ENGINE 01
FOREWORD
This wiring diagram incorporates the wiring schematics
of the Mazda3, Mazda3 MPS and available optional
equipment. Actual vehicle wiring may vary slightly SUSPENSION 02
depending on optional equipment or local specifications,
or both.
All rights reserved. No part of this book may be HEATER, VENTILATION &
reproduced or used in any form or by any means,
AIR CONDITIONING (HVAC)
07
electronic or mechanical-including photocopying and
recording and the use of any kind of information storage
and retrieval system-without permission in writing.
RESTRAINTS 08
Mazda Motor Corporation
HIROSHIMA, JAPAN
Two digits (section ID) indicated in front of each title are commonly used with the Workshop Manual.
1
00R Reading Wiring Diagrams
VEHICLE IDENTIFICATION NUMBER (VIN) CODE
JM0 BL 1 0 F 2 0 0 123456
Serial No.
No significance 0= Dummy
2
Reading Wiring Diagrams 00R
VEHICLE IDENTIFICATION NUMBERS (VIN)
3
00R Reading Wiring Diagrams
CONTENTS OF WIRING DIAGRAMS
x This manual comprises the sections shown below.
4
Reading Wiring Diagrams 00R
GROUND POINTS
x This shows ground points of the harness.
Ground indication
On vehide Indication
On circuit diagrams and ground points
5
00R Reading Wiring Diagrams
SYSTEM CIRCUIT DIAGRAM/CONNECTOR DIAGRAM
x These diagrams show the circuits for each system, from the power supply to the ground. The power supply side
is on the upper part of the page, the ground side on the lower part. The diagrams describe circuits with the
ignition switch off.
Below is an explanation of the various points in the diagram.
System name
Connector code
The prefix letter indicates the system in which the
connector is used.
6
Reading Wiring Diagrams 00R
Current symbol Multiplex communication
Current flows in the direction of the arrow. Indicates communication with connected parts.
Signals are transmitted back and forth between connected parts.
White
B Black W/R (base color)
(F) (F)
Red(stripe)
Connector symbols
x Male and female connectors are represented as follows
in the circuit and connector diagrams.
Circuit diagram Connector
symbol diagram symbol
L
Male
Male R
Female
L
Female
R
Ground numbers x Like connectors are linked by dashed lines between the
A harness ground is represented differently than a connector symbols.
unit ground. x Connector diagrams show connectors on the harness
side. The terminal indicates the view from the harness
side.
Types of grounds Symbol
Harness (Example)
7
00R Reading Wiring Diagrams
ROUTING DIAGRAM
x The routing diagram shows where electrical components are on the system circuit diagram by call out line and
connector symbols.
8
Reading Wiring Diagrams 00R
HARNESS SYMBOLS
SYMBOLS
–––––––––––––––
Ground (1) x Connecting point to vehicle body or
other ground wire where current flows
from positive to negative terminal of
battery.
G01 x Ground (1) indicates a ground point to
body through wire harness.
Ground (2) x Ground (2) indicates point where Resistance x A resistor with a constant value.
component is grounded directly to x Mainly used to protect electrical
body. components in circuits by maintaining
rated voltage.
Remarks
x Current will not flow through a circuit if
Ground (3) ground is faulty. Motor x Converts electrical energy into
mechanical energy.
9
00R Reading Wiring Diagrams
Precautions
x Do not replace with fuses exceeding
specified capacity. Cigarette lighter x Electrical coil that generates heat.
Speaker
Relay (1) x Current flowing through coil produces electromagnetic force causing contact to open or close.
No current to coil Current to coil
No flow Flow
Normally open
10
Reading Wiring Diagrams 00R
Symbol Meaning Symbol Meaning
Relay (2) x Current flowing through coil produces electromagnetic force causing contactto close.
No current to coil Current to coil
Flow No flow
Normally closed
Sensor (1) x Detects characteristics such as intake Solenoid x Current flowing through coil generates
manifold vacuum and airflow amount electromagnetic force to operate
according to resistance variation. plungers.
Sensor (2) x Detects resistance variation according Diode x Known as a semiconductor rectifier,
to operation of other parts. the diode allows current flow in one
direction only.
