthy, see chapter Check Test
Environment;
4. A MS which supports EGPRS is ready;
5. Ensure good radio environment;
6. Cell supports EDGE service.
Test Steps 1. Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2. In “configuration management” page, double click on
“cell” tablet to open cell property page;
3. In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme” and
“EGPRS downlink init.coding scheme” as “MCS5”;
4. In “EDGE params” tablet, set “EGPRS phones init
code can be changed(InitAttachExch_1)” as “No”;
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. MS performs attach and PDP activation in the cell;
7. MS performs ping testing (20 packets) in the cell;
8. Observe the BSC Signal Trace.
Anticipative Result 1. “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2. The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC
signaling trace is “MCS-5”;
3. No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 60


4.32.6 Modulation and coding scheme #6
Test Item Modulation and coding scheme #6
Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports EGPRS is ready;
5 Ensure good radio environment;
6 Cell supports EDGE service.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, double click on
“cell” tablet to open cell property page;
3 In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme” and
“EGPRS downlink init.coding scheme” as “MCS6”;
4 In “EDGE params” tablet, set “EGPRS phones init code
can be changed(InitAttachExch_1)” as “No”;
5 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6 MS performs attach and PDP activation in the cell;
7 MS performs ping testing (20 packets) in the cell;
8 Observe the BSC Signal Trace.
Anticipative Result 1 “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2 The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC signaling
trace is “MCS-6”;
3 No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.32.7 Modulation and coding scheme #7


Test Item Modulation and coding scheme #7

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 61


Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports EGPRS is ready;
5 Ensure good radio environment;
6 Cell supports EDGE service.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, double click on
“cell” tablet to open cell property page;
3 In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme” and
“EGPRS downlink init.coding scheme “as “MCS7”;
4 In “EDGE params” tablet, set “EGPRS phones init code
can be changed(InitAttachExch_1)” as “No”;
5 BSC function tablet ,change the highest coding scheme
of signal TBF as MCS 7;
6 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7 MS performs attach and PDP activation in the cell;
8 MS performs ping testing (20 packets) in the cell;
9 Observe the BSC Signal Trace.
Anticipative Result 1 “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2 The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC signaling
trace is “MCS-7”;
3 No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.32.8 Modulation and coding scheme #8


Test Item Modulation and coding scheme #8

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 62


Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports EGPRS is ready;
5 Ensure good radio environment;
6 Cell supports EDGE service.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, double click on
“cell” tablet to open cell property page;
3 In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme” and
“EGPRS downlink init.coding scheme” as “MCS8”;
4 In “EDGE params” tablet, set “EGPRS phones init code
can be changed(InitAttachExch_1)” as “No”;
5 BSC function tablet ,change the highest coding scheme
of signal TBF as MCS 8;
6 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7 MS performs attach and PDP activation in the cell;
8 MS performs ping testing (20 packets) in the cell;
9 Observe the BSC Signal Trace.
Anticipative Result 1 “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2 The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC signaling
trace is “MCS-8”;
3 No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.32.9 Modulation and coding scheme #9


Test Item Modulation and coding scheme #9

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 63


Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports EGPRS is ready;
5 Ensure good radio environment;
6 Cell supports EDGE service.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, double click on
“cell” tablet to open cell property page;
3 In “EDGE params” tablet, set “EGPRS Phone Init
Coding” of “EGPRS uplink init.coding scheme” and
“EGPRS downlink init.coding scheme “as “MCS9”;
4 BSC function tablet ,change the highest coding scheme
of signal TBF as MCS 9;
5 In “EDGE params” tablet, set “EGPRS phones init code
can be changed(InitAttachExch_1)” as “No”;
6 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7 MS performs attach and PDP activation in the cell;
8 MS performs ping testing (20 packets) in the cell;
9 Observe the BSC Signal Trace.
Anticipative Result 1 “Attach accept” message and “Activate PDP context
accept” message can be found in LLC signaling trace;
2 The value of “EGPRS Modulation and Coding IE” field
in “Uplink Assignment” message in RLC/MAC signaling
trace is “MCS-9”;
3 No packet loss when ping.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.33 STM-1 Support on A Interface


Test Item STM-1 Support on A Interface

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 64


Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. A interface transfer over STM-1.
Test Steps 1. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2. Make a CS call and hold on for 2 minutes in each cell
3. Perform handover between cells
4. Perform cell selection when data transferring
Anticipative Result 1. CS call could be established successfully in all cells,
and the voice is clear.
2. Handover could be triggered and performed normally
and the voice is normal.

Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.34 STM-1 Support on Ater Interface


Test Item STM-1 Support on Ater Interface
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Ater interface transfer over STM-1.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 65


Test Steps 1. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2. Make a CS call and hold on for 2 minutes in each cell
3. Perform handover between cells
4. Make PS service such as attach, PDP active, file
download/upload in each cell.
5. Perform cell selection when data transferring
Anticipative Result 1. CS call could be established successfully in all cells,
and the voice is clear.
2. Handover could be triggered and performed normally
and the voice is normal.
3. PS service is normal, the speed of data transferring is
ideal.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.35 STM-1 Support on Abis Interface


Test Item STM-1 Support on Abis Interface
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Abis interface transfer over STM-1.
Test Steps 1. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2. Make a CS call and hold on for 2 minutes in each cell
3. Perform handover between cells
4. Perform cell selection when data transferring
Anticipative Result 1. CS call could be established successfully in all cells,
and the voice is clear.
2. Handover could be triggered and performed normally
and the voice is normal.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 66


Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.36 2M High Speed Signaling Link


Test Item 2M High speed Signaling Link
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Configure a 2M signaling link.
Test Steps 1. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2. Make a CS calls and hold on for 2 minutes.
3. Perform handover between cells
Anticipative Result 1. CS call could be established successfully in all cells,
and the voice is clear.
2. Handover could be triggered and performed normally
and the voice is normal.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.37 TC Resource Dynamic Sharing


Test Item TC Resource Dynamic Sharing
Test Networking As shown in the figure 1

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 67


Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure the BSC with some DRTB boards
2. Make a call
Anticipative Result 1. The call can be established successfully

Test Description TC resource is not fixed configured. So, TC resource is


allocated dynamically naturally.

4.38 PCU Resource Dynamic Allocation


Test Item PCU Resource Dynamic Sharing
Test Networking As shown in the figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure the BSC support GPRS or EDGE
2. Use the test MS to PS attach, PDP activate and
perform PING service (32 bytes, 50 packets)
Anticipative Result 1. The PING success, no packet loss.

Test Description The PCU resource is not fixed configured. So, PCU
resource is allocated dynamically naturally.

4.39 Abis over IP


Test Item Abis over IP
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 68


2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Abis interface transfer over IP
Test Steps 1. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2. Make a CS call and hold on for 2 minutes in each cell
3. Perform handover between cells
4. Perform cell selection when data transferring
Anticipative Result 1. CS call could be established successfully in all cells,
and the voice is clear.
2. Handover could be triggered and performed normally
and the voice is normal.

Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.40 Gb over IP
Test Item BSC to support Gb over IP
Test Networking

Precondition 1 GSM system is ready, the Gb interface is GE mode;


2 check CN is healthy;
3 check BSC is healthy;
4 check SDR is healthy;
5 check default cell configuration and parameters in BSC;
6 MSs are ready;
7 ensure good radio environment.

Test Steps 1 Make CS service, such as: location request, voice call;
2 observe SCCP and CS signaling trace;
3 GB link is shared among 2 physical GB interface
4 enable GPRS on the tested cell, observe the signaling
message transfer from BSC to SGSN.
5 make PS service,such as attach,PDP context
activation; and ping test
6 Login Cisco Core6513 to observe interface counter and
find these uplink data flow assigned to which physical

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 69


Gb interface;
7 observe GB signaling trace.
8 Disconnect the GB interface

Anticipative Result 1 The conversation is normal,the quality of uplink and


downlink is good;.
2 these are “assign complete” in CS(ABIS interface)
signaling trace;
3 There are NS Live and NS LIVE ACK signal in NS
signal trace and it means GB link between BSC and
SGSN is normal
4 PS service is normal,
5 There are “attach complete” and “PDP context accept”
in GB signaling trace;
6 Uplink data flow should be assigned to different Gb
interface for load sharing;
7 When GB interface is disconnected.. The Ping test is
stalled

Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.41 Remote Transcoder Support


Test Item Remote Transcoder Support
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. Check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. Ensure good radio environment;
7. BSC connect to external TC
Test Steps 1. MS power on.
2. Use test MS to make voice call.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 70


Anticipative Result 1. The call could be established and the conversation is
normal.
Parameters Setting Default parameters

Message Flow

Test Description

4.42 Distributed Architecture of BTS


Test Item Distributed Architecture of BTS
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in cell, in IDLE mode;
8. The SDR type should support separated BBU and RU
Test Steps 1. The BTS supports separated BBU and RU (Remote
RU, RRU). The BBU is in equipment room. The RRU
is set close to antenna.
2. Check the status of BTS;
3. Make a call under the BTS;
Anticipative Result 1. For step 2, the status of the BTS should be normal;
2. For step 3, the call can be established under the BTS
successfully;
Test Description

Test Result

4.43 MMR
Test Item Massive Measurement Report
Test Networking As shown figure 1

Precondition 1. iBSC is healthy;


2. OMC and MR works normally;
3. the communication between iBSC and OMC is
normal;
4. the communication between iBSC and MR is normal;
5. the communication between MR and OMC is normal;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 71


Test Steps 1. Open Other parameters page in Set module
parameter window and set:
MR server IP: 10.9.0.62
MR server port:15000
2. In the [Configuration Management] window, double
click [BSC function] node and click [Radio basic
property] page in right view;
3. set MrRptEnable as YES in Radio basic property page
to enable MR function;
4. In the [Configuration Management] window, double
click a cell and click [Other params] in right view;
5. Set Preprocess as 0;.
6. Set MR report bmp: select all timeBMP;
7. MS makes a call in this cell and keep about 1 minute;
8. ftp OMC using user/password:ftpMR/ftpMR and get
MR stat. file;
Anticipative Result 1. MR stat. file can be obtained successfully;

Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.44 GSM/WCDMA Interworking Phase I

4.44.1 2G <-> 3G reselection in idle mode


Test Item 2G <-> 3G reselection in idle mode
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Use dual-mode handset, the handset should support
GPRS
8. Configure neighbor cell in different systems: cell1
(WCDMA), cell2(GSM)

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 72


9. UE registers cell2 successfully, in IDLE mode, Ensure
test cell supporting Packet service.
10. cell without PBCCH;
Test Steps 1. MS registeres in idle mode in 2G cell
2. Move the MS to cell1 cell and MS reselect to 3G cell
3. Move MS back to cell2 and MS reselect to 2G cell.
Anticipative Result 1. UE can reselect between cell 1 and cell2 successfully;
2. there is “location update acception” in SCCP and CS
singnalling trace;
3. There is “RA complete” in GB singnalling trace.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.44.2 2G <-> 3G reselection (packet transfer mode)


Test Item 2G <-> 3G reselection (packet transfer mode)
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Use dual-mode handset, the handset should support
GPRS
8. Configure neighbor cell in different systems: cell
2(WCDMA), cell1(GSM)
9. UE register successfully, in IDLE mode
10. cell without PBCCH;
Test Steps 1. Perform ftp downloading with UE at cell1
2. Use MCSF to trigger MS reselect to 3G cell
3. Use MCSF to trigger MS reselect to 2G cell
Anticipative Result 1. UE can reselect between cell1 and cell2 successfully,
FTP download could resume after cell reselection.
2. There is “RA complete” in GB singnalling trace.
Message Flow

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 73


Test Description

Test Result

Parameters Setting Default parameters

4.44.3 2G <-> 3G dedicated mode HO (voice)


Test Item 2G <-> 3G dedicated mode HO (voice)
Test Networking

Precondition 1. WCDMA/GSM systems are ready;


2. check CN is healthy, see chapter Check Test
Environment;
3. check BSC is healthy, see chapter Check Test
Environment;
4. check SDR is healthy, see chapter Check Test
Environment;
5. check default cell configuration and parameters in
BSC;
6. MSs are ready;
7. ensure good radio environment;
8. Use dual-mode handset capable for 900M WCDMA
9. Configure neighbor cell in different systems: cell1
(WCDMA) and cell2(GSM) ;
10. Several UEs register successfully, in IDLE mode;
Test Steps 1. Enable inter-system handover by setting
‘InterSysHoTrl’ as ‘yes’
2. enable traffic handover by setting ‘Allow automatic
handover based on traffic’ as ‘yes’
3. Set 'TrafficThs ' of cell2 as 1% in handover control
parameters of cell2;
4. Set ‘LoadHoEcNoThsFDD’ as 5 in UTRAN adjacent
cell paramenters
5. MS A Makes a voice call in cell2
6. MS B makes another call in cell 2, MS A handover to
cell 1. MS B occupied in cell 2.
7. Use MCSF to trigger handover to form 3G cell1 to 2G
cell2;
Anticipative Result 1. There is handover complete in CS and SCCP signal
2. HO between cell1 and cell2 can be performed
successfully, the call is remained during handover
Message Flow

Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 74


Parameters Setting Default parameters

4.45 Flexible MAIO Management


Test Item Flexible MAIO Management
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. BTS with 3 cells, cell A ,cell B, cell C, each cell have a
BCCH TRX with different ARFCN;
Test Steps 1. Open the CS and SCCP signaling windows using
BSC Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. In “configuration management” page, right-click on
“cell A” tablet and select “create” “create frequency
hoping system”;
4. In pop-up “create frequency hoping system” window,
set the “frequency hoping Mode” is “RFID freqhop”;
5. In the “MA frequency list” add the 6 AFRCN
A1,A2,A3,A4,A5,A6;
6. repeat step 3-5 with cell B and cell C to create RF
hopping system with the same MA frequency list;
7. Right-click on “cell A” tablet and select “create”
“TRX”, In pop-up “create TRX” window select
“Support Fhs” as “RFID freqhop” in “TRX info” tablet;
8. Set the value of MAIO is 2 in “Channel info” tablet;
9. Repeat step 7-8 with cell B and cell C, and set the
value of MAIO is 4 and 6;
10. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
11. Block all TCH in BCCH TRX.
12. MS1 performs CS call and PS download in cell A;
13. MS2 performs CS call and PS download in cell B;
14. MS3 performs CS call and PS download in cell C;
Anticipative Result 1. Data synchronization operation successes;
2. MS1, MS2, MS3 could be established successfully
and the call is not drop and voice quality is good; MA
list could be observed in Imm_Assing_cmd and
Ass_cmd message.
3. MS1, MS2, MS3 could perform download in all cells.
MA bitmap could be observed in ‘packet Immediate
Assign Command’
4. message.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 75


Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.46 Synthesized Frequency Hopping


Test Item Synthesized Frequency Hopping
Test Networking

Precondition 1 check CN is healthy, see chapter Check Test Environment;


2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MS should be ready;
6 The cell has 3 carriers.
Test Steps 1 Create two frequency hopping systems, add 4 frequency
spots to “MA frequency list” in each hopping system;
2 Set HSN as default parameter 0;
3 Open TRX configuration page, set “Support Fhs” as “Yes” ;
one non-BCCH carriers is in system 1, the other one non-
BCCH carriers is in system 2;
4 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
5 Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
6 In “dynamic data management” page, block TCH channel of
the BCCH carrier;
7 In “dynamic data management” page, block TCH channel of
the carriers which belonging to the hopping system 2, make
a call in the carriers which belonging to the hopping system
1, observe the signaling trace message;
8 In “dynamic data management” page, unblock TCH channel
of the carriers which belonging to the hopping system 2,
block TCH channel of the carriers which belonging to the
hopping system 1, make a call in the carriers which
belonging to the hopping system 2, and observe the
signaling trace message.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 76


Anticipative 1 Data synchronization operation successes in step 4;
Result
2 Block and unblock channel operation successes in step 6、
7 and 8;
3 The call could be established and the voice is normal in
step 7 and 8;
4 In system message 1, “cell channel description” shows all
configured frequency spots of the cell;
5 Step 7: assignment command message shows “hopping
channel: RF hopping channel” and the map of used
frequency spot. From this map, it can conclude that the
used hopping frequency spots belong to the hopping
system 1;
6 Step 8: assignment command message shows “hopping
channel: RF hopping channel” and the map of used
frequency spot. From this map, it can conclude that the
used hopping frequency spots belong to the hopping
system 2.
Message Flow

Test Description

Test Result

Parameters Default parameters


Setting

4.47 Support of 64 Frequencies Hopping


Test Item Support of 64 Frequencies Hopping
Sub-Item Support of 64 Frequencies Hopping
Objectives To verify 64 RFID function
Test Networking

Precondition 1 check CN is healthy, see chapter Check Test Environment;


2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MS should be ready;
6 ensure good radio environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 77


Test Steps 1 Right click the site to create a cell;
2 Right click the cell to create a Frequency Hopping System,
set the FHS number as 1, set the hopping mode as “RFID
freqhop”, and set its HSN as default parameter 0.
3 Add 63 ARFCNs 5, 6, 7, 8, 9 …to MA list.
4 Right click the cell to create BCCH TRX with ARFCN 60;
5 Right click the cell to create 2 non-BCCH carriers with
FHS=1, and set their MAIO as 0 and 1 respectively;
6 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7 In “dynamic data management” page, block TCH channel of
the BCCH carrier;;
8 Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
9 Make a call, observe the signaling trace message.
10
Anticipative 1 Data synchronization operation successes in step 6;
Result
2 Block channel operation successes in step 7;
3 The call could be established and the voice is normal in
step 9;
4 In system message 1, “cell channel description” shows all
configured frequency spots of the cell;
5 Assignment command message shows “hopping channel:
RF hopping channel” and the map of used frequency spot.
From this map, it can conclude the number of the frequency
spots which participated in hopping is 63. The HSN and
MAIO number should be the same as the configured
parameters.
Message Flow

Test Description

Test Result

Parameters Default parameters


Setting

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 78


4.48 Baseband Frequency Hopping
Test Item Baseband Frequency Hopping
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. check default cell configuration and parameters in BSC;
5. MS should be ready;
6. The cell has 5 carriers.
Test Steps 1. Create two frequency hopping systems, add 4 frequency
spots to “MA frequency list” in each hopping system;
2. Set HSN as default parameter 0; Set MAIO of the two
carriers (which belonging to the same one hopping
system)as 0 and 1 respectively;
3. Open TRX configuration page, set “Support Fhs” as
“Yes” ; two non-BCCH carriers are in system 1, the other
two non-BCCH carriers are in system 2;
4. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
5. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
6. In “dynamic data management” page, block TCH channel
of the BCCH carrier;
7. In “dynamic data management” page, block TCH channel
of the carriers which belonging to the hopping system 2,
make a call in the carriers which belonging to the hopping
system 1, observe the signaling trace message;
8. In “dynamic data management” page, unblock TCH
channel of the carriers which belonging to the hopping
system 2, block TCH channel of the carriers which
belonging to the hopping system 1, make a call in the
carriers which belonging to the hopping system 2, and
observe the signaling trace message.
Anticipative 1. Data synchronization operation successes in step 4;
Result 2. Block and unblock channel operation successes in step
6、7 and 8;
3. The call could be established and the voice is normal in
step 7 and 8;
4. In system message 1, “cell channel description” shows all
configured frequency spots of the cell;
5. Step 7: assignment command message shows “hopping
channel: RF hopping channel” and the map of used
frequency spot. From this map, it can conclude that the
used hopping frequency spots belong to the hopping
system 1;
6. Step 8: assignment command message shows “hopping
channel: RF hopping channel” and the map of used
frequency spot. From this map, it can conclude that the
used hopping frequency spots belong to the hopping
system 2.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 79


Parameters Default parameters
Setting
Message Flow

Test Description

Test Result

4.49 Cell Selection


Test Item Cell selection
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. MSs are ready;
5. ensure good radio environment;
Test Steps 1. MS power on
2. MS select a cell to perform location update

Anticipative Result 1. MS can location update successfully


Test Description

Test Result

4.50 Cell Reselection


Test Item Cell reselection
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. MSs are ready;
5. ensure good radio environment;
Test Steps 1. Configure cell A as “Adjacent cell handover and
reselection” for Cell B.
2. MS register in cell B.
3. Move MS from cell B to cell A until reselection taking
place.
Anticipative Result 1. MS can reselect to cell A successfully.
Test Description

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 80


Test Result

4.51 Immediate TCH Assignment


Test Item Immediate TCH Assignment
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

Test Steps 1. Block all the SDCCH channels of the cell;


2. Switch on the ”FACCH Call Setup of Call Initiation”
function of the cell;
3. Close dynamic SDCCH function;
4. Make a voice call in the cell
Anticipative Result 1. The call established successfully by using FACCH
channel to setup the call;
2. “Mode modify command” can be found before
assigning TCH channel to the test MS in CS signaling
trace;
Test Description

Test Result

4.52 Call Re-establishment


Test Item Call Reestablishment
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 81


BSC;
5. MS are ready;
6. ensure good radio environment;
Test Steps 1. Open the CS and SCCP signaling windows using
BSC Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. In “configuration management” page, double-click the
“cell A” table to open the cell A property page ;
4. In “Option params” page set the “cell re-establish
allowed” as “YES”;
5. reduce the counter of link time out ,In “system
params” page set the “Radio link timeout on MS
side” as 4;
6. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7. MS makes a call in cell A.
8. far away the BTS, make the radio quality and level
drop, when the MS request another channel to re-
establish, go back to close to the BTS make the
receive quality normal;
Anticipative Result 1. Data synchronization operation successes;
2. The call could be established in step 7;
3. when the MS require call reestablish , the BSC
allocate another TCH for MS, the call reestablish
successfully;
4. in step 8, the “Establish Indication” message
including the “CM REESTABLISHMENT REQUEST”;
Test Description

Test Result

4.53 MS Access Control


Test Item MS Access control
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 82


Test Steps 1. Configure Cell with RACH control parameter ,set all 15
class MS not barred;
2. Observe the System Information, AC segment value
should be zero;
3. modify AC1~15, Observe the System Information
segment value changed correctly.
Anticipative Result 1. All MS not bared, the AC segment value is zero;
2. When Some MS class are modified to bar, the bits of
these MS AC value is set to 1 as the System Info
show by MS data sheet.

Test Description

Test Result

4.54 MAC Dynamic Allocation Mode


Test Item MAC Dynamic Allocation Mode
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MS is ready and supports 4+2 ;
6. ensure good radio environment;
7. MS registers successfully in cell;
8. Cell supports EGPRS;

Test Steps 1. Open the RLC/MAC signaling windows using BSC


Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Configure “4*16kbps” as “MCS9” in EDGE property of
Cell level;
4. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
5. Use MS to make ftp download and then ftp upload at

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 83


same time;
6. Recording download and upload speed.

Anticipative Result 1. Data synchronization operation successes.


2. MS makes FTP download & Upload at the same time
successfully;
3. Check the value of DOWNLINK TIMESLOT
ALLOCATION in message “Timeslot reconfigure” or
TIMESLOT ALLOCATION in message “downlink
Assignment “ that DOWNLINK TIMESLOT
ALLOCATION or TIMESLOT ALLOCATION be four
timeslots for MS under making ftp download;
4. Check the value of USF TN in message “Uplink
Assignment” or “Timeslot reconfigure ” that USF TN be
two timeslots for MS under making ftp upload
Test Description

Test Result

4.55 Static Channel Management


Test Item Static Channel Management
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. MSs are ready;
5. ensure good radio environment;
Test Steps 1. Configure at least one static TCH channel in the cell
2. Make a CS call
3. Configure at leat one static PDTCH channel in the cell
4. Make a PS call

Anticipative Result 1. For step 2, the CS call can be set up sucessfully


2. For step 4, the PS call can be set up sucessfully
Test Description

Test Result

4.56 Dynamic Channel Management


Test Item Dynamic Channel Management
Test Networking

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 84


Precondition 1. check CN is healthy;
2. check BSC is healthy;
3. check SDR is healthy;
4. MSs are ready;
5. ensure good radio environment;
Test Steps 1. Configure at least one dynamic TCH/F channel in the
cell
2. Block all static TCH channels and PDTCH channels in
the cell
3. Make a CS call and then hang up
4. Make a PS call
Anticipative Result 1. For step 3, the CS call can be set up sucessfully
2. For step 4, the PS call can be set up sucessfully
Test Description

Test Result

4.57 Idle Channel Measurement


Test Item Idle Channel Measurement
Test Networking

Precondition 1 Check CN is healthy, see chapter Check Test


Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 Check default cell configuration and parameters in
BSC;
5 MSs are ready;
6 Ensure good radio environment;
Test Steps 1 Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2 Double-click “cell” tablet to open cell property “system
parameter”, set “InterfAvgPrd” as “10”
3 Inspect and verify no any current alarms from OMC;
4 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
5 Observe there are at least three signal in Signal Trace
6 Left-click “cell” tablet to open cell property “system
parameter”, set “InterfAvgPrd” as “20”
7 Inspect and verify no any current alarms from OMC;
8 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
9 Observe there are at least six signal in Signal Trace

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 85


10 Left-click “cell” tablet to open cell property “system
parameter”, set “InterfAvgPrd” as “30”
11 Inspect and verify no any current alarms from OMC;
12 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
13 Observe there are at least nine signal in Signal Trace

Anticipative Result 1 The time of “RF indication ”from one to next in CS


signal is about 5 seconds in step 5
2 The time of “RF indication ”from one to next in CS
signal is about 10 seconds in step 9
3 The time of “RF indication ”from one to next in CS
signal is about 14.5 seconds in step 13
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.58 Enhancement on CS Channel Allocation


Test Item Enhancement on CS Channel Allocation
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. Check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. Ensure good radio environment;
7. MS1 with higher priority 2, MS2 with lower priority 7.
Test Steps 1. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Double-click “BSC” tablet to open BSC “channel
allocation control params” page and Set ‘PriThreshold’
lower than the MS’s priority..
4. In “channel allocation control params” page, set
“RsvChanFirst” as “yes” and EMLPPThs,%= 20 ,.
5. block some TCHs to make the load of the cell is

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 86


higher than the EMLPPThs;
6. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7. In the cell, use mobile phone 1 make a call and hold;
8. In “dynamic data management” page, inquire the
channels statement;
9. In the cell, use mobile phone 2 make a call and hold;
10. In “dynamic data management” page, inquire the
channels statement;
11. Repeat step 6-9 using “RsvChanFirst” as “No”
Anticipative Result 1. Data synchronization operation successes;
2. All call could be established and the voice is normal;
3. In step 6, one reserved channel is occupied;
4. In step 8, still one reserved channel is occupied to
verify MS2 did not use reserved channel.;
5. In step 10, MS 1 and MS2 use non-reserved channel,
always 0 reserved channel is occupied.

Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.59 Enhancement on PS Channel Allocation


Test Item nhancement on PS Channel Allocation
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;
3. check SDR is healthy;
4. check default cell configuration and parameters in
BSC;
5. One MS is ready;
6. ensure good radio environment;
Test Steps 1. Configure the cell with 2 TRXs;
2. Configure TRX 1 with 1 PDTCH channel, TRX 2 with
2 PDTCH channel;
3. Configure the priority of TRX 1 as 1 and the priority of
TRX 2 as 3;
4. MS performs PS service and check the used TS is on

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 87


which TRX;
5. Configure the priority of TRX 1 as 3 and the priority of
TRX 2 as 1;
6. MS performs PS service and check the used TS is on
which TRX;

Anticipative Result 1. At step 4, the MS should occupy the channel of TRX1;


2. At step 2, the MS should occupy the channel of TRX2.

Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.60 Initial Coding Scheme per Cell Settable


Test Item Initial Coding Scheme per Cell Settable
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. Cell supports EGPRS service;
6. MS are ready;
7. ensure good radio environment;
8. MS registers successfully in cell A and supports
EGPRS, in IDLE mode;

Test Steps 1. Open the RLC/MAC, LLC, PS, BSSGP signaling


windows using BSC Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Double-click “cell” tablet to open cell “EDGE
attribution” page, Set the initial EGPRS modulation
and coding scheme as MSC 6, “InitAttachExch_0”
as “YES” ;
4. Right-click “BSC managed element” tablet and select
“synchronize modified data”;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 88


5. MS performs FTP uploading in cell A, and moves MS
close to antenna.

Anticipative Result 1. Data synchronization operation successes in step 4,.


2. FTP uploading is complete successfully in step 5 in
DOS window.
3. “CHANNEL_CODING_COMMAND” in massage
“EGPRS UpLink Response” in RLCMAC signaling
trace is “MCS-6” in step 5.
4. MEAN_BEP in “EGPRS DownLink Ack/Nack”
message increased and coding method in massage
“EGPRS UpLink Response” change to higher coding
method MCS9 when MS move close to antenna.
5. MEAN_BEP in “EGPRS DownLink Ack/Nack”
message decreased and coding method in massage
“EGPRS UpLink Response” change to lower coding
method MCS1 when MS move far away antenna.

Test Description

Test Result

4.61 8/11 bit Access Burst

4.61.1 8 bit access burst


Test Item 8 bit access burst
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. cell support PS service;
8. Configure 8 bit access burst

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 89


Test Steps 1. Check the system configuration is 8-bit;
2. open RLC/MAC Signalling trace;
3. MS attach and activate PDP;

Anticipative Result 1. “System Information Type 13” includes


“ACCESS_BURST_TYPE : 8 bit access burst shall be
used” in CS signaling trace;
2. “Attach complete” in LLC signaling trace;
3. “Activate PDP context accept” in LLC signaling trace;
Test Description

Test Result

4.61.2 11 bit access burst


Test Item 11 bit access burst
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. cell support PS service;
8. Configure 11 bit access burst
Test Steps 1. Check the system configuration is 11-bit;
2. open RLC/MAC Signalling trace;
3. MS attach and activate PDP.

Anticipative Result 4. “System Information Type 13” includes


“ACCESS_BURST_TYPE : 11 bit access burst shall
be used” in CS signaling trace;
5. “Attach complete” in LLC signaling trace;
6. “Activate PDP context accept” in LLC signaling trace;

Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 90


4.62 Class A, B, C mobile stations(Optional)
Test Item Class A , B ,C mobile stations
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MS1 is class A, MS2 is class B, MS3 is class C;
6. Ensure good radio environment.
7. Cell support DTM function.
Test Steps 1. MSs register successfully in cell.
2. Open CS, A, GB signaling trace
3. MS1 make a voice call and then make a PS service
such as ping.
4. MS2 make a voice call and then make a PS service
such as ping
5. MS2 make a PS service such as ping and then make
a call to paging MS2
6. MS3 make a voice call.
Anticipative Result 1. At step 3: There is “ASSIGN COMPLETE” in SCCP
signaling trace, make PS service success and the call
do not drop
2. At step 4: There is “ASSIGN COMPLETE” in SCCP
signaling trace, make PS service unsuccess and the
call do not drop
3. At step 5: Make PS service success, but when the call
to paging MS2, there is “ASSIGN COMPLETE” in
SCCP signaling trace and PS service is interrupted.
4. At step 6: There is “ASSIGN COMPLETE” in SCCP
signaling trace.
Test Description
Test Result

4.63 One Phase Access


Test Item One phase access
Objectives Demonstration MS can use one phase access mode to
initiate packet service

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 91


Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. cell support PS service;
8. Configure BSS can use one phase access
Test Steps 1. configure cell supporting GPRS;
2. MS attach and activate PDP;
3. configure cell supporting EDGE;
4. MS attach and activate PDP.
Anticipative Result 1. MS can attach and active PDP by one phase access
mode.

Test Description

Test Result

4.64 Two Phase Access


Test Item Two phase access
Objectives Demonstration MS can use one phase access mode to
initiate packet service
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Configure BSS use two phase access

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 92


Test Steps 1. configure cell supporting GPRS;
2. MS attach and activate PDP;
3. configure cell supporting EDGE;
4. MS attach and activate PDP.

Anticipative Result 1. MS can attach and active PDP by two phase access
mode

Test Description

Test Result

4.65 Timeslot Multiplexing

4.65.1 Uplink timeslot multiplexing for EDGE and GPRS


Test Item Uplink timeslot multiplexing for EDGE and GPRS
Objectives To verify if the system support timeslot multiplexing for
EDGE and GPRS
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Cell supports EGPRS;

Test Steps 1. Open the RLC/MAC signaling windows using BSC


Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Configure one Ts as “PDTCH+PACCH+PTCCH” on
BCCH TRX;
4. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
5. In “dynamic data management” page, block all TCH

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 93


channel resources in cell.
6. Use 2 GPRS MSs to make ftp upload;
7. Repeat step 1 – step 6 by using EGPRS MS.
8. Repeat by using 1 x GPRS and 1 x EDGE MS at the
same time

Anticipative Result 1. Data synchronization operation successes.


2. Check the value of USF TN and USF in message
“Uplink Assignment” or “Timeslot reconfigure” that
USF TN be same and USF be different for two MSs
under making ftp upload.
Test Description

Test Result

4.65.2 Downlink timeslot multiplexing for EDGE and GPRS


Test Item Downlink timeslot multiplexing for EDGE and GPRS
Objectives To verify if the system support timeslot multiplexing for
EDGE and GPRS
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Cell supports EGPRS;

Test Steps 1. Open the RLC/MAC signaling windows using BSC


Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Configure one Ts as “PDTCH+PACCH+PTCCH” on
BCCH TRX;
4. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
5. In “dynamic data management” page, block all TCH
channel resources in cell.
6. Use 2 GPRS MSs to make ftp download;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 94


7. Repeat step 1 –step6 by using EGPRS MS.
8. Repeat FTP download by using 1 GPRS MS and 1
EDGE MS at the same time

Anticipative Result 1. Data synchronization operation successes.


2. Check the value of DOWNLINK TIMESLOT
ALLOCATION in message “Timeslot reconfigure” or
TIMESLOT ALLOCATION in message “downlink
Assignment “ that DOWNLINK TIMESLOT
ALLOCATION or TIMESLOT ALLOCATION be same
for two MSs under making ftp download.
Test Description

Test Result

4.66 GPRS Link Adaptation


Test Item GPRS link adaptation
Objectives To confirm that iBSC transmit the radio blocks to MS with
coding scheme determined by retransmission rate
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. cell support PS service;
8. FTP server is ready.
Test Steps 1. Configure Cell only support GPRS.
2. Configure the initial coding scheme of the cell as CS4
and configure the GPRS MAX coding scheme as CS4.
3. Set the “InitAttachExch_0” (GPRS phones init code
can be changed) as “Yes”.
4. Open the PS, RLC/MAC and LLC signaling windows
using BSC Signal Trace to record signaling;
5. MS attach and activate PDP.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 95


6. MS download a file.
7. Move the MS away from the antenna to make the
downlink quality not good.
8. Move the MS near the antenna again.

Anticipative Result 1. At step 7, the BSC should use lower coding scheme to
transmit data blocks when MS moving away from
antenna;
2. At step 8, the BSC should user higher coding scheme
to transmit data blocks when MS moving near
antenna;
Test Description

Test Result

4.67 Delayed TBF Release in DL


Test Item Delayed TBF Release in DL
Test Networking

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 cell support PS service;

Test Steps 1 Configure the DL Delay time as 1.5s;


2 Ping 32 BYTE for 1 time ;
3 Configure the DL Delay time as 3s;
4 Ping 32 BYTE 1 time;
5 Configure the DL Delay time as 4s;
6 Ping 32 BYTE 1 time.

Anticipative Result 1 The time from the first packet downlink ack to the last
packet downlink ack is about 1.5s in step 2;
2 The time from the first packet downlink ack to the last
packet downlink ack is about 3s in step 4;
3 The time from the first packet downlink ack to the last

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 96


packet downlink ack is about 4s in step 6.

Test Description

Test Result

4.68 Delayed TBF Release in UL


Test Item Delayed TBF Release in UL
Test Networking

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 cell support PS service;

Test Steps 1 Close the option of EXT_UL_TBF;


2 Configure the UL Delay time as 1.5s;
3 Ping 32 bytes to an unreachable address for one time,
and record the log of MS’s RLC/MAC signal;
4 Configure the UL Delay time as 3s;
5 Ping 32 bytes to an unreachable address for one time,
and record the log of MS’s RLC/MAC signaling trace;
6 Configure the UL Delay time as 4s;
7 Ping 32 bytes to an unreachable address for one time,
and record the log of MS’s RLC/MAC signaling trace;
Anticipative Result 1 The time from the packet uplink assignment to the
packet uplink response is about 1.5s in step 3;
2 The time from the packet uplink assignment to the
packet uplink response is about 3s in step 5;
3 The time from the packet uplink assignment to the
packet uplink response is about 4s in step 7.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 97


4.69 Downlink BVC Flow Control
Test Item BVC Flow Control (in DL)

Objectives To verify if the system could support BVC Flow Control

Test Networking

1. check CN is healthy, see chapter Check Test


Environment;
2. check SGSN is healthy, see chapter Check Test
Environment
3. check BSC is healthy, see chapter Check Test
Environment;
Precondition 4. check SDR is healthy, see chapter Check Test
Environment;
5. check default cell configuration and parameters in
BSC;
6. MS are ready;
7. ensure good radio environment;
8. MS registers successfully in cell, in IDLE mode;
1. Open the BSGP signaling windows using BSC Signal
Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. In “configuration management” page, double-click on
“BSC function1” to open “GPRS property1”;
4. Set “BVC flow control period” as “3000”
5. Open “BVC flow control” page, set “BVC flow control
supported” as “yes”, set “flow control mode” as “1”, set
“Parameter of flow control mode 1” as “1”, set “BVC
Test Steps flow control R MIN value as “80”, set “BVC flow control
threshold” as “80”;
6. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7. Make a PS call in cell;
8. Hold on the dial for 3 minutes.
9. Repeat step 3-8,but on step 5, set “flow control mode”
as “2” instead of “1” ,set “Parameter of flow control
mode 2” as “214” instead of setting “Parameter of flow
control mode 1”
1. Data synchronization operation successes in step 6.
2. BVC Flow Control can be triggered periodically in
Anticipative Result Signal Trace as set on OMC
3. Parameters in initial BVC Flow Control message are
the same as setting on OMC.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 98


Test Description

Test Result

4.70 Downlink MS Flow Control


Test Item MS Flow Control (in DL)

Objectives To verify if the system could support MS Flow Control

Test Networking

1. check CN is healthy, see chapter Check Test


Environment;
2. check SGSN is healthy, see chapter Check Test
Environment
3. check BSC is healthy, see chapter Check Test
Environment;
Precondition 4. check SDR is healthy, see chapter Check Test
Environment;
5. check default cell configuration and parameters in
BSC;
6. MS are ready;
7. ensure good radio environment;
8. MS registers successfully in cell, in IDLE mode;
1. Open the BSSGP signaling windows using BSC
Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. In “configuration management” page, double-click on
“BSC function1” to open “GPRS property1”;
4. Set “MS flow control period” as “3000”
Test Steps 5. Open “BVC flow control” page, set “MS flow control
supported” as “yes”, set “MS flow control R MIN value
as “80”, set “MS flow control threshold” as “80”;
6. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7. Make a PS call in cell;
8. Hold on the dial for 3 minutes.
1. Data synchronization operation successes in step 6.
2. MS Flow Control message can be triggered
Anticipative Result periodically in Signal Trace as set on OMC
3. Parameters in initial MS Flow Control message are the
same as setting on OMC.
Test Description

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 99


Test Result

4.71 EGPRS Packet Channel Request on CCCH


Test Item EGPRS Packet Channel Request on CCCH
Test Networking
Precondition 1 Check CN is healthy, see chapter Check Test
Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 A MS which supports EGPRS is ready;
5 Ensure good radio environment;
6 Cell supports EDGE service;
7 Cell doesn’t have PBCCH channel;
8 Cell supports EGPRS PACKET CHANNEL REQUEST.
Test Steps 1 Open the CS, PS, RLC/MAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2 In “configuration management” page, right-click “BSC
function” tablet;
3 In the pop-up menu, left-click “System control
parameter” button to open “System control parameter”
window;
4 In “Operation control parameters” tablet, set “Two
phase access” as “No”;
5 In “configuration management” page, double click on
“cell” tablet to open cell property page;
6 In “EDGE params” tablet, set “Support EGPRS packet
channel request access program(EgprsPacketChreq)”
as “Yes”;
7 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
8 MS performs PS attach in the cell;
9 Observe the BSC Signal Trace.
Anticipative Result 1 The value of
“EGPRS_PACKET_CHANNEL_REQUEST” field in
PSI13 in RLC\MAC signaling trace is “0”;
2 The MS will initiate packet service by “CCCH Uplink
EGPRS Packet Channel Request” message which can
be observed in PS signaling trace. Then the network

