\U \ no"\
b) Goggles only
b) 220Y
c) 240Y
d) ISOY
a) 25 ft J
b) 50 ft
c) 50 meters
d) J00 ft
4) The ratio of vertical to horizontal spacing for a straight or extension ladder is:
a) I to I
b) 2 to I
c) 3 to 1 /
d) 4 to I ../
5) A straight or extension ladder must extend over the edge of a roof, excavation, or scaffold platform
by a minimum distance of:
a) I foot
b) 4 feet /
c) 0.9 meter V
d) No set distance
6) The Saudi Aramco General Instruction which sets forth the Work Pennit Receiver's requirements is:
a) Gl l.200
b) GI5.430 /
c) G12.100
d) G16.200
7) If someone is injured on your job site, a preliminary written report must be submitted to the Saudi
Aramco PMT within period of time:
a) 2 hours /'
b) 24 hours . /
c) 8 hours
d) 3 days
8) Work platfonns must have toe boards, mid rails, top rails and access ladders once they reach a height
of _ __
a) 4 ft - . /
b) 8 ft
c) 6 ft
d) When the height is four times greater than the base width
9) Excavation "Spoils" must be set back a minimum of _ _ fTom the sides of the excavation.
a) 1 meter / '
b) 6 ft
c) 3 ft
d) 2 ft
a) 7
b) 10 / ,
c) 15
d) 19.50
II) During storage of oxygen and acetylene gas cylinders they must be separated by (I) A Fire Resistant
Wall or (2) A Distance of _ __
a) 20ft . /
b) 50 ft
c) Not required iftanks are empty
d) Not required ifprotective caps are on
e) None of the above
a) Type A
b) TypeB /
c) Type C
14) What is necessary for a worker to wear On a steel beam six feet or more above ground?
15) When there are openings in roof work and /o r at edges of roofs, and a fall hazard exist, barricades
must be installed capable of withstanding a force of:
16) Which of the following factors does not affect the load capacity ofa mobile crane?
a) Boom length
b) Boom angle
17) How many clips are required to construct an eye in a one-half inch wire rope?
18) Class "B" fires involve flammable liquids or gases that could be under pressure. What would give
you most concern when selecting a Class "B" fire extinguisher?
a) I month
b) I week ./
c) I shift v'
d) 1 day
a) 10 ft
b) 15 ft
c) 50 ft ./
d) 25 ft .../
21) When transferring an extremely flammable liquid from a 55 gallon drum via a hand pump to a small
metal safety can, which of the following provides the best protection?
22) A small mobile crane with rubber tires has struck a power line. The line, which is now believed to
be dead, is lying across the crane boom. Which of the following best describes the proper course of
action for the Crane operator?
c) Have the oiler knock the line from the boom with a wood pole
d) Swing the boom back and forth until the line breaks or falls off
23) When checking the ground on a duplex outlet, which of the following provides the best method?
b) Check continuity between the green wire and the outlet box
c) Check continuity between the white wire and the outlet box /
d) Check continuity between the green wire and the building ground J
24) Which of the following is true concerning explosive proof equipment? Explosive proof equipment is
allowed to operate in a flammable or explosive atmosphere because it is capable of:
25) How long should the appointed "Fire Watch" remain at the site of HOT work after the work has
stopped?
a) 10 minutes
b) 15 minutes
c) 20 minutes /
d) 30 minutes ../
c) To determine the length of the wire rope that has been extended /'
d) To prevent the overhaul ball from contacting the boom sheaves -../
27) What are the most important self-developed skills of a site safety officer?
a) Explosive atmospheres
29) When lifting over or adjacent to process piping, etc., what is required?
a) Hold Tag
b) Welding Machine
c) Rigger3
b) Guys
c) Tag Lines
d) Shackles /'
31) If you found a fire exit blocked by a wooden pallet what would you do?
a) Leave it
c) Move it immediately . /
b) Singed by Operations
33) What is the permissible noise exposure for an eight-hour work shift?