Cathode(K) Anode(A)
Sensor (3) x A resistor whose resistance variation Flow of electric current
according to temperature variation.
x When temperature increases, K A K A K A
resistance decreases.
Sensor (4) x Detects pulse signals from rotating Light-emitting x A diode that lights when current flows.
object. diode x Unlike ordinary bulbs, the diode does
(LED) not generate heat when lit.
Cathode(K) Anode(A)
Sensor (5) x Generates potential difference when Cathode(K)
tension or pressure is applied.
Anode(A)
Flow of current
Capacitor x Component that temporarily stores Reference diode x Allows current to flow in one direction
electrical charge. (Zener diode) up to a certain voltage; allows current
to flow in the other direction once that
voltage is exceeded.
Symbol Meaning
Extent of the change in the wiring position (1) x The wiring position can be exchanged freely within the
connector.
C A
E
E C A
B B B
B B B
F D B
F D B
Extent of the change in the wiring position (2) x The wiring position can be exchanged according to the
following combinations only.
C
E A Between A and B, Between C and D, Between E and F
B B B E C A
B B B
F D B F D B
Extent of the change in the wiring position (3) x The wiring position can be exchanged according to the
following combinations only.
3 2 1 2 1 Between 1, 2, 4 and 7.
L B B
5 4 x The wiring positions may be indicated by numbers for some
L B 4
connectors.
8 7 6
B/Y B R 7
11
00R Reading Wiring Diagrams
SERVICE WARNING AND CAUTION FOR VEHICLES WITH SRS AIR BAG SYSTEM
If the SRS air bag system inspection is not performed correctly in accordance with the workshop manual procedures it could
cause the system to operate (deploy) accidentally, resulting in injury.
Always follow the service warnings and cautions in the workshop manual when performing the SRS air bag system-related
inspection or servicing.
12
Reading Wiring Diagrams 00R
LH LEFT HAND ST START
LO LOW SW SWITCH
LR LEFT REAR TC TURBOCHARGER
M MOTOR TCC TORQUE CONVERTER CLUTCH
MAF MASS AIR FLOW TRANSMISSION(TRANSAXLE)
TCM
MAP MANIFOLD ABSOLUTE PRESSURE CONTROL MODULE
MFI MULTIPORT FUEL INJECTION TCS TRACTION CONTROL SYSTEM
MID MIDDLE TEMP TEMPERATURE
MIL MALFUNCTION INDICATOR LAMP TFT TRANSAXLE FLUID TEMPERATURE
MIN MINUTE TRIPLE INDUCTION CONTROL
TICS
MIX MIXTURE SYSTEM
MPX MULTIPLEX TNS TAIL NUMBER SIDE LIGHTS
MS MIDDLE SPEED TP THROTTLE POSITION SENSOR
MT MANUAL TRANSMISSION TIRE PRESSURE MONITORING
TPMS
MTX MANUAL TRANSAXLE SYSTEM
N NEUTRAL TR TRANSMISSION(TRANSAXLE) RANGE
NC NORMALLY CLOSED TWS TOTAL WIRING SYSTEM
NO NORMALLY OPEN V VOLT
O2S OXYGEN SENSOR VAF VOLUME AIR FLOW SENSOR
OBD ON-BOARD DIAGNOSTIC VENT VENTILATION
O/D OVER DRIVE VARIABLE INERTIA CHARGING
VICS
OFF SWITCH OFF SYSTEM
13
00P Electrical System General Procedures
ELECTRICAL PARTS B6U000000006W03
Battery Cable
• Before disconnecting connectors or removing
electrical parts, disconnect the negative battery cable. NEGATIVE BATTERY CABLE
WGIWXX0007E
Wiring Harness
• To remove the wiring harness from the clip in the
engine room, pry up the hook of the clip using a
flathead screwdriver.
WGIWXX0039E
Caution
• Do not remove the Harness protective tape.
Otherwise, the wires could rub against the body,
which could result in water penetration and
electrical shorting.
CONNECTORS NO GOOD
WGIWXX0040E
Disconnecting Connectors
• When disconnecting connector, grasp the connectors,
not the wires.