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 100
will return a “Package Immediate Assignment
Command” message containing an “EGPRS Packet
Uplink Assignment” structure to the MS;
3 “Resource Request” message can’t be observed in
RLC/MAC signaling trace;
4 “Attach accept” message can be found in LLC signaling
trace.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.72 EGPRS Activation per Cell


Test Item EGPRS Activation per cell
Test Networking As shown in the figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. cell A and cell B belong to the same site;
Test Steps 1. Open the PS、RLC/MAC and LLC signaling windows
using BSC Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Double-click “cell” tablet to open Cell A property;
4. In prop-up “Basic params 1” page , set “Support
GPRS (Ps Support)” as “NO”;
5. Double-click “cell” tablet to open Cell B property;
6. In prop-up “Basic params 1” page , set “Support
GPRS (Ps Support)” as “Support EDGE”;
7. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
8. MS C make a PS call in cell A;
9. MS D make a PS call in cell B;
10. repeat step 8-9 by config “Support GPRS (Ps
Support)” as “Support GPRS” in cell A.
Anticipative Result 1. Data synchronization operation successes in step 7;
2. MS C can’t do attach success in step 8;
3. MS D can do attach 、Activate PDP context and ping

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 101
test normal in step 9;
4. MS C、MSD can do attach 、Activate PDP context
and ping test normal in step 10;
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.73 Discontinuous Reception (DRX)


Test Item GPRS non-DRX mode
Objectives To test the functionality of GPRS non-DRX mode
Test Networking As shown figure 1
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. cell support PS service;
Test Steps 1. Configure the DrxTimeMax as 2s.
2. Besure DRX-TIMER_MAX<NON_DRX_TIMER
3. MS camp on the cell.
4. Block the cell.
5. Unblock the cell.
6. MS attach, PDP activate and ping.
7. MS deactivate and detach.
8. Configure the DrxTimeMax as 8s.
9. Besure DRX-TIMER_MAX>NON_DRX_TIMER
10. Repeat step 2-6
Anticipative Result 1. At step 5: DRX_TIMER_MAX is 2(2s) in PS13 in
RLC/MAC signaling trace.
2. At step 6: NON_DRX_TIMER is observed in LLC
signaling trace.
3. At step 7: Confirm the time which MS keeps in Non-
DRX mode is min(DRX_TIMER_MAX,
NON_DRX_TIMER).

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 102
4. At step 10: DRX_TIMER_MAX is 4(8s) in PS13 in
RLC/MAC signaling trace, and confirm the time which
MS keeps in Non-DRX mode.
5. The time of MS keeping in Non-DRX mode is different,
and the last test is longer than the first test.
Test Description The time which MS keeps in Non-DRX mode is decided by
min(DRX_TIMER_MAX, NON_DRX_TIMER), and it could
be observed from MS(Nokia).
Test Result

4.74 MAC Extended Dynamic Allocation


Test Item EGPRS Extended Dynamic Allocation
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Set Cell support EGPRS service;
8. ensure MS support extended uplink dynamic
allocation, such as Nokia 6120c;
Test Steps 1. Double-click “BSC” tablet to open BSC property
“GPRS property1” page, Set “Support extended uplink
dynamic allocation” as “YES”
2. Double-click “cell” tablet to open cell property “GPRS
other params” page, Set “Support extended uplink
dynamic allocation” as “YES”
3. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
4. Inspect and verify no any current alarms from OMC;
5. Open the CS, PS, RLCMAC, LLC, and BSSGP
signaling windows using BSC Signal Trace to record
signaling
6. MS attach and activate PDP context;
7. MS FTP upload file, for example, 1M Bytes;
Anticipative Result 1. When MS attach, activate PDP Context and FTP
upload, Resource Request message in RLCMAC
signaling include GPRS Extended Dynamic
Allocation Capability and EGPRS Extended Dynamic
Allocation Capability = 1;
2. After MS starting upload file, Timeslot Reconfigure

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 103
message in RLCMAC signaling including
EXTENDED_DYNAMIC_ALLOCATION means
current TBF of MS is Extended Dynamic Allocation;
3. MS FTP upload file successfully;
4. Data synchronization operation successes in step 3
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.75 Flexible Priority Handling of Packet Data


Channel

4.75.1 EDGE dedicated channel


Test Item EDGE dedicated channel
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure EDGE dedicated channels, block the other
channels;
2. Make a CS call;
3. GPRS MS attach;
4. EDGE MS attach.

Anticipative Result 1. CS call fails;


2. GPRS MS attach fails;
3. EDGE MS attach success.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 104
4.75.2 EDGE priority channel
Test Item EDGE priority channel
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. cell support PS service;
Test Steps 1. Configure EDGE priority channels and some common
static PDTCH channels;
2. GPRS MS attach, PDP activate and ping;
3. EGPRS MS attach, PDP activate and ping;
4. Configure EDGE priority channels, no common static
PDTCH channels;
5. GPRS MS attach, PDP activate and ping;
6. EGPRS MS attach, PDP activate and ping;
Anticipative Result 1. GPRS MS use the common PDTCH in step 2;
2. EGPRS MS use the EDGE priority channel in step 3;
3. GPRS MS can use the EDGE priority channel in step
5;
4. EGPRS MS use the EDGE priority channel in step 6;
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.75.3 GPRS priority channel


Test Item GPRS priority channel
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 105
5. MSs are ready;
6. ensure good radio environment;
7. cell support PS service;
Test Steps 1. Configure GPRS priority channels and some common
static PDTCH channels;
2. GPRS MS attach, PDP activate and ping;
3. EGPRS MS attach, PDP activate and ping;
4. Configure GPRS priority channels and no common
static PDTCH channels;
5. GPRS MS attach, PDP activate and ping;
6. EGPRS MS attach, PDP activate and ping.
Anticipative Result 1. GPRS MS use the GPRS priority channels in step 2;
2. EGPRS MS use the common PDTCH channels in
step 3;
3. GPRS MS use the GPRS priority channels in step 5;
4. EGPRS MS use the GPRS priority channels in step 6.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.75.4 Default channel


Test Item Default channel
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. cell support PS service;

Test Steps 1. Configure some common static PDTCH channels;


2. GPRS MS attach, PDP activate and ping;
3. EGPRS MS attach, PDP activate and ping;

Anticipative Result 1. GPRS MS use the common PDTCH channels in step


2;
2. EGPRS MS use the common PDTCH channels in

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 106
step 3;

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.76 GPRS and EGPRS Channels Allocated


Separately
Test Item GPRS and EGPRS Channels Allocated Separately

Test Networking

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 cell support EDGE/GPRS service;
Test Steps 1 In “Configuration Management” configure a “EDGE
exclusion” PDCH in “Channel info”;
2 In “dynamic data management” page, block other TCH
channels and reserve two TCH unblock in cell ,for
example reserve channel 2 and channel 3;
3 Right-click “BSC managed element” table and select
“synchronize modified data”;
4 Open the PS, RLC/MAC and LLC signaling windows
using BSC Signal Trace to record signaling;
5 GPRS MS connect to PC PDP activate;
6 GPRS MS performs uploading;
7 EGPRS MS connect to PC and PDP activate;
8 EGPRS MS performs uploading;
9 Block TS 3;

Anticipative Result 1 In step 5 GPRS MS occupied TS 3, “UpLink_Assign”


message contain the “USF_TN3” in RLC/MAC signaling
window;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 107
2 In step 8 EGPRS MS occupied TS 2, “UpLink_Assign”
message contain the “USF_TN2” in RLC/MAC signaling
window;
3 In step 9 GPRS MS cannot uploading ,EGPRS MS
uploading continue;

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.77 Multi Timeslot Supported in Extended Cell


Test Item Multi Timeslot Supported in Extended Cell
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Configure cell as extended cell and TRX type is
extended TRX.
Test Steps 1. Configure cell as extended cell and TRX type is
extended TRX.
2. In “GPRS other params 3” page of the cell, configure
the “Multislot allocation of extended range cell
support(Info1_7_13) as Yes;
3. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
4. Configure two PDTCH channels in the extended cell
5. MS PS attach, PDP activate and perform FTP
download
6. Check the number of timeslots used when FTP
download
Anticipative Result 1. For step 5, the MS can PS attach, PDP activate and
FTP download successfully;
2. For step 6, the number of downlink timeslots can reach
2.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 108
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.78 EGPRS Link Adaptation


Test Item EGPRS Link Adaptation
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. SAGEM is ready;
6. ensure good radio environment;
7. SAGEM registers successfully in cell;

Test Steps 1. Open the SAGEM signaling trace windows to record


signaling;
2. Open the RLC/MAC signaling windows using BSC
Signal Trace to record signaling;
3. Inspect and verify no any current alarms from OMC;
4. Cell supports EGPRS with antenna;
5. Configure “4*16kbps” as “MCS9” in EDGE property of
Cell level;
6. Configure “EGPRS phones init code can be
changed(InitAttachExch_1)” as “No”;
7. Configure “IrSupportUp” as “NO” in EDGE property of
Cell level;
8. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
9. Make other BCCH TRX(named TRXInrer ) with the
same frequency as an interference;
10. Use MS to make ftp upload and download near the
antenna and hold on;
11. Move MS nearly to TRXInter;
12. Repeat step4-step9 with configure “4*16kbps” as
“MCS8” and “MCS7” for two times again.

Anticipative Result 1. Data synchronization operation successes;


2. FTP upload and download work well;
3. Check the value of “RESEGMENT” in message
“Uplink Response” of RLC/MAC signaling, that could

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 109
be “Retransmitted RLC data blocks shall be re-
segmented according to commanded MCS”;
4. The re-tranmsit block shall be according to below
table.

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.79 Incremental Redundancy in UL


Test Item Incremental Redundancy in UL
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. Ensure good radio environment.
Test Steps 1. Open the RLC/MAC, LLC, PS, and BSSGP signaling
trace windows to record signaling;
2. In the cell parameter, configure “Support uplink LA+IR
quality control(IrSupportUp)” as “Yes” in “EDGE
params” page;
3. EGPRS MS attach and activate PDP;
4. MS performs FTP upload;
5. Add some uplink interference to make the uplink
quality to be bad;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 110
Anticipative Result 1. “RESEGMENT:Retransmitted RLC data blocks shall
not be re-segmented” can be found in “Uplink
Assignment” message in RLC/MAC signalling.
2. FTP uploads successfully.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.80 Extended uplink TBF mode

4.80.1 Extended uplink TBF mode


Test Item Extended UL TBF Mode
Test Networking

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 BSC is in default configuration;
5 MSs are ready;
6 ensure good radio environment;

Test Steps 1 Open the CS, PS, RLC/MAC, LLC, BSSGP signaling
windows using Signal Trace to record signalings;
2 Observe SI 13 in CS signal
3 Open BSC function, Set Support signal extended uplink
TBF = Yes in GPRS property 2;
4 Open Cell function, Set Cell support extendable uplink
TBF =YES in GPRS other params;
5 Open Cell function, and configure the Extend Uplink
TBF time as 1s in GPRS other params;
6 Ping 32 bytes to an unreachable address for one
packets, and observe RLC/MAC signal trace;
7 Open Cell function, and configure the Extend Uplink
TBF time as 2s in GPRS other params;;
8 Ping 32 bytes to an unreachable address for one
packets, and observe RLC/MAC signal trace;
9 Open Cell function, and configure the Extend Uplink

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 111
TBF time as 3s in GPRS other params;
10 Ping 32 bytes to an unreachable address for one
packets, and observe RLC/MAC signal trace;

Anticipative Result 1 NW_EXT_UTBF: The extended uplink TBF mode is


supported by the network can be found in System
Information 13 in CS signals
2 NW_EXT_UTBF: The extended uplink TBF mode is
supported by the network can be found in PSI 13 in
RLCMAC signals
3 The time from the first packet Uplink Response to the
last packet Uplink Response is about 1s in step 6;
4 The time from the first packet Uplink Response to the
last packet Uplink Response is about 2s in step 8;
5 The time from the first packet Uplink Response to the
last packet Uplink Response is about 3s in step 10;
Test Description

Test Result

4.80.2 Enhanced Extended uplink TBF mode


Test Item Enhanced Extended uplink TBF mode
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Set Cell support EGPRS service;
8. ensure MS support Enhanced extended uplink
dynamic allocation, such as Nokia E71;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 112
Test Steps 1. Open the CS, PS, RLC/MAC, LLC, BSSGP signaling
windows using Signal Trace to record signalings;
2. Observe SI 13 in CS signal
3. Open BSC function, Set Support signal extended
uplink TBF = Yes in GPRS property 2;
4. Open Cell function, Set Cell support extendable uplink
TBF =YES in GPRS other params;
5. Set no data during extended uplink TBF mode = YES;

Anticipative Result 1. When MS attach, activate PDP Context and ping test
PSI 13 in RLCMAC signaling including
EXT_UTBF_NO_DATA = 1
2. There is no Uplink Dummy Control Block message in
RLCMAC signaling when TBF is in Extended Uplink
TBF mode.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.81 Intelligent UL/DL timeslot adjustment


Test Item Intelligent UL/DL timeslot adjustment
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Cell support GPRS or EDGE.

