Química Delta
S.A. de C.V.
1. PRODUCT AND COMPANY IDENTIFICATION
MSDS: Therminol 55
Sinonyms:
Heat transfer fluid
supplier:
Química Delta S.A. de C.V.
Teoloyucan – Huehuetoca No. 259
Sta. Ma. Caliacac, Teoloyucan
phone: 58-99-94-00
Emergency phone: 01-800-00-214-00
2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
Acute toxicity, Aspiration (Category 1)
Skin irritation (Category 3)
Hazard statement(s)
H304 May be fatal if swallowed and enters airways.
H316 Causes mild skin irritation.
Precautionary statement(s)
P301 + P310 - IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician
P331 - Do NOT induce vomiting
Storage
P405 - Store locked up
Disposal
P501 - Dispose of contents/ container to an approved waste disposal plant
Inhalation High processing temperatures may cause release of vapors that irritate if inhaled.
Skin Causes mild skin irritation. Fully reversible in 7 days or less.
Eyes Causes mild skin irritation. Fully reversible in 7 days or less.
Ingestion Aspiration hazard. May be fatal if swallowed and enters pathways respiratory.
1
Chronic Effects Repeated exposure may cause skin dryness or cracking skin.
Danger to the environment See section 12: ECOLOGICAL INFORMATION.
Other information
Other hazards
Hot liquid can cause severe burns.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Chemical name No. CAS Concentration [%]
If inhaled
Remove to fresh air. If not breathing give artificial respiration. If breathing is difficult, give oxygen. Call a physician. Keep victim
warm and quiet. Loosen tight clothing such as a collar, tie, belt or waistband. Maintain an open airway. Persons who have
inhaled vapors or smoke fumes have to be put under medical observation for at least 48 hours, due to the delayed
appearance of poisoning.
If swallowed
If swallowed, rinse mouth with water (only if the person is conscious). Call a physician or poison control center immediately.
Remove victim to fresh air and keep at rest in a position comfortable for breathing. Loosen tight clothing such as a collar, tie,
belt or waistband. Never give anything by mouth to an unconscious person. Do NOT induce vomiting unless directed to do so
by a physician. If vomiting occurs spontaneously, keep head below hips to prevent aspiration. Maintain an open airway. If not
breathing, give artificial respiration. If breathing is difficult, give oxygen.
Notes to physician
Treat symptomatically. Contact with hot material: Treat for thermal burns. Persons who have inhaled vapors or smoke fumes
have to be put under medical observation for at least 48 hours, due to the delayed appearance of poisoning.
5. FIREFIGHTING MEASURES
Conditions of flammability
This product is not classified as a transfer fluid heat fire resistant. Caution should beto avoid ignition sources.
2
Hazardous combustion products
Fire will produce dense black acrid smoke. Thermal decomposition can lead to release of toxic and corrosive gases/vapors.
Decomposition products: Carbon monoxide, carbon dioxide and unburned hydrocarbons (smoke). Container may explode in
heat of fire. Runoff may pollute waterways.
Environmental precautions
Prevent further leakage or spillage if safe to do so. Clean up spill immediately. Try to prevent the material from entering drains
or water courses.
Containment methods.
Prevent further leakage or spillage if you can do so safely. Dike to collect large liquid spills size.
Engineering measures
Good general ventilation should be sufficient to control worker exposure to airborne contaminants. Apply technical measures
to comply with the occupational exposure limits. If this product contains ingredients with exposure limits, personal, workplace
atmosphere or biological monitoring may be required to determine the effectiveness of the ventilation or other control
measures and/or the necessity to use respiratory protective equipment.
Respiratory protection
Use a properly fitted, particulate filter respirator complying with an approved standard if a risk assessment indicates this is
necessary Respirator selection must be based on known or anticipated exposure levels, the hazards of the product and the
safe working limits of the selected respirator. If exposure limits are exceeded or irritation is experienced, use respiratory
protection must be approved by the NIOSH / MSHA. When the concentration of airborne contaminants is high, the use of it
may be necessary.