NO GOOD
WGIWXX0041E
14
Electrical System General Procedures 00P
• Connectors can be disconnected by pressing or
pulling the lock lever as shown.
WGIWXX0042E
Locking Connector
• When locking connectors, listen for a click indicating
they are securely locked.
X3U000WB1
Inspection
• When a tester is used to inspect for continuity or
measuring voltage, insert the tester probe from the
wiring harness side.
NO GOOD
WGIWXX0044E
Caution
• To prevent damage to the terminal, wrap a thin
wire around the tester probe before inserting
into terminal.
NO GOOD
WGIWXX0045E
15
00P Electrical System General Procedures
Terminals
Inspection
• Pull lightly on individual wires to verify that they are
secured in the terminal.
X3U000WB4
Replacement
• Use the appropriate tools to remove a terminal as
shown. When installing a terminal, be sure to insert it
until it locks securely.
• Insert a thin piece of metal from the terminal side of
the connector and with the terminal locking tab
pressed down, pull the terminal out from the
connector.
X3U000WB5
X3U000WB6
Fuse
Replacement
• When replacing a fuse, be sure to replace it with one
of the same capacity. If a fuse fails again, the circuit
probably has a short and the wiring should be
inspected.
• Be sure the negative battery terminal is disconnected
before replacing a main fuse.
YMU000WA1
16
Electrical System General Procedures 00P
• When replacing a pullout fuse, use the fuse puller.
YMU000WAK
Caution
• Do not connect a jumper wire from the power
source line to a body ground. This may cause
burning or other damage to wiring harnesses or
electronic components.
X3U000WBB
Voltmeter
• The DC voltmeter is used to measure circuit voltage. A
voltmeter with a range of 15 V or more is used by
connecting the positive (+) probe (red lead wire) to the
point where voltage will be measured and the negative
(-) probe (black lead wire) to a body ground.
X3U000WBC
Ohmmeter
• The ohmmeter is used to measure the resistance
between two points in a circuit and to inspect for
continuity and short circuits. POWER SOURCE LINE
Caution NO GOOD
• Do not connect the ohmmeter to any circuit
where voltage is applied. This will damage the
ohmmeter. GROUND LINE
OHMMETER
YMU000WAL
17
18
19
20
21
22
23
24
THIS PAGE INTENTIONALLY
LEFT BLANK
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
43 Revised 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
44 Revised 10/2012 (Ref. No. L041/12)
THIS PAGE INTENTIONALLY
LEFT BLANK
46
47
48
49
50
51
52
53
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
54 Revised 10/2012 (Ref. No. L041/12)
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
136
137
138
139
140
141
142
143
144
145
146
147
148
149
150
151
152
153
154
155
156
157
158
159
160
161
162
163
164
165
166
167
168
169
170
171
172
173
174
175
176
177
178
179
180
181
182
183
184
185
186
187
188
189
190
191
192
193
194
195
196
197
198
199
200
201
202
203
204
205
206
207
208
209
210
211
212
213
214
215
216
217
218
219
220
221
222
223
224
225
226
227
228
229
230
231
232
233
234
235
236
237
238
239
240
241
242
243
244
245
246
247
248
249
250
251
252
253
254
255
256
257
258
259
260
261
262
263
264
265
266
267
268
269
270
271
272
273
274
275
276
277
278
279
280
281
282
283
284
285
286
287
288
289
290
291
292
293
294
295
296
297
298
299
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
300 Revised 10/2012 (Ref. No. L041/12)
301
302
303
304
305
306
307
308
309
310
311
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
312 Revised 10/2012 (Ref. No. L041/12)
313
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
314 Revised 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
315 Revised 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
316 Revised 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
316-1 Added 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
316-2 Added 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
316-3 Added 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
316-4 Added 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
317 Revised 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
318 Revised 10/2012 (Ref. No. L041/12)
319
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
320 Revised 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
321 Revised 10/2012 (Ref. No. L041/12)
322
323
324
325
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
326 Revised 10/2012 (Ref. No. L041/12)
327
328
329
330
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
330-1 Added 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
330-2 Added 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
330-3 Added 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
330-4 Added 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
331 Revised 10/2012 (Ref. No. L041/12)
332
333
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
334 Revised 10/2012 (Ref. No. L041/12)
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
335 Revised 10/2012 (Ref. No. L041/12)