Test Steps 1. Configure 4 static PDTCH channels in the cell;


2. MS PS attach and PDP activate;
3. MS performs FTP download test;
4. Check the number of used downlink timeslots and
number of used uplink timeslots;
5. MS performs FTP download test;
6. Check the number of downlink timeslots and number
of uplink timeslots;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 113
Anticipative Result 1. For step 3, the number of used downlink timeslots
should be more than the number of used uplink
timeslots;
2. For step 6, the number of used uplink timeslots
should be more than the number of used downlink
timeslots.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.82 Enhanced Multi-timeslot Support


Test Item Enhanced Multi-timeslot Support
Test Networking

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 The MS supporting High Multislot Capability(class 32) is
ready;
6 ensure good radio environment;
7 Cell A supports EGPRS;
Test Steps 1 Open LLC and RLC/MAC signaling windows using BSC
Signal Trace to record signaling;
2 Configure 5 PDTCH channels for cell A;
3 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
4 MS performs ping testing in cell A;
5 Observe signaling;
6 Observe the number of DL and UP in MS;
Anticipative Result 1. The signaling that MS support High Multislot Capability
(class 32) displays in Resource Request message in
RCL/MAC signaling.
Message Flow

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 114
Test Description

Test Result

Parameters Setting Default parameters

4.83 Enhanced Cell Reselection Procedure


Test Item Enhanced Cell Reselection Procedure
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

Test Steps 1. Two cells, Cell A and cell B, are configured as


neighboring cells for each other.
2. Configure the cell supporting EDGE
3. Open the LLC, PS, RLC/MAC signal trace to record
signaling.
4. Close the LLC transfer function for both cells.
5. MS performs FTP download in cell A.
6. During downloading, Move MS from cell A to cell B
until reselection. Record the time of downloading
interruption when reselection
7. Open the LLC transfer function for both cells.
8. MS performs FTP download in cell A.
9. During downloading, Move MS from cell A to cell B
until reselection. Record the time of downloading
interruption when reselection
10. Configure the cell supporting GPRS
11. Repeat step 3 to step 9
Anticipative Result 1. The time of downloading interruption when reselection
in step 9 should be less than that in step 6.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 115
4.84 IP SLA
Test Item IP SLA
Test Networking As shown in BSS IP Networking

Precondition 1. check CN is healthy


2. check BSC is healthy;
3. check SDR is healthy;
4. Check BSS IP network is healthy;
5. ensure good radio environment;

Test Steps 1. Open “Performance Management” on OMCR, create IP


SLA measurement task, set measure type as “IP PD
Statistic” and activate the task through “Measurement
task management”;
2. Select RPU module and execute instant test (set test
type as “BSC IP Road test”) through “Test
Management” on OMCR, select “Performance
Statistic” as report type and set “Detect Time” value for
0;
3. Open “Performance Management” on OMCR, select
“PD” from “Performance Data Query->Query Index ->
Object Type” , query “IP PD Statistic”;

Anticipative Result 1. The measurement task is created and activated


successfully;
2. The instant task is executed, the measurement data is
reported as performance statistics data;
3. The counters “Send PD Request, Receive PD Reply, PD
Packet Loss Rate, PD Packet statistics by watch time,
PD Packet Loss Rate by watch time, PD Packet Out of
Sequence, Receive PD Request, Send PD Reply, Max
Delay, Min Delay, Mean Delay, Max jitter, Min jitter,
Mean jitter, Jitter Sampling Times, delay Sampling
Times” can be queried;

Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.85 Abis Triggered FR/HR Adaptation


Test Item Abis Triggered FR/HR Adaptation
Test Networking

Precondition 1. check CN is healthy;


2. check BSC is healthy;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 116
3. check SDR is healthy;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. The site transmission is IPoE;
8. The busy channel of the cell doesn’t exceed the
configured half rate threshold;
9. Dynamic HR in enabled in the cell;
10. The CAC function is enabled in the cell;
11. The MS supports HR;
12. The user is not a eMLPP user.
13. Configure Abis with 5 timeslots with bandwidth
320kbps;
1. Configure Over booking bandwidth(%) as 100;
2. Configure Safe allocation floor limit as 75% and Safe
allocation upper limit 85%;
14. Configure Bandwidth restore limit as 70%;
Test Steps 1. Configure cell 2 as the neigbouring cell of cell 1. Cell 2
and cell 1 belongs different ABIS resource pools;
2. Configure the channel select strategy of cell 1 as full
rate first;
3. When the total traffic bandwidth of ABIS resource pool
which cell 2 is belonged is lower than Bandwidth
restore limit, make a voice call and check the channel
type;
4. When the total traffic bandwidth of ABIS resource pool
which cell 2 is belonged exceeds the Bandwidth
restore limit but lower than Safe allocation floor limit,
make a voice call and check the channel type;
5. Configure the channel select strategy of cell 1 as only
full rate;
6. When the total traffic bandwidth of ABIS resource pool
which cell 2 is belonged exceeds the Bandwidth
restore limit but lower than Safe allocation floor limit,
make a voice call and check the channel type;
7. Configure the channel select strategy of cell 1 as full
rate first;
8. Make a full rate voice call in cell 2;
9. When the total traffic bandwidth of ABIS resource pool
which cell 2 is belonged exceeds the Bandwidth
restore limit but lower than Safe allocation floor limit,
move the MS to make the call in cell 2 handover to
cell 1. Check the channel type.
Anticipative Result 1. For step 3, the channel type should be full rate;
2. For step 4, the channel type should be half rate;
3. For step 6, the channel type should be full rate;
4. For step 9, the channel type should be half rate after
handover.

Parameters Setting

Message Flow

Test Description

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 117
Test Result

4.86 Dynamic FR/HR Adjustment

4.86.1 AMR FR -> AMR HR due to traffic


Test Item AMR FR -> AMR HR due to traffic
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS and MSC support AMR codec
Test Steps 1. Configure “Preferred Speech version (full)” as “Full
Rate version 3” and Configure “Preferred Speech
version (half)” as “Half Rate version 3”in BSC Function
interface;
2. Configure ”Handover between FR/AMR FRand
HR/AMR HR support(FRThrHoSupport) ” as ”yes”;
3. Configure the ”The load of HO from AMR FR to AMR
HR(AmrFrHoLoadThr) ” as 20;
4. Configure cell supporting dynamic half rate;
5. Open the CS and SCCP signaling trace
6. Reserve 5 TCH/F channels and block other TCH
channels;
7. MS 1 makes a CS call in the cell;
8. MS 2 makes another CS call in the cell;
Anticipative Result 1. For step 7, AMR FR is used by MS 1;
2. For step 8, MS 1 will intra-cell handover. The AMR HR
will be used for MS 1. The handover cause is traffic in
“handover performed” message in SCCP signaling
trace.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 118
4.86.2 FR -> HR due to traffic
Test Item FR -> HR due to traffic
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure “Preferred Speech version (full)” as “Full
Rate version 1” and Configure “Preferred Speech
version (half)” as “Half Rate version 1”in BSC Function
interface;
2. Configure ”Handover between FR/AMR FRand
HR/AMR HR support(FRThrHoSupport) ” as ”yes”;
3. Configure the ”The load of HO from FR to
HR(FrHoLoadThr) ” as 20;
4. Configure cell supporting dynamic half rate;
5. Open the CS and SCCP signaling trace
6. Reserve 5 TCH/F channels and block other TCH
channels;
7. MS 1 makes a CS call in the cell;
8. MS 2 makes another CS call in the cell;
Anticipative Result 1. For step 7, FR is used by MS 1;
2. For step 8, MS 1 will intra-cell handover. The HR will be
used for MS 1. The handover cause is traffic in
“handover performed” message in SCCP signaling
trace.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.87 Monitoring Um Interface


Test Item Monitoring Um Interface
Objectives Verify that BSC could handle radio link monitoring..
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 119
BSC;
5. MSs are ready;
6. ensure good radio environment;

Test Steps 1. Open the SCCP and CS signal trace


2. MS makes a call.
3. Moves far away from cell to reduce the downlink level
until call drops.
Anticipative Result 1. The call could be established successfully in step 2.
2. “Connection failure” could be observed in CS signaling
trace when call dropped.
Test Description
Test Result

4.88 Abis Interface Monitoring


Test Item Abis Interface Monitoring
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment.
Test Steps 1. Disconnect cables between BSC and SDR;
2. Observe the alarm;
3. Query the BTS state in “BTS Dynamic data
management->Site equipment Management->Abis
Device Management”;
Anticipative Result 1. There are corresponding alarms in step 2;
2. The “Abis device state” should be “abnormal,unblock”
at step 3.
Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 120
4.89 Performance Data Measurement
Test Item Performance Data Measurement
Test Target To verify all kinds of performance measurement data can
be collected correctly
Test Networking As shown figure 1

Precondition 1. iBSC is healthy, see chapter Check Test Environment;


2. OMC works normally;
3. the communication between iBSC and OMC is
normal;
4. Log on OMC;
5. Enter Performance Management Interface
Test Steps 1. Click [Performance Management-> Measurement
Task Management] and then the [measurement task
management] window opens
2. Click [Create measurement task] button on the toolbar
and then [Create task: Measurement Task] dialog box
pops up
3. Set basic task information, such as task name and
collection granularity
measure type:TCHFMeasurement
Collection granularity:15 Minutes
4. set task measure object;
5. Click [OK] to create a measurement task;
6. Repeat step 1 – step 5 to create measurement tasks
of following type:
TRXMeasurement
DownlinkDataTBFMeasurement
UplinkDataTBFMeasurement
DataFlowMeasurement
CPUMEMMeasurement
SCTPASMeasurement
BTSTRXMeasurement
AdjacentCellHandoverMeasurement
NSVConIPGBHOSTMeasurement
7. Repeat step 1 – step 5 to create measurement tasks
of following type(set Collection granularity as 30
Minutes):
ABISMessageCountMeas
GBMessageonIPGBHOSTMeasurement
NSEonIPGBHOSTMeasurement
BSSMAPMessageMeasurement
TerrestrialResourceAvailableMeasurement

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 121
AterMessagesMeasurement
RMMCallDropMeasurement
RadioResourceAvailableMeasurement
GeneralHandoverMeasurement
8. Repeat step 1 – step 5 to create measurement tasks
of following type(set Collection granularity as 1 Hour):
RadioAccessMeasurement
RadioMeasurement
SubCellStatistic
TSMeasurement
MSTAMeasurement
SAPI3Measurement
UpdownPACCHStatistic
DownlinkGPRSDataTBFStatistic
DownlinkEGPRSDataTBFStatistic
9. Repeat step 1 – step 5 to create measurement tasks
of following type(set Collection granularity as 24
Hours):
UpdownRLCStatistic
PSResourceUsedStatistic
RMMAssignmentMeasurement
HandoverCauseMeasurement
SDCCHMeasurement
TCH/HMeasurement
UplinkEGPRSDataTBFStatistic
BSSGPFlowStatistic
UplinkGPRSDataTBFStatistica
10. Check the measurement table of all kinds of
measurement type after the measurement time is
expired:
1) Click [Performance Management-> Performance
Data Query-by Task] and then the [Query by task
condition] window opens;
2) Select correct Ne location and then select the
task you want to query data
3) Select correct begin time and end time, then in
[Measure Object/Counter] tab page of the query
condition dialog, choose objects and counters
4) Click [OK] button on the condition dialog.