a) 80 /'
b) 90 ../
c) 100
d) 120
35) Hold tags and locks are primarily intended to protect the individual who is doing the work from?
d) Sleeping
SECTION 2
I. When step ladders have steps on one side and rungs on the other, two men may be on the same
ladder at the Same time:
a) True
b) FalseV
2. Portable power tools being operated from an on site generator need not be protected by a GFCI
(ground fault circuit interrupter) to be consistent with the Saudi Aramco CSM.
a) True
b) False / '
3. Excavation not subject to vehicle traffic may be barricaded using Red and White Warning Tape:
a) True
b) False /
4. The new heavy plastic 5 gallon drums may be used to store, transport, and dispense diesel fuel only.
a) True
b) False .../
5. Cigarette smoking is forbidden anywhere on Saudi Aramco construction sites except in designated
and approved smoking shelters.
a) True /
b) False
6. Holes may be drilled into sides of hard hats to provide for cross ventilation air-flow during very hot
weather.
a) True /
b) Falsev'
a) True
b) FalseJ
8. Soap and paper towels must be provided for the men to clean up before meals.
a) True /
b) False
9. Push sticks must always be used when guiding woodwork into a table saw.
a) True J
b) False
10. Rubber boots must be provided for persons engaged in the pouring of concrete.
a) True / "
b) False
II . When wearing rubber boots for concrete pours, it is not necessary to have your steel toe boots/shoes
on.
a) True /
b) False J
12. Placing an 8'2" X 12" board over two 20-liter paint cans is allowed for temporary work platform.
a) True
b) Falsc /
J 3. Formwork boards should be removed to the de-nailing area as soon as possible after they are
disassembled.
a) True /
b) Fal se
14. A fire extinguisher must be placed near (5 to 15 feet) to any combustion engine being operated on
site.
a) True ·/
b) False
a) True . /
b) Fal se
a) True /
b) False
17. Hand held power tools such as drill s and grinders may be locked-on if the job is going to take a long
period of time to accomplish.
a) True /
b) False
18. Permanent scaffolds should be secured by tyin g off to a firm portion of the structure every 26 ft.
vertically, 30 ft. horizo ntall y, at each end, and the top.
a) True /
b) False
19. Scaffo ld planks must be at least 2" thick by 9" wide or up to 2" thick by 12" wide.
a) True /
b) False
20. Scaffold planks must be tied to or otherwise secured to the scaffold bearers.
a) True . /
b) False
21. The windsocks in Saudi Aramco facilities are to let people know in which direction a gas or
chemical leak will fl ow.
a) True
b) Fa lsJ
22. A Safety Officer must to ur the site several times a day becau se conditions are changin g constantly
during construction activities.
a) TrueJ
b) False
23. Dangerous safety hazard s should be noted and kept in writing so that they can be reported at the next
Safety meetin g.
a) True/
b) False
24. A weekly Safety Inspection of each area should be carried out and a report of defects given to those
responsible for correcting them.
a) True .../
b) False
25. A Safety Officer checks all construction activities only. The personnel officer checks the medi ca l
facilities, toilet facilities, drinking water and all things affecting health and welfare.
a) True
b) False /
26. When hot tapping gasoline lines, it is very important to establish and maintain product now.
a) True J
b) False
27. It is okay to bring chemicals on site without a MSDS if you only have 20 liters of liquid or 10 cubic
meters of a toxic gas.
a) True /
b) False J
28. Crane operations must be stopped when the wind speed is over 10 mph?
a) True /'
b) False -../'
a) True . /
b) False / '
30. Before use, all new lifting equipment should be subjected to a proof load test by the manufacture
and certified.
a) True . /
b) False
31. Respiratory protective devices can be classified as, air purifying, supplied air, & self-contained
breathing devices.
a) True /
b) False
32. When perfonning excavation work and there is no know underground uti lities, by suspected
utilities, it is permissible to use mechanical equipment to excavate.
a) True ./
b) Faise V
68 Questions Requiring 80% to Pass
(Correct Answer to 55 Questions)