336
337
338
339
340
341
342
343
344
345
346
347
348
349
350
351
352
353
354
355
356
357
358
359
360
361
362
363
364
365
366
367
368
369
370
371
372
373
374
375
ALPHABETICAL INDEX
A D
A/C RELAY........................................................... 27,29,196 DATA LINK CONNECTOR-2 ............................................ 50
A/F SENSOR............................................... 82,100,120,140 DC-DC CONVERTER....................................................... 64
ABBREVIATIONS............................................................. 12 DIMMER CANCEL SWITCH .......................................... 348
ABS WHEEL-SPEED SENSOR..................................... 158 DISCHARGE HEADLIGHT CONTROL MODULE.......... 264
ACC RELAY ................................................................... 340 DOOR LATCH AND LOCK ACTUATOR.................. 224,250
ACCELERATOR PEDAL POSITION SENSOR...... 86,102,124,142 DOOR SPEAKER .................................................... 316,328
ACCESSORY SOCKET ................................................. 310 DRIVER-SIDE AIR BAG MODULE................................. 200
AFS CONTROL MODULE ............................................. 290 DRIVER-SIDE AIR MIX ACTUATOR.............................. 192
AFS OFF SWITCH ......................................................... 292 DRIVER-SIDE BUCKLE SWITCH .................................. 200
AIR BAG MODULE ........................................................ 200 DRIVER-SIDE CURTAIN AIR BAG MODULE................ 202
AIR INTAKE ACTUATOR ........................................ 184,192 DRIVER-SIDE PRE-TENSIONER SEAT BELT .............. 202
AIR MIX ACTUATOR ..................................................... 192 DRIVER-SIDE SIDE AIR BAG MODULE ....................... 202
AIRFLOW MODE ACTUATOR....................................... 190 DRIVER-SIDE SIDE AIR BAG SENSOR ....................... 204
AMBIENT TEMPERATURE SENSOR .................... 186,194 DSC HU/CM ................................................................... 158
ANTENNA ............................................................... 312,318 DSC OFF SWITCH......................................................... 160
AT MAIN RELAY ....................................................... 27,162 E
AUDIO AMPLIFIER ........................................................ 326 EGR COOLER BYPASS VALVE .................................... 100
AUDIO UNIT............................................................ 312,318 EGR VALVE........................................................ 80,106,118
AudioPilot®2 MICROPHONE......................................... 330 EHPAS CONTROL MODULE......................................... 180
AUTO DIMMING MIRROR............................................. 216 ELECTRIC AT OIL PUMP .............................................. 176
AUTO LEVELING CONTROL MODULE........................ 290 ELECTRIC AT OIL PUMP RELAY............................. 33,176
AUTO LEVELING SENSOR........................................... 292 ELECTRIC VARIABLE VALVE TIMING MOTOR/DRIVER ...... 148
AUTO LIGHT SENSOR........................................... 268,302 ELECTRIC VARIABLE VALVE TIMING RELAY ........ 27,134
AUXILIARY JACK ................................................... 314,320 ELECTRICAL WIRING SCHEMATIC .......................... 18,22
B ENGINE COOLANT TEMPERATURE SENSOR......90,104,128,140
BACK-UP LIGHT............................................................ 282 ENGINE OIL SOLENOID VALVE ................................... 136
BACK-UP LIGHT RELAY .......................................... 33,280 EVAPORATOR TEMPERATURE SENSOR ............ 184,190
BACK-UP LIGHT SWITCH............................................. 280 EXHAUST CAMSHAFT POSITION SENSOR................ 138
BASS-BOX ..................................................................... 330 EXHAUST GAS PRESSURE CORRECTION
BCM ...................... 186,194,206,210,222,248,258,262,274, TEMPERATURE SENSOR.......................................... 112
276,280,288,294,300,302,308,358,360,372 EXHAUST GAS PRESSURE SENSOR ......................... 110
BLOWER MOTOR .................................................. 182,188 EXHAUST GAS TEMPERATURE SENSOR .................. 108
BLOWER RELAY .......................................... 27,29,182,188 F
Bluetooth UNIT............................................................... 332 FAN CONTROL MODULE................................................ 56
BONNET LATCH SWITCH............................................. 258 FAN SWITCH ................................................................. 182
BOOST AIR TEMPERATURE SENSOR........................ 130 FILAMENT ...................................................................... 206
BOOST SENSOR........................................................... 108 FOG LIGHT .................................................................... 274