Anticipative Result 1. Measurement tasks can be created successfully;


2. Performance data can be collected and displayed
successfully
3. The date, time, measurement object are correct for all

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 122
PM tables

Test Description

Test Result

4.90 BSC Monitor Functions


Test Item BSC Monitor Functions
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

Test Steps 1. Query the status of cells in dynamic management


2. Query the status of channels in dynamic management
3. Plug out a SDTB board
4. Check the alarm and query the satus of BTSs
connected to BSC through the SDTB board which was
pluged out in step 3
5. Plug out a active CMP board
6. Check the alarm;
7. Check whether the active state is switched to its
backup board or not in dynamic management
8. Make a call in the BTS configured on the CMP board
Anticipative Result 1. For step 2, there should be some corresponding
alarms in OMC. The status of BTSs connected to BSC
through the SDTB board should be blocked.
2. For step 6, there should be some corresponding
alarms in OMC.
3. For step 7, the active state should be switched to its
backup board.
4. For step 8, the call can be set up successfully.
Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 123
4.91 BTS Software Loading
Test Item BTS Software Loading
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check and record default cell configuration and
parameters in BSC;
5. MS should be ready;
6. ensure good radio environment;

Test Steps 1. Warehousing the new BTS software version from local
PC to OMC;

2. Download the new version files from OMC to BTS,


make a call at the same time.
3. Activate the new software version through OMC
4. After activation, query the running version in BTS
5. Make a call
Anticipative Result 1. For step 2, the download success. The call be setup
successfully during downloading.
2. For step 3, new software version is activated
successfully.
3. For step 4, the running version in BTS should be the
new version.
4. For step 5, the call can be set up successfully.
Test Description

Test Result

4.92 Cell Traffic Statistics


Test Item Cell traffic statistics
Test Objective To verify function of cell traffic statistics
Test Networking As shown figure 1

Precondition 1. iBSC is healthy, see chapter Check Test Environment;


2. OMC works normally;
3. the communication between iBSC and OMC is normal;
4. check SDR is healthy, see chapter Check Test Environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 124
Test Steps SDDCH Availability test:
1. Configure 4 SDCCHs in normal state for testing cell;
2. Block one SDCCH;
3. Block all SDCCHs;
SDCCH Congestion Rate test:
4. Unblock all SDCCHs and configure only one SDCCH for
the cell;
5. Block the SDCCH and make a CS call in the cell ;
TCH Availability test
6. Configure a few TCHs in normal state,
7. Block one or several TCHs
Handover Success Rate test
8. Configure co-frequency neighboring cells, and use a mobile
phone to carry out service. Adjust signal to originate
handover, and conduct handover several times.
Anticipative Result 1. After step 2, check whether SDCCH Availability is 75%
upon arrival of the granularity;
2. After step 3, check whether SDCCH Availability is 0 upon
arrival of the granularity;
3. After step 5,check whether SDCCH Congestion Rate is
100%;
4. After step 7 ,check whether TCH Availability meets the
availability formula upon arrival of the granularity.
5. After step 8,check whether the handover success rate meets
the formula;
Test Description

Test Result

4.93 BSC Diagnostic Tests

4.93.1 Test Management


Test Item Test Management
Test Target The purpose of this test case is to verify the functionality of test
management
Test Networking

Precondition 1. RAN and core network work normally


2. The link between OMC and NE is normal
3. OMC works normally
4. Log on OMC

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 125
5. Enter Test Management Interface
Test Steps 1. Click [Test Management -> Start Instant Test] from the
menu and [Device Test] winodw pops up
2. Select Test Device, Test Type and other parameters. Click
[OK] button.
3. The test result will be displayed in [Test Result] window
Anticipative Result Test management can work normally and rhe result is correctly

Test Description

Test Result

4.93.2 BSC board test


Test Item BSC board test

Test Networking As shown figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check and record default cell configuration and
parameters in BSC;
5. MS should be ready;
6. ensure good radio environment;
Test Steps 1. In the menu ”View”, click ”Test Management” to enter BSC
diagnostic module;
2. Click the BSC Rack, select the CPU of a board, for
example, the CPU 1 of OMP board.
3. Right click the CPU and select ”Excute Instant Test”;
4. On the pop-up window, select the ”Test Type” as BSC Board
Test;
5. Click OK and wait the return test result.
Anticipative Result 1. For step 5, the return test result can show the right
hardware status.
Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 126
4.93.3 BSC Version Information test
Test Item BSC Version Information test
Test Networking As shown figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check and record default cell configuration and
parameters in BSC;
5. MS should be ready;
6. ensure good radio environment;
Test Steps 1. In the menu ”View”, click ”Test Management” to enter
BSC diagnostic module;
2. Click the BSC Rack, select the CPU of a board, for
example, the CPU 1 of OMP board.
3. Right click the CPU and select ”Excute Instant Test”;
4. On the pop-up window, select the ”Test Type” as BSC
BoardVersion Test;
5. Click OK and wait the return test result.
Anticipative Result 1. For step 5, the test result can return the right software
information of the board.
Test Description

Test Result

4.94 BSC LMT


Test Item BSC LMT
Test Target To verify function of BSC LMT
Test Networking As shown figure 1

Precondition 1. iBSC is healthy, see chapter Check Test Environment;


2. BSC LMT works normally;
3. the communication between iBSC and LMT is normal;
Test Steps 1. Startup LMT client and login LMT server with the valid
account
2. Click [View]->[Configuration Management] to enter
into configuration management and operate config
data such as modify/add/delete BSC
function/site/cell/trx;
3. Click [View]->[Performance Management] to enter into
performance management and makes some
operations such as pm data query;
4. Click [View]->[Fault Management] to enter into fault
management and makes some operations such as
current alarms query/history alarms query;
Anticipative Result 1. Login LMT server successfully;
2. Configuration operations can be executed
successfully;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 127
3. Performance operations can be executed
successfully;
4. Fault operations can be executed successfully;
Test Description

Test Result

4.95 Service Based QoS


Test Item Service Based Qos
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. Open BSC EDGE Property and set PFCSupport to
yes;
Test Steps 1. Open the BSSGP, RLCMAC and LLC signaling
windows using BSC Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. IMSI 1 subscribe to interactive service with THP = 1,
IMSI 2 subscribe to interactive service with THP = 2
4. MS1 activate PDP context and MS1 ftp download test;
5. MS 2 activate PDP context and MS2 ftp download
test;
6. Change test subscribe Qos profile, IMSI 1 subscribe
to conversational service with Transfer delay =1, IMSI
2 subscribe to conversational service with Transfer
delay = 63
7. MS1 activate PDP context and MS1 ftp download test;
8. MS 2 activate PDP context and MS2 ftp download
test;

Anticipative Result 1. For step 4 and 5, in LLC Signal trace PDP context
Accept can be found;
2. For step 4 and 5, in BSSGP Signal trace, Create BSS
PFC and Create BSS PFC Ack can be found;
3. For step 4 and 5, QoS profile of THP = 1/2 can be
found in ‘Create BSS PFC’ message;
4. For step 4 and 5, download rate of MS2 > MS1;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 128
5. For step 7 and 8, in LLC Signal trace PDP context
Accept can be found;
6. For step 7 and 8, in BSSGP Signal trace, Create BSS
PFC and Create BSS PFC Ack can be found;
7. For step 4 and 5, QoS profile of Transfer delay = 1/63
can be found in ‘Create BSS PFC’ message;
8. For step 7 and 8, download rate of MS1 < MS2;

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.96 Streaming Service Policies


Test Item Streaming Service Policies
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. configure QoS profile of 100kbit/s GBR for user in
SGSN;
8. Open BSC EDGE Property and set PFCSupport to
yes;
9. Configure 2 static PDTCHs in cell;

Test Steps 1. Open the BSSGP, RLCMAC and LLC signaling


windows using BSC Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Double-click “cell” tablet to open cell “EDGE
attribution” page, Set initial MCS as “MCS9”,
“InitAttachExch_0” as “No” ;
4. MS1 activate PDP context and MS1 ftp download test;
5. MS 2 activate PDP context and MS2 ftp download
test;

Anticipative Result 1. For step 4, in LLC Signal trace PDP context Accept of
MS1 can be found;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 129
2. In BSSGP Signal trace, ‘Create BSS PFC’ and
‘Create BSS PFC Ack’ of MS1 can be found;
3. QoS profile of 100kbit/s GBR can be found in ‘Create
BSS PFC’ message;
4. MS1 perform download successful.
5. For step 5, in LLC Signal trace PDP context Accept of
MS2 can be found;
6. In BSSGP Signal trace, ‘Create BSS PFC’ and
‘Create BSS PFC Ack’ of MS2 can be found;
7. QoS profile of 100kbit/s GBR can be found in Create
BSS PFC message;
8. MS2 connect ftp server failure

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.97 eMLPP

4.97.1 Force release of CS service


Test Item Force release of CS service
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. ensure good radio environment;
6. The test MS has been registered on HLR: MS1 with
higher priority (PCI=1)., MS2 with lower priority (PVI=1);
7. MSC supports emlpp.
Test Steps 1. Set cell property supporting preemption
(’preemptionind_0= yes’);
2. MS2 make a call and block other channel which are not
used;
3. MS1 make a call;
4. Repeat Step 2 and 3 without blocking other channels
Anticipative Result 1. At step3, the second call could be established by
preempting channel which MS2 occupied.
2. At step3, “Clear Request” with “Cause: Preemption” can

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 130
be found in SCCP signalling.
3. At step4, MS1 call established without preempting MS2

Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.97.2 Force handover of CS services


Test Item Force handover of CS services
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. ensure good radio environment;
6. The test MS has been registered on HLR: MS1 with
higher priority (PCI=1 and QA=1)., MS2 with lower
priority (PVI=1);
7. MSC supports emlpp;
8. Configure cell with adjacent cell.
Test Steps 1. Set cell property supporting queue, force handover
(’Queueind_0= yes’ and ‘ForceHoInd=0’);
2. MS2 make a call and block other channel which are not
used
3. MS1 make a call.

Anticipative Result 1. At step 3, “Queuing Indication” can be found in SCCP


signalling trace;
2. At step 3, MS2 will be forcedly handovered to adjacent
cell; “Handover Required” with “Cause: Preemption”
can be found in SCCP signalling.
3. At step 3, MS1 call successfully by occupied the
channel which MS2 occupied before. “Assignment
Completed” can be found in SCCP signalling.

Message Flow
Test Description
Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 131
4.98 Inter-BSC NACC (Optional)
Test Item Inter BSC NACC
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. configure two cell belong to different BSC;
8. configure the two BTS as neighbor cell;
Test Steps 1. Configure BSC do not support NACC by setting
‘NACCsupport’ =’not support NACC’
2. Configure the 2G cell parameter ‘NETWORK
CONTROL ORDER’ =NC0.
3. MS power on and select cell A as serve cell
4. MS attach, PDP activate and ping.
5. Attenuate the RX power lever of serving cell, till cell
reselect
6. Configure BSC support NACC by setting
‘NACCsupport’ =’support NACC, and LLC frame
transfer’
7. Cell support NACC by setting ‘CCNActive’ = ‘yes’;
8. Configure neighbor cell support CCN mode by setting
‘CCNsupport’ = ’yes’ ;
9. Repeat step 3 to step 5.
Anticipative Result 1. ‘Packet Cell Change Notification’ could be observed
sent from MS to BSC;
2. ‘Packet Neighbor Cell Data’ could be observed sent
from BSC to MS.
3. ‘Packet Cell Change Continue’ could be observed
sent from BSC to MS.
4. The interval time of cell reselection is shortened when
NACC used.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 132
4.99 Automatic BCCH Recovery
Test Item Automatic BCCH Recovery
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MS is ready;
6. ensure good radio environment;
7. Cell include two RRU, one RRU has 2 TRXs at least,
the other one has 2 TRXs too.

Test Steps 1. Open CS and SCCP signaling windows using BSC


Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Configure “CcchConf” as “Ccch use one physical
channel,combile with SDCCH” in Basic Param1 of
Cell level;
4. Configure “CanBcchExch” as “Yes” in “service
process additional params” tablet of Cell Level;
5. Right-click “BSC managed element” tablet and select
“Set System Control Parameter”;
6. Configure “CanBCCHEx” as “Yes” in “Handover
Parameters of BCCH” tablet;
7. Configure “CanBCCHEx” as “Yes” in “Service Process
Additional Params” tablet of Cell Property;
8. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
9. Power off RRU with BCCH TRX;
10. In “dynamic data management” page, inquire the
BCCH TRX statement;
11. Make a CS call;

Anticipative Result 1. Data synchronization operation successes;


2. “BCCH Change Over” could be observed in OAM
signal trace;
3. After BCCH handover, BCCH TRX statement is
unblock;
4. Cs call is normal;
5. Check SDCCH, ARFCN, TRX priority and BCCH TRX
parameter being same as before.
Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 133
4.100 Interference Rejection Combining (IRC)
Test Item IRC
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Configure a cell supporting diversity receiving.
2. Switch off the IRC function of the cell.
3. Query the performance index uplink receive quality (at
least one day)
4. Switch on the IRC function of the cell.
5. Query the performance index uplink receive quality (at
least one day)
Anticipative Result 1. The uplink receive quality in step 5 should be better
than that in step 3.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.101 Co-BCCH

4.101.1 Channel Allocation based on Dual-band Subcell


Test Item Channel Allocation based on Dual-band Subcell
Test Networking

Precondition 1 Check CN is healthy, see chapter Check Test


Environment;
2 Check BSC is healthy, see chapter Check Test
Environment;
3 Check SDR is healthy, see chapter Check Test
Environment;
4 Check default cell configuration and parameters in
BSC;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 134
5 MSs are ready;
6 Ensure good radio environment;
Test Steps 1 Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2 Inspect and verify no any current alarms from OMC;
3 Double-click “cell” tablet to open cell property page;
4 In “Basic params 1” tablet, set “Subcell used” as “yes”,
set “Frequency band” as “GSM900” , set “Frequency
band of Subcell” as “DCS1800”;
5 Double-click “trx1” tablet to open trx property page;
6 In “TRX Info” table, set “Subcell ID” and “First subcell”
7 Double-click “trx2” tablet to open trx property page;
8 In “TRX Info” table, set “Subcell ID” and “Second
subcell”
9 Double-click “Handover control1” tablet to open
Handover control page;
10 In “Subcell params” tablet, set “The MIN of path loss” as
“150”;
11 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
12 In the cell, use mobile phone, which support Dual-band
to make a call and hold;
13 Repeat step 12 with setting “The MIN of path loss”=’80’;
Anticipative Result 1 Data synchronization operation successes;
2 All call could be established and the voice is normal;
3 In step 12, mobile phone occupied the channel in the
second subcell;
4 In step 13, mobile phone occupied the channel in the
first subcell;
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.101.2 Subcell HO - Passloss&TA


Test Item Subcell HO - Passloss&TA
Sub-Item Handover base on Concentric Circle—when PathLoss and
TA are smaller or bigger

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 135
Objectives To verify if the system support Handover base on
PathLoss and TA
Test Networking

