GENERAL FEATURES
Fully equipped charging station for management of AC and DC conductive
charging of Electric Vehicles. Juice Station charges two vehicles at the same
time with high speed (up to 50 kW).
Real time communication with the remote center EMM Platform via GPRS/UMTS for the
monitoring and controlling of the charging station
User interface to support the customer in the charging sessions and to provide
charging status (kWh and timing)
Data acquisition and transmission for each charging process and all diagnostic alarms
Able to be integrated into Smart Charging Logics thanks to specific algorithm and advanced
smart metering functions (real-time modulation of charging process by the EMM Platform)
The DC outputs allow just one charging at the same time, while the AC charging
can be active together with DC charging
Users instructions
The access to charging process is performed automatically on behalf of the customer,
according to the following steps:
Intended use
PUBLIC PRIVATE
Charging station installed in a public area Charging station installed in a private area,
or in a private area with public access, available to a limited group of users,
open to all type of customers. for private charging only.
POWER SUPPLY:
1.00JUDA0503ECEU-
Enel X JuicePUMP 50 Trio 43
SLTCA4-000 Trio 43
1.00JUDA0503ECEU-
Enel X JuicePUMP 50 Trio S22
SMSCA4-000
1.00JUDD0503ECEU-
Enel X JuicePUMP 50 Duo
SYTCA4-000
During the installation, pay attention to indications and requirements for the construction
of the plinth (reported in the installation guide), based on wind speed and ground surfaces.
DC output
RCD–TypeB30mA–125A
MCB – D80
AC output
RCD–TypeB30mA–80A
MCB – D80
REFERENCE STANDARDS. TECHNICAL CHARACTERISTICS
IEC 61851-21-2
Electric vehicle conductive charging system – Part 21-2: Electric vehicle
requirements for conductive connection to an AC/DC supply – EMC requirements
for o board electric vehicle charging systems.
IEC 62196-1
Plugs, socket-outlets, vehicle couplers and vehicle inlets – Conductive charging
of electric vehicles – Part 1: General requirements.
IEC 62196-2
Plugs, socket-outlets, vehicle couplers and vehicle inlets – Conductive charging
of electric vehicles – Part 2: Dimensional compatibility and interchangeability requirements
for AC pin and contact-tube accessories.
IEC 62196-3
Plugs, socket-outlets, vehicle couplers and vehicle inlets – Conductive charging
of electric
vehicles – Part 3: Dimensional compatibility and interchangeability requirements
for DC and AC/DC pin and contact-tube vehicle coupler.
COMMUNICATION CHARACTERISTICS
The communication with remote center backend is based either on the OCPP 1.6 SOAP,
or Enel Proprietary protocol when the backend is the EMM platform.