BRAKE FLUID LEVEL SENSOR ................................... 358 FOG LIGHT RELAY................................................... 31,274
BRAKE LIGHT................................................................ 284 FOG LIGHT SWITCH ..................................................... 274
BRAKE SWITCH ..................................................... 284,352 FRONT CENTER SPEAKER.......................................... 328
BUCKLE SWITCH.......................................................... 200 FRONT COMBINATION LIGHT........................ 264,272,276
C FRONT DOOR LATCH AND LOCK ACTUATOR..........224,250
CABIN TEMPERATURE SENSOR ................................ 190 FRONT DOOR SPEAKER ...................................... 316,328
CAMSHAFT POSITION SENSOR ..................... 92,106,120 FRONT FOG LIGHT ....................................................... 274
CARGO COMPARTMENT LIGHT.................................. 270 FRONT FOG LIGHT RELAY ..................................... 31,274
CARGO COMPARTMENT LIGHT SWITCH................... 270 FRONT OUTER HANDLE .............................................. 238
CENTER SPEAKER FRONT TILT MOTOR..................................................... 218
(FRONT)...................................................................... 328 FRONT TURN LIGHT..................................................... 276
(REAR) ........................................................................ 330 FUEL GAUGE SENDER UNIT ....................................... 346
CHECK CONNECTOR.............................................. 29,102 FUEL INJECTOR......................................... 84,110,128,150
CLIMATE CONTROL UNIT ..................................... 182,188 FUEL INJECTOR RELAY ................................... 27,116,134
CLOCK SPRING ................................. 76,172,200,298,316, FUEL PRESSURE SENSOR ........................... 108,122,148
322,332,360,362,366 FUEL PUMP CONTROL MODULE .................................. 58
CLOCK SWITCH..................................................... 364,368 FUEL PUMP RELAY............................................... 27,58,60
CLUTCH PEDAL POSITION SWITCH................96,112,130 FUEL PUMP RESISTOR.................................................. 60
COIL ANTENNA............................................................. 256 FUEL PUMP SPEED CONTROL RELAY.................... 27,60
COMBINATION LIGHT..................................... 264,272,276 FUEL PUMP UNIT....................................................... 58,60
COMMON CONNECTOR LIST........................................ 34 FUEL TEMPERATURE SENSOR .................................. 104
CONDENSER ......................................................... 206,284 FUSE BOX .................................................................. 26,28
COOLING FAN MOTOR .................................................. 56 G
CRANKSHAFT POSITION SENSOR.......... 92,106,120,138 GENERAL INFORMATION................................................. 4
CRASH ZONE SENSOR................................................ 204 GENERATOR .............................................................. 62,66
CRUISE CONTROL SWITCH .......................................... 76 GLOVE COMPARTMENT LIGHT................................... 296
CURRENT SENSOR...................................................... 156 GLOW PLUG .................................................................... 98
CURTAIN AIR BAG MODULE........................................ 202 GLOW PLUG RELAY .................................................. 33,98
GROUND POINT.............................................................. 46
GUIDE BLADE ACTUATOR POSITION SENSOR......... 112
376
ALPHABETICAL INDEX
H O
HAZARD WARNING SWITCH........................................276 OCCUPANCY SENSOR ................................................ 354
HEADLIGHT ...................................................................264 OIL CONTROL VALVE ....................................... 90,124,136
HEADLIGHT CLEANER MOTOR ...................................308 OIL PRESSURE SWITCH................................ 148,168,346
HEADLIGHT CLEANER RELAY ...........................27,33,308 OUTER HANDLE ........................................................... 238
HEADLIGHT LEVELING ACTUATOR ............................290 P
HEADLIGHT RELAY.............................................27,29,262 PARKING BRAKE SWITCH ........................................... 358
HEATER CORE TEMPERATURE SENSOR ..................192 PARKING LIGHT............................................................ 272
HIGH-MOUNT BRAKE LIGHT........................................284 PASSENGER-SIDE AIR BAG MODULE........................ 200
HO2S ..................................................................82,124,142 PASSENGER-SIDE AIR MIX ACTUATOR..................... 192