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 ensure cell A support subcell with TRX1 belong to
subcell 1 and TRX2 belong to subcell 2
Test Steps 1 Double-click “handover control” tablet to open handover
control property “handover control” page, set “Allow
standover PBGT handover” as “NO”
2 Double-click “handover control” tablet to open handover
control property “subcell params” page, set “Subcell
handover algorithm” as “Handover based on path loss
and TA”
3 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
4 Inspect and verify no any current alarms from OMC;
5 Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
6 In “dynamic data management” page, block TRX2 in
“TRX management”
7 MS make a voice call far away from the antenna of cell
A and hold on
8 In “dynamic data management” page, unblock TRX2 in
“TRX management”
9 Go near to the antenna of cell A and call end.
Anticipative Result 1 Handover performed signal in SCCP can be found in
step 9
2 The value of “cause” in message “Handover performed
” in SCCP signaling trace is “Better cell” in step 9
3 Block and unblock channel operation successes in step
6 and step 8
4 Data synchronization operation successes in step 3
Message Flow

Test Description

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 136
Test Result

Parameters Setting Default parameters

4.101.3 Subcell HO - C/I


Test Item Subcell HO - C/I
Sub-Item Handover base on Concentric Circle—when C/I good
enough or bad enough
Objectives Concentric Circle Technology
Test Networking
Precondition 1 check CN is healthy, see chapter Check Test
Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 ensure cell A support subcell with TRX1 belong to
subcell 1 and TRX2 belong to subcell 2
Test Steps 1 Double-click “handover control” tablet to open handover
control property “handover control” page, set “Allow
standover PBGT handover” as “NO”
2 Double-click “handover control” tablet to open handover
control property “subcell params” page, set “Subcell
handover algorithm” as “Concentric handover”
3 Double-click “handover control” tablet to open handover
control property “Handover level” page, set “Good C/I”
as 170 and “Bad C/I” as 160
4 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
5 Inspect and verify no any current alarms from OMC;
6 Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
7 In “dynamic data management” page, block TS2 to TS7
of TRX1 in “TRX management”
8 MS make a voice call near the BTS
9 MS go far away from BTS.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 137
10 In “dynamic data management” page, unblock TS2 to
TS7 of TRX1 in “TRX management”
11 Observe the value of “cause” in message “Handover
performed” in SCPP signaling trace
12 Call end.
Anticipative Result 1 Handover performed signal in SCCP can be found in
step 11
2 The value of “cause” in message “Handover performed
” in SCCP signaling trace is “Better cell” in step 11
3 Block and unblock channel operation successes in step
7 and step 10
4 Data synchronization operation successes in step 4
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.102 AMR Radio Link Timers


Test Item AMR Radio Link Timers
Sub-Item
Objectives To verify AMR Radio Link Timers
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready ,support AMR codec;
6. ensure good radio environment;
Test Steps 1. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2. Configure “Preferred Speech version (full)” as “Full
Rate version 3” in BSC Property interface.
3. Configure “Channel Select priority” as “Only Full Rate
Allowed” in Cell Property interface.
4. Configure “Bss Radio Link Timer’s Max Value for AMR

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 138
FR Bug” as “32” in “basic params 2” page of cell level;
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. Make a call, then hold on;
7. Unplug mobile battery
8. Repeat with “Bss Radio Link Timer’s Max Value for
AMR FR Bug” as “4
Anticipative Result 1. “Connection Failure” is observed in CS signaling trace
after unplug mobile battery;
2. after 32 “Measurement Result” with only Uplink
measurement and RXLEV/RXQUAL being ugly before
“Connection Failure” message.
3. After 4 “Measurement Result” with only Uplink
measurement and RXLEV/RXQUAL being ugly before
“Connection Failure” message
Test Description

Test Result

4.103 TCH Migration to BCCH TRX


Test Item TCH Migration to BCCH TRX
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MS is ready;
6. ensure good radio environment;
7. Cell include two RRU, one RRU has 2 TRXs at least,
the other one has 2 TRXs too

Test Steps 1. Open CS and SCCP signaling windows using BSC


Signal Trace to record signaling;
2. Inspect and verify no any current alarms from OMC;
3. Configure “CcchConf” as “Ccch use one physical
channel, combile with SDCCH” in Basic Param1 of
Cell level;
4. Configure “CanBcchExch” as “Yes” in “service
process additional params” tablet of Cell Level;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 139
5. Right-click “BSC managed element” tablet and select
“Set module params”;
6. Configure “BCCH HO” as “Yes” in “BCCH and SD HO
Params” tablet;
7. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
8. Power off RRU with BCCH TRX;
9. In “dynamic data management” page, inquire the
BCCH TRX statement;
10. Make a CS call;
11. Make a PS ping test;

Anticipative Result 1. Data synchronization operation successes;


2. After BCCH handover, BCCH TRX statement is
unblock;
3. Cs call is normal;
4. PS Ping test is normal.
5. Check SDCCH, ARFCN, TRX priority and BCCH TRX
parameter being same as before.
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.104 Load Dependent Intelligent TRX Shutdown


Test Item Load Dependent Intelligent TRX Shutdown
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

Test Steps 1. Enable intelligent function switch from IOMCR;


2. Configure the intelligent TRX shutdown execution
time includes the current time.
3. Configure the threshold for intelligent TRX shutdown
as 20%
4. Make a voice call on non-BCCH TRX and hold on

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 140
until measurement granularity is reached.
5. Check if non-BCCH TRX could be shutdown correctly.
6. Check if the call could be handover to other TRX.

Anticipative Result 1. Non-BCCH TRX could be shutdown correctly;


2. The call could be handover to other TRX and the
voice keep normal;

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.105 Intelligent TRX Shutdown Triggered by Main


Power Failure (Optional)
Test Item Intelligent TRX Shutdown Triggered by Main Power Failure
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
7. The site has main power supply and auxiliary power
supply such as battery at the same time
Test Steps 1. Set the parameter MasterPwCtrlOp as 1 in system
control parameter to switch on the intelligent TRX
shutdown triggered by main power failure function of
the BSC;
2. Set the parameter BtsMasterPwCtrlOp as 1 in site
config to switch on the intelligent TRX shutdown
triggered by main power failure function of the BTS;
3. Configure the cell with 3 TRXs. One is BCCH TRX and
two are non-BCCH TRXs.
4. Configure the TrxOffPercent as 50%;
5. Configure the MasterPwrOffTime as 5 minutes;
6. Configure the TrxOffTime as 0 minutes;
7. Switch off the main power supply to make the BTS to
use auxiliary power supply. Make sure that the
corresponding alarm for main power off is generated.
8. Wait the MasterPwrOffTime timer expire, check the

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 141
status of TRXs;
9. Wait the TrxOffTime timer expire, check the status of
TRXs;
Anticipative Result 1. For step 8, TrxOffPercent TRXs in all non-BCCH TRXs
are shutdown when MasterPwrOffTime expired;
2. For step 9, all non-BCCH TRXs are shutdown when
TrxOffTime expired.
Message Flow
Test Description
Test Result

Parameters Setting Default parameters

4.106 Multi-layer Cell Structure

4.106.1 Basic Micro cell creation


Test Item Basic Micro cell creation
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

Test Steps 1. Inspect and verify no any current alarms from OMC;
2. In “configuration management” page, right-click on
“Site” tablet to create “cell”.
3. In pop-up “Create Cell” window, select the “CellType”
as “Micro cell” and select the “PsSupport” as “Support
EDGE”.
4. In “configuration management” page, right-click on the
new “cell” tablet to create “Trx”.
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. Open the CS, SCCP the RLC/MAC, LLC, BSSGP
and PS signaling windows using BSC Signal Trace to
record signaling;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 142
7. MS powers on and registers successfully in the Micro
cell;
8. MS makes a call in the Micro cell. The call could be
established successfully and the voice is normal.
9. MS attach and PDP activate successes.
10. MS performs ping testing, FTP downloading and
uploading in the Micro cell.

Anticipative Result 1. The new Micro cell is created successes.


2. Data synchronization operation successes.
3. “Assignment complete” message sent from BSC to
MSC could be observed in SCCP signaling trace.
4. “Attach complete” message sent from BSC to SGSN
could be observed in LLC signaling trace
5. “Activate PDP context accept” message sent from
BSC to SGSN could be observed in LLC signaling
trace
6. Ping test, FTP download and upload is success
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.106.2 Basic Macro cell creation


Test Item Basic Macro cell creation
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 143
Test Steps 1. Inspect and verify no any current alarms from OMC;
2. In “configuration management” page, right-click on
“Site” tablet to create “cell”.
3. In pop-up “Create Cell” window, select the “CellType”
as “Macro cell” and select the “PsSupport” as
“Support EDGE”.
4. In “configuration management” page, right-click on the
new “cell” tablet to create “Trx”.
5. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
6. Open the CS, SCCP the RLC/MAC, LLC, BSSGP
and PS signaling windows using BSC Signal Trace to
record signaling;
7. MS powers on and registers successfully in the Macro
cell;
8. MS makes a call in the Macro cell. The call could be
established successfully and the voice is normal.
9. MS attach and PDP activate successes.
10. MS performs ping testing, FTP downloading and
uploading in the Macro cell.

Anticipative Result 1. The new Macro cell is created successes.


2. Data synchronization operation successes.
3. “Assignment complete” message sent from BSC to
MSC could be observed in SCCP signaling trace.
4. “Attach complete” message sent from BSC to SGSN
could be observed in LLC signaling trace
5. “Activate PDP context accept” message sent from
BSC to SGSN could be observed in LLC signaling
trace
6. Ping test, FTP download and upload is success
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 144
4.107 Concentric Circle Technology

4.107.1 Handover based on Passloss&TA


Test Item Handover based on Passloss&TA
Objectives To verify if the system support Handover base on
PathLoss and TA
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
7. ensure cell A support subcell with TRX1 belong to
subcell 1 and TRX2 belong to subcell 2
Test Steps 1. Double-click “handover control” tablet to open
handover control property “handover control” page,
set “Allow standover PBGT handover” as “NO”
2. Double-click “handover control” tablet to open
handover control property “subcell params” page, set
“Subcell handover algorithm” as “Handover based on
path loss and TA”
3. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
4. Inspect and verify no any current alarms from OMC;
5. Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
6. In “dynamic data management” page, block TRX2 in
“TRX management”
7. MS make a voice call far away from the antenna of
cell A and hold on
8. In “dynamic data management” page, unblock TRX2
in “TRX management”
9. Go near to the antenna of cell A and call end.
Anticipative Result 1. Handover performed signal in SCCP can be found in
step 9
2. The value of “cause” in message “Handover
performed ” in SCCP signaling trace is “Better cell” in
step 9
3. Block and unblock channel operation successes in
step 6 and step 8
4. Data synchronization operation successes in step 3
Message Flow

Test Description

Test Result

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 145
Parameters Setting Default parameters

4.107.2 Handover based on C/I


Test Item Handover based on C/I
Objectives Concentric Circle Technology
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default parameters in BSC;
5. MSs are ready;
6. ensure good radio environment;
7. ensure cell A support subcell with TRX1 belong to
subcell 1 and TRX2 belong to subcell 2
Test Steps 1. Double-click “handover control” tablet to open
handover control property “handover control” page,
set “Allow standover PBGT handover” as “NO”
2. Double-click “handover control” tablet to open
handover control property “subcell params” page, set
“Subcell handover algorithm” as “Concentric
handover”
3. Double-click “handover control” tablet to open
handover control property “Handover level” page, set
“Good C/I” as 170 and “Bad C/I” as 160
4. Right-click “BSC managed element” tablet and select
“synchronize modified data”;
5. Inspect and verify no any current alarms from OMC;
6. Open the CS and SCCP signaling windows using
BSC Signal Trace to record signaling;
7. In “dynamic data management” page, block TS2 to
TS7 of TRX1 in “TRX management”
8. MS make a voice call near the BTS
9. MS go far away from BTS.
10. In “dynamic data management” page, unblock TS2 to
TS7 of TRX1 in “TRX management”
11. Observe the value of “cause” in message “Handover
performed” in SCPP signaling trace
12. Call end.
Anticipative Result 1. Handover performed signal in SCCP can be found in
step 11
2. The value of “cause” in message “Handover
performed ” in SCCP signaling trace is “Better cell” in
step 11
3. Block and unblock channel operation successes in
step 7 and step 10
4. Data synchronization operation successes in step 4
Message Flow

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 146
Test Description

Test Result

Parameters Setting Default parameters

4.108 Multi-band Networking

4.108.1 Cell re-selection from 900M to 1800M


Test Item Cell re-selection from 900M to 1800M
Test Networking As shown in Fig.3

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 Cell B which is 1800M is adjacent handover/reselection
cell of Cell A which is 900M.
Test Steps 1 MS switch on and registers in cell A;
2 Use MCSF to trigger MS A handover from cell B to cell
A;

Anticipative Result 1 MS can register successfully in cell A after step 1;


2 MS register in cell B successfully after step 2.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.108.2 Cell re-selection from 1800M to 900M


Test Item Cell re-selection from 1800M to 900M
Test Networking As shown in Fig.3

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 147
Precondition 1 check CN is healthy, see chapter Check Test
Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 Cell A which is 900M is adjacent handover/reselection
cell of cell B which is 1800M.
Test Steps 1 MS switch on and registers in cell A;
2 Use MCSF to trigger MS A handover from cell B to cell
A to make the signal level of Cell A better than that of
Cell B.
Anticipative Result 1 MS can register successfully in cell B after step 1;
2 MS can register cell A after step 2.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.108.3 Cell handover from 900M to 1800M


