HYDROQUINONE IN URINE
BY HARRY D. BAERNSTEIN
(From the Industrial Hygiene ResearchLaboratory, National Institute of Health,
Bethesda, Maryland)
14 CM. o
0-c
-
-
V
END VIEW
17 CM.
FIG. 1. Apparatus for the hydrolysis and extraction of urine and concentration
of the extract. The letters represent the respective positions.
titatively extracted and the extract does not need further washing. Sulfite
has the advantage over bicarbonate in furnishing SOZ for reduction of any
quinones which may have formed.
The urine is cooled and the apparatus is assembled for extraction as in B,
Fig. 1. The glass wool plug on the funnel tube aids in the separation of
ether from t,he urine. A few small pieces of pumice (40 mesh) are added to
the ether boiler to prevent bumping. The water bath is kept at 55” and
extraction is continued for 4 hours.
The rate of extraction may be considerably increased by wrapping a strip
of lead (not shown) in a spiral around the lower third of the funnel tube.
This facilitates saturation of each drop of ether which passes through the
Analysis of Extract
Separation of Catechol-After extraction and concentration of the extract,
catechol is separated as the lead salt at pH 6.5.
A battery of small sintered glass funnels, of medium porosity,2 mounted
for suction filtration is used for the separations to follow.
About 2.0 ml. of 0.1 M lead.acetate solution are placed in one of the fun-
nels. 3 ml. of 2 M pyridine-acetate buffer, pH 6.5, are added to the con-
centrated extract in the ether boiler and this is rinsed into the funnel with
a few ml. of water. The mixture is stirred and catechol is immediately
and quantitatively precipitated as a lead salt,. After a minute it settles
out, and is filtered with suction. The filtrate containing phenol and
hydroquinone is received in a 100 ml. wide mouth, screw cap bottle.3 The
* Pyrex, catalogue No. 33730.
3 A. H. Thomas 4 ounce bottle, No. 6284; plastic caps, No. 2849. Remove the cork
liner and pour in a layer of paraffin to protect the cap from bromine fumes.
688 DETERMINATION OF URINARY PHESOLS
Mg,catechol
= cs- B)x N x llO.l
12
S = ml. of sulfite used for the sample, B = ml. of sulfite used for the
blank, N = the normality of the sulfite.
The blank for benzene-exposed animals is a sample of urine taken before
exposure and treated exactly as the sample after exposure is treated.
For other purposes 25 ml. of water may be substituted for urine. These
blanks are usually very small and for some purposes entirely negligible.
Determination of Phenol-The filtrate from lead catecholate is acidified
with 1.0 ml. of concentrated sulfuric acid and 5.0 ml. of 0.2 N bromate-
bromide mixture are added. This is sufficient to brominate about 8.0 mg.
4 Before the funnels are used again they must be washed with acid and water.
H. D. BAERNSTEIN 689
of phenol under these conditions. A small vial containing about 1.0 gm.
of potassium iodide is placed in the bottle and the cap is screwed on.5
After about 30 minutes, when bromination is complete, the vial is tipped
over and the excess bromine liberates an equivalent quantity of iodine from
the iodide. The bottle is opened and the vial removed and washed care-
fully with alcohol, the washings being added to the mixture in the bottle.
Alcohol is used in order to bring any precipitated iodine into solution and
to prevent the precipitation of oxidized hydroquinone in the next step of
the analysis.
The iodine is titrated with 0.2 N sulfite solution, the electrode being
used as indicator.
+- 0TN
\--.- +
I I -O-
0 +
I- 0 1
0
1, l’, 1”-(2,5-Dihydro-3-hydroxy-2,5-dioxo-p-phenylene)-
tripyridinium bet&e diiodide
The watch-glass is rinsed with alcohol and the mixture allowed to stand for
1 hour, after which it is titrated with sulfite.
During the oxidation of hydroquinone a red precipitate sometimes ap-
pears. This must be brought back into solution by the addition of a few
ml. of alcohol. If it is allowed to remain separated, the oxidation will be
incomplete and the end-point in the titration of excessiodine will be uncer-
tain, since the precipitate carries down free iodine.
Calculation-
(B - S) X N X 110.1
Mg. hydroquinone =
10
FIG. 2. Excretion of phenol (Curve P), hydroquinone (Curve H), and catechol!
(Curve C) by a rabbit during the daily subcutaneous injection of 2 ml. of benzene in
2 ml. of olive oil.
The count of white blood cells declined from 11,000 on the 2nd day to less
than 1000 on the 17th.
Further studies are in progress.
DISCUSSION
SUMMARY
BIBLIOGRAPHY
1. Nencki, M., and Giacosa, P., Z. physiol. Chem., 4, 325, 339 (1880).
2. Koppesehaar, W., Z. anal. Chem., 15,233 (1876).
3. Baernstein, H. D., J. Am. Chem. SOL, 67, 1437 (1945).
THE DETERMINATION OF
CATECHOL, PHENOL, AND
HYDROQUINONE IN URINE
Harry D. Baernstein
J. Biol. Chem. 1945, 161:685-692.
Alerts:
• When this article is cited
• When a correction for this article is posted