[3] Playing audio files from the SD D - When pairing has occurred the LED [5] Bluetooth speaker-phone:
ooth speaker-phone: While
Instructions card (7): Using a computer, load MP3, (3) will shift from rapid RED-BLUE to paired, the S10 will sound a 4-note trill MP4, WMA or WAV files onto micro SD blinking BLUE when idle and solid blue when an incoming phone call occurs, then Thank you for purchasing the S10 bass card. Push card straight into slot, contacts when active. S10 is now paired with the plays the phone’s ring tone. Calls may be Xpansion speaker. Please read over down until card clicks into place (7). Push phone. LED will blink about 2 times per answered or dropped by momentarily these instructions for best results. again to remove. Slide Power switch (2) second if the phone’s Bluetooth is turned pressing volume control (1) straight in. to MP3 mode position. . Momentarily rock off or the phone moves out of range. Make sure the microphone (4) is facing Important! Please fit the USB plug to a the volume control to + jump to next file or you and the S10 is close to you, or pick Some phones have a “make powered USB jack and charge the – previous file. Rock and hold volume discoverable” mode. Try pairing again the speaker up and talk into the MIC. speaker before using it. control (1) in + or – direction for with phone in discoverable mode if pairing TIPS comfortable level. LED (3) blinks GREEN attempts are unsuccessful. during playback. If card is removed or Remove the SD card from the S10 and use NOTE: Every S10 has a unique MAC external programming methods to edit the power is cut, the S10 will start at the last number, and must be paired individually card content. The files on the SD card file played when power or card is with the phone for it to be recognized. cannot be reached by a computer via the restored. USB Y-cable. E - When paired, play a music file and NOTE: Press the file select button (1) in adjust S10 local volume by rocking and Remove the slip sheet from the bottom of to switch between AUX input (6) and SD holding volume (1) in + position until the speaker. The bare silicone rubber foot (7) card playback. sound level is at maximum. Beep tones will be better able to grab onto smooth or will be heard when S10 reaches max textured surfaces. Clean the foot with a volume. Use phone’s media volume damp cloth when needed to restore its control for the main level control. Use the gripping abilities. phone’s music player software and For better bass response, place the S10 on graphical interface to choose music files surfaces that have a bit of flexibility. Larger [1] Charging (8): Plug the USB (5) and desired locations within each file. wooden, metal or plastic tables or cabinets charge / audio cable into an energized Once the S10 is on the phone’s pair list, of thin or medium thickness are a good USB jack. Then plug the MINI USB plug future pairing events should only require start. Suspended wooden floors can work into the S-10 speaker. LED (3) will glow . too. Ice chest lids work well. Auto RED while charging and go dark when [4] Playing audio files through the steps A and B. Older phones may require more steps to re-pair. dashboards, trunk lids, hoods and pick-up battery is full. Maximum charge time is 2 Bluetooth link: For the first link event truck tail gates can also work well. hours. make sure S10 power is off. Have source, Some phone’s apps, such as music . such as a mobile phone, ready to launch players, can be controlled by the S10. Tap a prospective surface with your finger NOTE: During use, the LED (3) will blink and listen for some resonance or “give.” its Bluetooth mode (BT is off but ready to The file selector (1) may be rocked to RED when battery needs recharging. jump through files on a playlist, just as Avoid dead non-resonant surfaces. Avoid . start). Then: with file selection from SD card playback. heavy marble or laminate type tables. Any [2] Playing analog audio files through A - Put the S10 in Bluetooth mode (2). Caution: Momentarily pressing the very rigid or very soft surface will not AUX input (6): Start audio player and LED (3) will show some rapid blue blinks, provide good bass developement. bring its volume up to middle level. Fit Y- then a stream of rapid RED-BLUE blinks. volume control IN (1) may assert a last cable’s stereo mini plug to audio player’s S10 is ready to pair. phone number re-dial function. Press Avoid dropping the speaker. The protruding headphone or line output mini jack. Fit Y- B - Launch mobile phone’s Bluetooth again to hang up. control knobs can be damaged if the cable’s mini USB plug to S10 speaker. NOTE: Analog audio input on the Y-cable speaker hits a hard surface. Keep away mode and scan for new devices. Make sure there is no micro SD card in from high humidity, or extreme heat or cold. C - Phone should scan and display a is muted when the S10 is in Bluetooth slot (7). Slide Power switch (2) to MP3 Avoid blocking speaker grille. Do not list of nearby Bluetooth devices. S10 mode. However, charging may be position. Rock and hold volume control dispose of in fire. Do not disassemble. should appear on the list. Select and pair asserted at any time using the Y-cable. (1) in + or – direction to adjust playback with the S10 shown on the list. Some The LED will glow RED AND GREEN or The S10 mixes two-channel stereo into a level. Then use volume control on music older phones might need a pairing PIN BLUE at the same time. Colors will mix to monophonic signal for the loudspeaker. No playing device to adjust level. number. If so, use “0000” as the PIN. form new hues, showing multiple modes; changes to your music files will occur, not to worry. except hearing them in mono. The Compact S10 gives you “big Formenti Feature Highlights speaker” sound by using the slight Specifications flexibility of tables and other surfaces as a Corporation® Extraordinary Sound Through Bass Xpansion Technology. Smooth midrange sounding board. The table’s large surface area can be transformed into an effective Supported music files: MP3, MP4, and WAV. 16 bit x 44 kHz WAV files OK. and high frequencies emanate from the woofer for satisfying bass response. Maximum Micro SD card size: 16 GB. top grille while bass vibrations are sent to Slower class 4 cards may be used. the table top through the silicone rubber foot on the bottom. Invite your larger Battery: Li-ion 3.7V 500 mA. tables or countertops to play along at the Run time: 2 – 10 hours depending on party! volume level. The S10 is compatible ompatible with iPhone, Bluetooth operating range: 10m, 30 feet. iPod, Android, MP3 players, etc. Bluetooth version employed: 2.21 Bluetooth Music Player – Play Files Charge voltage: 5 VDC, 0.5 A, via USB From Any Mobile PhoPhone Equipped With power. Bluetooth (supports popular music file formats,, or streaming sound sources). Size: 60 mm wide, 50mm high. .
IMPORTANT SAFETY INFORMATION Weight: 230 grams, about 8 oz.
Robust 3 Watt amplifier furnishes Do not disassemble or attempt to repair
satisfying volume in nearly any size room. this speaker. Recycle responsibly in Formenti Corporation accordance with local laws. Playback Time Time: 2 – 8 hours 542 C Via Estrada depending on volume level Laguna Woods, CA Voice: (520) 468-5885 Available In Eight Colors to meet all www.formentico.com fashion requirements requirements: Matte Black, Matte Red, Matte Blue, Oxide Silver Silver. Glossy finish colors: Gunmetal Gray Gray, Ceramic White (matches matches iPhone motif), Orange Sherbet and Turquoise!