Test Item Cell handover from 900M to 1800M
Test Networking As shown in Fig.3

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 Cell B which is 1800M is adjacent handover/reselection
cell of Cell A which is 900M.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 148
Test Steps 1 Open the SCCP signaling windows using BSC Signal
Trace to record signaling;
2 Double-click “Handover control1” of cell A to open
handover control property page;
3 Click “Handover control” page and set “Allow standover
PBGT handover” as “YES”;
4 Click “Handover level” and set “PBGTHo”: Value N=1,
Value P=1;
5 Select cell B in Adjacent cell handover and reselection
list of cell A and click in tools bar. Set
“HoMarinPbgt” as 5 in the pop-up window.;
6 Right-click “BSC managed element” tablet and select
“synchronize modified data”;
7 MS makes a call in cell A;
8 Use MCSF to trigger MS A handover from cell A to cell
B;

Anticipative Result 1 MS calls in cell A successfully;


2 MS handovers from cell A to cell B successfully after
step 8;
3 ‘Handover complete’ message sent from BSC to MSC
could be observed in SCCP signaling trace.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.109 Clock Synchronization on GPS


Test Item Clock Synchronization on GPS

Sub-Item Clock Synchronization on GPS


Objectives To verify BTS can be synchronize by GPS
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 149
4. check default and record cell configuration and
parameters in BSC;
5. CC module with GPS function is ready
6. MS should be ready;
7. ensure good radio environment;
8. GPS equipment is connected to BTS, active and standby with
two different CC modules ;
Test Steps 1. Configure GPS clock resouce mode ;
2. BTS start to trace to GPS clock in both active and standby;
3. Disconnect active GPS clock. The clock status is changed to
priority 2 (defined by user).
4. Manual switch over CC board to backup module.
5. standby GPS clock take up as master
6. Connect active GPS to master CC board
7. Manual switch over CC board to master module
8. make a CS call throughout the testing period
9. make a PS call throughout the testing period
10. Record any configuration and method to trace the clock.
Anticipative Result 1. The BTS works normally in the GPS clock mode;
2. During CC board switch over, CS and PS call will be
interrupted.
3. call succeed, PS call can be setup successfully throughout
the testing period;
Test Description
Test Result

4.110 MS Specification Collection


Test Item MS Specification Collection
Test Networking

Precondition 1 check CN is healthy, see chapter Check Test


Environment;
2 check BSC is healthy, see chapter Check Test
Environment;
3 check SDR is healthy, see chapter Check Test
Environment;
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
7 Several MS with different capability (AMR capability,
DTM capability, MS radio access capability etc.).

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 150
Test Steps 1 Open the CS and SCCP signaling windows using BSC
Signal Trace to record signaling;
2 Make CS calls and hold on for 2 minutes using different
MS.
3 Make PS service such as attach, PDP active, file
download/upload.
4 Check MS specification collection statistics from OMCR.
Anticipative Result 1 CS call could be established successfully and the voice
is clear.
2 PS service is normal, the speed of data transferring is
ideal.
3 The collection statistics is consistent with the capability of
MSs.
Message Flow
Test Description
Test Result
Parameters Setting Default parameters

4.111 Random Fill Bits


Test Item LAPDm Random Fill Bits
Test Networking
Precondition 1 check CN is healthy;
2 check BSC is healthy;
3 check SDR is healthy;
4 check default cell configuration and parameters in BSC;
5 Sagem OT498,which can support LAPDm message trace,
is ready;
6 ensure good radio environment;
7 SDR version supports “LAPDm Random Fill Bits” function;
Test Steps 1 Double-click “cell” table to open cell property “Basic
params2” page, check “LapdmL2Cfg” parameter, default
value is “No”;
2 Connect OT498 to PC and run OTDrive4 software, select
and trace LAPD-m message;
3 Make a voice call and record the LAPDm message;
4 Modify “LapdmL2Cfg” as “Yes”;
5 Right-click “BSC managed element” table and select
“synchronize modified data”;
6 Inspect and verify no any current alarms from OMC;
7 Make a voice call and record the LAPDm message;
8 Compare the random fill bits in downlink I frame between
step 3 and step 7;
Anticipative Result 1 Data synchronization operation success in step 5;
2 In step 3, the random fill bits of downlink I frame are
“00101011”;
3 In step 7, the random fill bits of downlink I frame are
random bits;
Test Result
Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 151
4.112 Enhanced One Logical Cell with Multi RRU
Test Item Enhanced One Logical Cell with Multi RRU
Sub-Item Multi-Channel mode(1 TRX MCM)
Objectives To verify if the BTS support configuration GSM 1+1 MCM
This configuration of MCM using multiple RRUs extends
the radio coverage limited by a single RRU in certain use
cases.
Test Networking As shown in Error! Reference source not found.
Precondition 1. CN work normally.
2. BSC work normally.
3. One B8200 is connected with 2 R8860s.
Test Steps 1. Connect LMT to the BTS.
2. Configure GSM 1 + 1(MCM) , and wait for all cells
working normally.
3. Make voice call in each cell.
Anticipative Result 1. The BTS in configuration GSM 1+1 (MCM) work
normally.
2. Voice call can be setup successfully in each MCM
cell.
3. The Call can share same channel of different RRU
within each cell.
Test Description
Test Result

4.113 RLC Acknowledged/Unacknowledged Mode


Test Item RLC Acknowledged/Unacknowledged Mode
Test Networking
Precondition 1 check CN is healthy
2 check BSC is healthy
3 check SDR is healthy
4 check default cell configuration and parameters in BSC;
5 MSs are ready;
6 ensure good radio environment;
Test Steps 1 Set subscriber’s Reliability class as RLC
acknowledged mode in HLR;
2 MS performs GPRS attach and PDP activation;
3 Observe in MS which RLC mode used.
4 FTP download a file (size: 200kBytes).
5 Set subscriber’s Reliability class as RLC
unacknowledged mode in HLR;
6 MS performs GPRS attach and PDP activation;
7 Observe in MS which RLC mode used.

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 152
8 FTP download a file (size: 200kBytes).

Anticipative Result 1 At step 2, the Reliability class is acknowledged RLC


which can be found in “Activate PDP context accept
” message;
2 At step 3, RLC acknowledge mode is used
3 At step 4, FTP download succeed.
4 At step 6, the Reliability class is unacknowledged RLC
which can be found in “Activate PDP context accept
” message;
5 At step 7, RLC unacknowledge mode is used
6 At step 8, FTP download succeed.
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.114 Data Traffic Channels


Test Item Data Traffic Channels
Test Networking
Precondition 1. check CN is normal;
2. check BSC is normal;
3. check SDR is normal;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. Ensure good radio environment;
7. Test SIMs have been subscribed the corresponding
service of data call in HLR.
8. Test MS supports data call service.
Test Steps 1. Open the CS, SCCP signaling windows using Signal
Trace to record signals;
2. Open the program HyperTerm in PC connecting with
two MS.
3. Input AT Command in HyperTerm to control the call;
4. In MO side, input “at”, “at+cbst=7,0,1”;
5. In MT side, input “at”, “ats0=1”;
6. In MO side, input “atd callnumber” to init a CS data
call;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 153
7. After call is connected, send text in HyperTerm and
send ZIP file.
Anticipative Result 1. Channel Mode in ”Assignment Command” in CS signal
trace is data channel;
2. Data call succeed;
3. Send and receive ZIP file successfully, and file can be
read after received.
Parameters Setting Default parameters

Message Flow

Test Description

Test Result

4.115 Quality of Service (QoS)


Test Item Quality of Service (QoS)
Test Networking
Precondition 1. check CN is healthy
2. check BSC is healthy
3. check SDR is healthy
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Set subscriber’s Reliability class as RLC
acknowledged mode in HLR;
2. MS performs GPRS attach and PDP activation;
3. Observe in MS which RLC mode used.
4. FTP download a file (size: 200kBytes).
5. Set subscriber’s Reliability class as RLC
unacknowledged mode in HLR;
6. MS performs GPRS attach and PDP activation;
7. Observe in MS which RLC mode used.
8. FTP download a file (size: 200kBytes).
Anticipative Result 1. At step 2, the Reliability class is acknowledged RLC
which can be found in “Activate PDP context accept
” message;
2. At step 3, RLC acknowledge mode is used
3. At step 4, FTP download succeed.
4. At step 6, the Reliability class is unacknowledged RLC
which can be found in “Activate PDP context accept
” message;
5. At step 7, RLC unacknowledge mode is used
6. At step 8, FTP download succeed.
Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 154
Message Flow

Test Description

Test Result

4.116 Queuing
Test Item Queuing
Test Networking
Precondition 1. check CN is healthy, see chapter Check Test
Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. ensure good radio environment;
6. Two MS
Test Steps 1. Set the cell parameter ‘Queue allowed when assign’
=YES;
2. MS1 makes a call successfully;
3. Block channels which are not used in the cell;
4. MS2 make a call ;
5. MS1 release call before the queue time-out.
Anticipative Result 1. Queuing Indication is found in signalling trace.
2. MS2 occupies the channel which is released by MS1,
the call established
Test Description
Test Result

4.117 Star, Tree, and Chain Networking

4.117.1 Star networking


Test Item Star networking
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 155
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in cell, in IDLE mode;

Test Steps 1. BTS 1 and BTS 2, configured to connect to BSC


shown as following picture;

iBSC

BTS 1 BTS 2

2. Check the status of BTS 1 and BTS 2;


3. Make a call in BTS 1 and BTS 2;
Anticipative Result 1. For step 2, the status of BTS 1 and BTS 2 should be
normal;
2. For step 3, the call can be established in BTS 1 and
BTS 2 successfully;
Test Description

Test Result

4.117.2 Tree networking


Test Item Tree networking
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in cell, in IDLE mode;

Test Steps 1. BTS 1, BTS 2 and BTS 3, configured to connect to


BSC shown as following picture;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 156
iBSC

BTS 1 BTS 3

BTS 2

2. Check the status of BTS 1, BTS 2 and BTS 3;


3. Make a call in BTS 1, BTS 2 and BTS 3;
Anticipative Result 1. For step 2, the status of BTS 1, BTS 2 and BTS 3
should be normal;
2. For step 3, the call can be established in BTS 1, BTS
2 and BTS 3 successfully;
Test Description

Test Result

4.117.3 Chain networking


Test Item Chain networking
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. MS registers successfully in cell, in IDLE mode;

Test Steps 1. BTS 1 and BTS 2, configured to connect to BSC


shown as following picture;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 157
iBSC

BTS 1

BTS 2

2. Check the status of BTS 1 and BTS 2;


3. Make a call in BTS 1 and BTS 2;
Anticipative Result 1. For step 2, the status of BTS 1 and BTS 2 should be
normal;
2. For step 3, the call can be established in BTS 1 and
BTS 2 successfully;
Test Description

Test Result

4.118 BTS Recovery


Test Item BTS Recovery
Test Networking As shown in the figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
Test Steps 1. Make a call under the BTS;
2. Disconnect the Abis link between BTS and BSC;
3. Wait 5 minutes, connect the Abis link;
4. Make a call
Anticipative Result 1. For step 1 and step 4, the call can be established
successfully.
Test Description

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 158
4.119 Dry Contact Alarm(Optional)

4.119.1 Dry Contact Alarm


Test Item Dry Contact Alarm
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. ensure good radio environment;
6. Configure dry contact alarm “smog alarm” as index 0
alarm.
Test Steps 1. Configure alarm property as “enable in normal state”
2. Short pin 1 and 14 in SA board
3. Observe if “smog alarm” reported.
4. Configure alarm property as “disable in normal state”
5. repeat step 2-3

Anticipative Result 1. No “smog alarm” reported to dry contact in step 3.


2. “smog alarm” reported to dry contact in step 5;

Message Flow

Test Description

Test Result

Parameters Setting Default parameters

4.120 Backward Compatibility for BTS


Test Item Backward Compatibility for BTS
Test Networking As shown in the figure 1

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 159
6. ensure good radio environment;

Test Steps 1. Connect the SDR to BSC;


2. Check the BTS is normal, performs CS and PS
service ;
3. Upgrade the SDR software version to a new one;
4. Check the BTS is normal, performs CS and PS
service
Anticipative Result 1. For step 2, the BTS is normal. CS and PS service are
normal.
2. For step 4, the BTS is normal. CS and PS service are
normal.

Test Description

4.121 Network-assisted Cell Change


Test Item Intra BSC NACC
Test Networking

Precondition 1. check CN is healthy, see chapter Check Test


Environment;
2. check BSC is healthy, see chapter Check Test
Environment;
3. check SDR is healthy, see chapter Check Test
Environment;
4. check default cell configuration and parameters in
BSC;
5. MSs are ready;
6. ensure good radio environment;
7. configure two BTS ;
8. configure the two BTS as neighbor cell;

Test Steps 1. Configure BSC do not support NACC


2. EGPRS MS power on
3. EGPRS MS select a cell as serve cell
4. EGPRS MS attach, PDP activate and ping.
5. attenuate the RX power lever of serving cell, till cell
reselect
6. Configure the 2G cell parameter ‘NETWORK
CONTROL ORDER’ =NC0.
7. Configure BSC support NACC;
8. cell support NACC;
9. neighbor cell support CCN mode;
10. Repeat step 2 to step 5.
Anticipative Result 1. ‘Packet Cell Change Notification’ could be observed
sent from MS to BSC;
2. ‘Packet Neighbor Cell Data’ could be observed sent
from BSC to MS.
3. ‘Packet Cell Change Continue’ could be observed

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 160
sent from BSC to MS.
4. The interval time of cell reselection is shortened when
NACC used.
Message Flow

Test Description

Test Result

Parameters Setting Default parameters

ZTE Confidential Proprietary © 2010 ZTE Corporation. All rights reserved. 161

Anda mungkin juga menyukai