• Thickness baseplate • Bolt size and bolt number • Diameter hole (diameter hole adalah diameter bolt + ¼”)
Input yang harus diketahui didalam mendesain pressure vessel adalah:
• Design pressure (Pd) • Design temperature • Diamater dan panjang Vessel • Corrosion allowance (C) • Joint efficiency – E - (0.7 adalah harga joint efficiency untuk pressure vessel tanpa radiography test, 0.85 adalah harga joint efficiency untuk pressure vessel yang diinspeksi dengan spot radiography, sedangkan joint efficiency 1 adalah harga untuk pressure vessel yang di inspeksi secara fully radiography). Radiogra • Material yang akan digunakan, disini akan dicari harga allowable stress untuk material yang dipilih. Penamaannya adalah sebagai berikut: Sh = allowable stress untuk material head, Ss = allowable stress untuk mater Sn = allowable stress untuk material nozzle, etc. • Bentuk head untuk menghitung factor K didalam perhitungan thickness dan MAWP head. Untuk 2:1 ellipsoidal hea • Perlu juga diketahui orientasi vessel, seismic zone, wind speed untuk perhitungan load yang akan bekerja pada vess lly radiography). Radiography test merefer ke UW-11.
owable stress untuk material head,
. Untuk 2:1 ellipsoidal head K = 1.
ng akan bekerja pada vessel. Static Head 1. Perhitungan static head. Static head adalah tekanan yang terjadi akibat elevasi yang dimiliki ol Rumus untuk menghitung static head adalah: Ps= ∫liquid x h Design Data: Max. Internal Design Pressure (Pi): Mpa Fluid: Fluid Specific Grafity (SG): g/cm3 Liquid Height (h): mm
Static Head From Lower Shell
SG*h Ph= = Mpa 100000
Design Pressure Calculations (UG-98(b))
P = Pi + Ph = Mpa akibat elevasi yang dimiliki oleh fluida didalam vessel. Shell Thickness Pipe Description Material&Condition: Design Pressure (P): Mpa Material Specification: Allowable Stress (S): Mpa Undertolerance Allowance (UTP): % Joint Efficiency (E):
Dimensions: Outside Diameter (Do): mm Nominal Wall Thickness (t): mm tmin UG-16(b): mm Corrosion Allowance (C): mm