HORN .............................................................................360 PASSENGER-SIDE BUCKLE SWITCH ......................... 200
HORN RELAY.......................................................27,29,360 PASSENGER-SIDE CURTAIN AIR BAG MODULE ....... 202
HORN SWITCH ..............................................................360 PASSENGER-SIDE PRE-TENSIONER SEAT BELT ..... 202
I PASSENGER-SIDE SIDE AIR BAG MODULE .............. 202
IG1 RELAY......................................................................340 PASSENGER-SIDE SIDE AIR BAG SENSOR .............. 204
IG2 RELAY......................................................................342 PCM ...............................................................78,98,116,134
IGNITION COIL...................................................88,126,144 POWER BRAKE UNIT VACUUM SENSOR................... 156
IGNITION RELAY ........................................................33,64 POWER MOS FET......................................................... 188
IGNITION SWITCH.........................................................336 POWER OUTER MIRROR............................................. 214
ILLUMINATION POWER OUTER MIRROR SWITCH ............................. 214
AFS OFF SWITCH.......................................................298 POWER SEAT SWITCH ................................................ 218
CONSOLE INDIRECT..................................................296 POWER WINDOW MAIN SWITCH................................ 208
CRUISE CONTROL SWITCH ......................................298 POWER WINDOW MOTOR........................................... 210
DSC OFF SWITCH ......................................................298 POWER WINDOW RELAY ............................................ 340
HAZARD WARNING SWITCH .....................................296 POWER WINDOW SUBSWITCH .................................. 212
IGNITION KEY .............................................................294 PRE-TENSIONER SEAT BELT ...................................... 202
i-stop OFF SWITCH .....................................................298 PURGE SOLENOID VALVE ................................80,118,136
POWER WINDOW SWITCH INDIRECT......................288 PUSH BUTTON START ................................................. 234
PUSH BUTTON START ...............................................294
SELECTOR ..................................................................298
R
STEERING SHIFT SWITCH ........................................298 RAIN SENSOR........................................................ 268,302
STEERING SWITCH....................................................298 REAR CENTER SPEAKER............................................ 330
VANITY MIRROR .........................................................288 REAR DOOR LATCH AND LOCK ACTUATOR ...... 224,250
INPUT/TURBINE SPEED SENSOR ...............................168 REAR DOOR SPEAKER......................................... 316,328
INSTRUMENT CLUSTER...............................................344 REAR SPEAKER ........................................................... 328
INTAKE AIR TEMPERATURE SENSOR ..........108,136,146 REAR TILT MOTOR ....................................................... 218
INTAKE CAMSHAFT POSITION SENSOR ....................138 REAR TURN LIGHT....................................................... 278
INTAKE SHUTTER VALVE .............................................104 REAR WINDOW DEFROSTER RELAY............... 27,29,206
INTERIOR LIGHT ...........................................................286 REAR WIPER AND WASHER SWITCH ........................ 306
INTERMEDIATE SENSOR .............................................164 REAR WIPER MOTOR .................................................. 304
i-stop OFF SWITCH........................................................156 RECLINER MOTOR....................................................... 218
K REFRIGERANT PRESSURE SENSOR........... 184,190,192
KEY INTERLOCK SOLENOID........................................178 REFRIGERANT PRESSURE SWITCH................... 186,194
KEY REMINDER SWITCH ......................................222,246 REQUEST SWITCH....................................................... 240
KEYLESS ANTENNA .....................................................236 RESISTOR ..................................................................... 182
KEYLESS BEEPER ........................................................240 S
KEYLESS CONTROL MODULE.....................................230 SAS CONTROL MODULE ............................................. 198
KEYLESS RECEIVER .............................................220,236 SELECTOR LEVER COMPONENT................. 170,174,178
KNOCK SENSOR ...............................................82,122,140 SIDE AIR BAG MODULE ............................................... 202
SIDE AIR BAG SENSOR ............................................... 204
