Float glass (including tempered, Sika® Cleaner G+M or toughened, laminated Sika® Cleaner P and tinted types) Sika® Cleaner P** & Sika® Aktivator-100* or Ceramic-coated (enamelled) glass Sika® Cleaner G+M & Sika® Primer-790 Sika® Cleaner P** or Sika® Cleaner P** & Sika® Anodized aluminum Aktivator-100* Sika® Cleaner G&M & Sika® Primer-790 +M or Sika® Cleaner P** & Sika® Stainless steel Aktivator-100* Sika® Cleaner G&M & Sika® Primer-790 Polyester powder-coated P** & Sika® Aktivator-205* or aluminum or Sika® Cleaner G+M & Sika® PVDF-coated aluminum Primer-790 * Sika® Aktivator-100 and Sika® Aktivator-205 leave a visible film on the pre-treated surfaces and can change the appearance of the pre-treated substrates. If this is not acceptable, use masking tape to protect the visible areas. ** For greasy or oily metal surfaces, Sika® Cleaner G+M is recommended instead of Sika® Cleaner P.
Table 4: Storage time of bonded façade units*
Time after applying Time after applying Step Conditions 1-part adhesives** 2-part adhesives Initial curing and Store units stress-free in adhesion till full curing 24 hours horizontal position build-up Strength-build up and Store units with dead load after full curing, see 3 days increase of adhesion support vertically corresponding PDS Further strength and Transportation of units 4 days adhesion increase vertically with support Ultimate strength and Installation of Elements > 7 days adhesion reached * Times can be reduced with the use of Sika® Spacer Tape HD (see Figure 2, B). For details consult the Technical Department of Sika Industry. ** Depends on joint dimension and ambient conditions.