3
Hand protection
Handle with gloves. Gloves must be inspected prior to use .Use the correct removal technique gloves (without touching glove's
outer surface) to avoid skin contact with this product. Discard gloves contaminated after use in accordance with applicable
laws and good laboratory practices laws. Wash and dry hands.
Eye protection
Face shield and safety glasses. Use equipment eye protection tested and approved under the rules governmental
authorities, such as NIOSH (U.S.) or EN 166 (EU).
Hygiene measures
Handle in accordance with good industrial hygiene and safety practice.
Density 868 kg / m³ 25 ° C
4
10. STABILITY AND REACTIVITY
Chemical stability
Stable under recommended storage and handling conditions (see section 7).
Incompatible products
Strong oxidizing agents.
Conditions to avoid
This product is not classified as a transfer fluid heat fire resistant. Caution should be
to avoid ignition sources. Heating in air.
Inhalation High processing temperatures may cause release of vapors irritating if inhaled.
Eyes May cause slight irritation. Fully reversible in 7 days or less.
Skin Causes mild skin irritation. Fully reversible in 7 days or less.
Ingestion Aspiration hazard. May be fatal if swallowed and enters airways.
Acute toxicity
DERIVADOS C14-30- > 15800 mg/kg ( Rat ) > 7940 mg/kg ( Rabbit ) No data available
ALQUILAROMATICOS
Chronic Toxicity
Repeated exposure may cause skin dryness or cracking skin.
Carcinogenicity
This product contains no carcinogen or potential carcinogen as classified by OSHA, IARC or NTP.
Sensitization
No caused sensitization in laboratory animals: Guinea Pigs.
Aspiration hazard
Liquid hydrocarbons of low viscosity. Potential for aspiration if swallowed. Aspiration into lungs can produce severe lung
damage.
5
12. ECOLOGICAL INFORMATION
Acute aquatic toxicity
EL50 method of the water accommodated fraction (W.A.F.).
Bioaccumulative potential
Product has a low potential to bioconcentrate.
Toxicity
Chemical name log Pow
Bioaccumulative potential:
No data available
Mobility in soil
No data available
Contaminated packaging
Empty containers should be taken to an approved waste management for recycling or disposal.
Product Offer surplus and non-recyclable solutions to a licensed disposal company.
Other Information
This product meets the criteria for synthetic oil under the standards of the U.S. EPA for the management
Used Oil (40 CFR 279). These rules govern recycling and disposal instead of 40 CFR 260-272 residues
Federal hazardous program in states that have adopted these used oil regulations. Consult your attorney or appropriate
regulatory official to ensure that these standards have been adopted in your state.
Recycle or burn under the applicable rules. It should not be dumped, spilled, rinsed or washed product so that enters sewers
or public waterways.
6
14. TRANSPORT INFORMATION
DOT (US)
Not dangerous goods
IMDG
Not dangerous goods
IATA
Not dangerous goods
CERCLA
This material, as supplied, does not contain any substances regulated as hazardous substances under the Act
Response, Compensation, and Comprehensive Environmental Liability (CERCLA for its acronym in English) (40 CFR 302) or
Amendments and Reauthorization Act Superfund (SARA) (40 CFR 355). There may be reporting requirements
specific local, regional or state level pertaining to releases of this material.
International regulations
International Inventories
TSCA comply
DSL/NDSL comply
EINECS/ELINCS comply
ENCS (Japan) comply
IECSC comply
KECL comply
PICCS comply
AICS comply
7
16. OTHER INFORMATION
Clasificacion HMIS
Health hazard: 1
Flammability: 1
Physical hazards: 0
Clasificación NFPA
Peligro para la salud: 1
Fuego: 1
Peligro de Reactividad: 0
Further information
The information above is based on available data which is believed to be correct. However, no guarantee merchantability,
fitness for any purpose or any other warranty is expressed or implied regarding the accuracy of this information, the results
obtained from the use, risks related to the use of materials or any other use not infringe any patent, since the information
contained herein will be applied under conditions beyond our control and with which we may be unfamiliar, we assume no
liability resulting from its use. this information is set on the conditions that the person receiving it shall make their own
determinations under the suitability of the material for your particular job.