L SIDE TURN LIGHT ........................................................ 276
LAP PRE-TENSIONER SEAT BELT...............................204 SLIDER MOTOR ............................................................ 218
LICENSE PLATE LIGHT .................................................272 SOLAR RADIATION SENSOR....................................... 190
LIFTGATE LOCK ACTUATOR.................................228,254 SOLENOID VALVE......................................................... 166
LIFTGATE OPENER SWITCH.................................222,248 SPEAKER ...................................................................... 328
LIGHT SWITCH ..............................................................268 SPILL VALVE CONTROL SOLENOID VALVE
M (HIGH PRESSURE FUEL PUMP)........................ 128,148
MAGNETIC CLUTCH .....................................................196 STARTER ............................................................... 68,70,74
MAIN RELAY ....................................... 27,29,78,98,116,134 STARTER CUT RELAY .................................................... 72
MANIFOLD ABSOLUTE PRESSURE SENSOR .......... 90,130,136 STARTER INTERLOCK SWITCH .................................... 72
MAP LIGHT.....................................................................286 STARTER RELAY ........................................ 27,29,68,70,74
STEERING ANGLE SENSOR........................................ 300
MASS AIR FLOW SENSOR ..........................................146
STEERING LOCK UNIT................................................. 232
MASS AIR FLOW/
INTAKE AIR TEMPERATURE SENSOR ......... 84,100,118 STEERING SHIFT SWITCH .......................................... 172
STEERING SWITCH.......................... 316,322,332,362,366
MICROPHONE ...............................................................334
SUCTION CONTROL VALVE ........................................ 102
MULTI INFORMATION DISPLAY.............................362,366
SUNROOF MOTOR ....................................................... 260
N SUNROOF RELAY......................................................... 260
NEUTRAL SWITCH ............................................ 96,112,130 SUNROOF SWITCH ...................................................... 260
SWIVEL ACTUATOR ..................................................... 290
377
Mazda3,Mazda3 MPS Wiring Diagram (5866-1A-11H)
ALPHABETICAL INDEX
T
TAILLIGHT ..................................................................... 272
TCM......................................................................... 162,174
THROTTLE BODY ............................................. 86,122,140
TILT MOTOR.................................................................. 218
TNS RELAY.......................................................... 27,29,272
TRANSAXLE CASE ....................................................... 166
TRANSAXLE FLUID TEMPERATURE SENSOR .......... 166
TRANSAXLE RANGE SWITCH ................................ 68,164
TRIPMETER SWITCH ................................................... 346
TRUNK COMPARTMENT LIGHT .................................. 270
TRUNK COMPARTMENT LIGHT SWITCH ................... 270
TRUNK LID LATCH AND RELEASE ACTUATOR ....... 228,254
TRUNK LID OPENER SWITCH .............................. 222,248
TURN LIGHT
(FRONT)...................................................................... 276
(REAR) ........................................................................ 278
TURN SWITCH .............................................................. 276
TWEETER............................................................... 316,328
U
USB PORT ........................................................ 316-2,330-2
USB ADAPTER ................................................. 316-2,330-2
V
VARIABLE BOOST CONTROL SOLENOID VALVE ...... 100
VARIABLE INTAKE AIR SOLENOID VALVE.................... 80
VARIABLE SWIRL SOLENOID VALVE .......................... 122
VARIABLE TUMBLE SOLENOID VALVE......................... 80
VEHICLE IDENTIFICATION NUMBERS (VIN) .................. 3
VEHICLE SPEED SENSOR........................................... 164
W
WASHER FLUID-LEVEL SENSOR................................ 350
WASHER MOTOR ......................................................... 304
WASTEGATE CONTROL SOLENOID VALVE................118
WINDSHIELD WIPER AND WASHER SWITCH............ 306
WINDSHIELD WIPER MOTOR...................................... 302
WINDSHIELD WIPER RELAY ....................................... 342
WIPER AND WASHER SWITCH ................................... 306
WIPER MOTOR
(WINDSHIELD)............................................................ 302
(REAR) ........................................................................ 304
WIPER RELAY ............................................................... 342
WIRING COLOR CODE..................................................... 9