847680
Product identifier
Trade name : OPTIPHEN HD
EHSProductSafety@ashland.com
GHS Classification
Eye irritation : Category 2A
1 / 14
Page: 2
847680
Other hazards
None known.
Hazardous components
Chemical Name CAS-No. Classification Concentration (%)
1,2-Hexanediol 6920-22-5 Eye Irrit. 2A; H319 100.00
Most important symptoms : Signs and symptoms of exposure to this material through
and effects, both acute and breathing, swallowing, and/or passage of the material through
delayed the skin may include:
irritation (nose, throat, airways)
2 / 14
Page: 3
847680
Suitable extinguishing media : Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Water spray
Foam
Carbon dioxide (CO2)
Dry chemical
Specific hazards during : If product is heated above its flash point it will produce vapors
firefighting sufficient to support combustion. Vapors are heavier than air
and may travel along the ground and be ignited by heat, pilot
lights, other flames and ignition sources at locations near the
point of release.
Do not allow run-off from fire fighting to enter drains or water
courses.
Specific extinguishing :
methods
Special protective equipment : In the event of fire, wear self-contained breathing apparatus.
for firefighters
3 / 14
Page: 4
847680
Methods and materials for : Soak up with inert absorbent material (e.g. sand, silica gel,
containment and cleaning up acid binder, universal binder, sawdust).
Keep in suitable, closed containers for disposal.
Other information : Comply with all applicable federal, state, and local regulations.
Conditions for safe storage : Keep container tightly closed in a dry and well-ventilated
place.
Electrical installations / working materials must comply with
the technological safety standards.
Eye protection : Wear chemical splash goggles when there is the potential for
exposure of the eyes to liquid, vapor or mist.
4 / 14
Page: 5
847680
impervious clothing
Safety shoes
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Wear resistant gloves (consult your safety equipment
supplier).
Hygiene measures : Wash hands before breaks and at the end of workday.
When using do not eat or drink.
When using do not smoke.
pH : No data available
Solubility(ies)
5 / 14
Page: 6
847680
Viscosity
Viscosity, dynamic : 148 mPa.s (11 °C)
Hazardous decomposition
products No hazardous decomposition products are known.
Acute toxicity
Not classified based on available information.
Components:
1,2-Hexanediol:
Acute oral toxicity : LD 50 (Rat, female): > 5,339 mg/kg
6 / 14
Page: 7
847680
Skin corrosion/irritation
Not classified based on available information.
Product:
Remarks: May cause skin irritation in susceptible persons.
Components:
1,2-Hexanediol:
Species: Rabbit
Method: OECD Test Guideline 404
Components:
1,2-Hexanediol:
Species: Rabbit
Result: Irritation to eyes, reversing after 7 to 21 days
7 / 14
Page: 8
847680
Carcinogenicity
Not classified based on available information.
Reproductive toxicity
Not classified based on available information.
STOT - single exposure
Not classified based on available information.
STOT - repeated exposure
Not classified based on available information.
Aspiration toxicity
Not classified based on available information.
Further information
Product:
Remarks: No data available
Carcinogenicity:
IARC No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
8 / 14
Page: 9
847680
Ecotoxicity
Components:
1,2-Hexanediol:
Toxicity to fish : LC 50 (Oncorhynchus mykiss (rainbow trout)): > 1,000 mg/l
Exposure time: 96 h
Test Type: static test
Remarks: Information given is based on data obtained from
similar substances.
Toxicity to daphnia and other : EC 50 (Daphnia magna (Water flea)): > 110 mg/l
aquatic invertebrates Exposure time: 48 h
Test Type: static test
Method: OECD Test Guideline 202
GLP: yes
9 / 14
Page: 10
847680
Bioaccumulative potential
Components:
1,2-Hexanediol:
Partition coefficient: n- : log Pow: 0.58 (25 °C)
octanol/water pH: 7.09
Mobility in soil
Components:
No data available
Other adverse effects
No data available
Product:
Additional ecological : No data available
information
Components:
Disposal methods
General advice : Do not dispose of waste into sewer.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Send to a licensed waste management company.
10 / 14
Page: 11
847680
MX_DG
Not dangerous goods
TDG_INWT_C
Not dangerous goods
TDG_RAIL_C
Not dangerous goods
TDG_ROAD_C
Not dangerous goods
CFR_RAIL_C
Not dangerous goods
Marine pollutant no
11 / 14
Page: 12
847680
Dangerous goods descriptions (if indicated above) may not reflect quantity, end-use or region-specific
exceptions that can be applied. Consult shipping documents for descriptions that are specific to the
shipment.
SARA 313 : This material does not contain any chemical components with
Component(s)SARA 313 known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
California Prop 65 This product does not contain any chemicals known to State
of California to cause cancer, birth defects, or any other
reproductive harm.
The components of this product are reported in the following inventories:
TSCA : On TSCA Inventory
Inventories
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL
(Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TSCA (USA)
12 / 14
Page: 13
847680
Further information
Revision Date: 11/07/2016
HEALTH 2
1
Instability
Health
1 0 FLAMMABILITY 1
PHYSICAL HAZARD 0
0 = not significant, 1 =Slight,
Special hazard. 2 = Moderate, 3 = High
4 = Extreme, * = Chronic
The information accumulated herein is believed to be accurate but is not warranted to be whether
originating with the company or not. Recipients are advised to confirm in advance of need that the
information is current, applicable, and suitable to their circumstances. This SDS has been prepared by
Ashland's Environmental Health and Safety Department (1-800-325-3751).
List of abbreviations and acronyms that could be, but not necessarily are, used in this safety data
sheet :
ACGIH : American Conference of Industrial Hygienists
BEI : Biological Exposure Index
CAS : Chemical Abstracts Service (Division of the American Chemical Society).
13 / 14
Page: 14
847680
14 / 14