Supports re
re--configurable antenna sharing capability enabling control of the internal RET system using
up to two separate RET compatible OEM radios
Electrical Specifications
Frequency Band, MHz 694–806 790–894 880–960 1695–1920 1920–2200 2490–2690
Gain, dBi 15.6 15.9 16.2 17.1 17.8 17.5
Beamwidth, Horizontal, degrees 72 70 65 60 61 65
Beamwidth, Vertical, degrees 9.7 8.8 8.3 7.7 7.0 5.8
Beam Tilt, degrees 2– 12 2– 12 2– 12 2– 12 2– 12 2– 12
USLS (First Lobe), dB 19 18 16 17 18 17
Front
Front--to
to--Back Ratio at 180°, dB 33 35 34 37 37 33
Isolation, Cross Polarization, dB 25 25 25 25 25 25
Isolation, Inter
Inter--band, dB 25 25 25 25 25 25
VSWR | Return Loss, dB 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0
PIM, 3rd Order, 2 x 20 W, dBc -150 -150 -150 -150 -150 -150
Input Power per Port at 50°C,
300 300 300 250 250 200
maximum, watts
Polarization ±45° ±45° ±45° ±45° ±45° ±45°
Impedance 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm
* CommScope
CommScope® ® supports NGMN recommendations on Base Station Antenna Standards (BASTA). To learn more about the benefits of BASTA, download the
whitepaper Time to Raise the Bar on BSAs.
Array Layout
page 1 of 4
September 30, 2019
©2019 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope.All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 23, 2019
RRV4-65C-R6
Port Configuration
General Specifications
Operating Frequency Band 1695 – 2690 MHz | 694 – 960 MHz
page 2 of 4
September 30, 2019
©2019 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope.All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 23, 2019
RRV4-65C-R6
Mechanical Specifications
RF Connector Quantity, total 12
RF Connector Quantity, low band 4
RF Connector Quantity, high band 8
RF Connector Interface 4.3-10 Female
Grounding Type RF connector inner conductor and body grounded to reflector and mounting bracket
Radiator Material Low loss circuit board
Radome Material Fiberglass, UV resistant
Reflector Material Aluminum
RF Connector Location Bottom
Wind Loading, frontal 215.4 lbf @ 150 km/h | 954.0 N @ 150 km/h
Wind Loading, lateral 331.0 N @ 150 km/h | 74.4 lbf @ 150 km/h
Wind Loading, maximum 1,235.0 N @ 150 km/h | 277.6 lbf @ 150 km/h
Wind Speed, maximum 241 km/h | 150 mph
Dimensions
Length 2438.0 mm | 96.0 in
Width 498.0 mm | 19.6 in
Depth 197.0 mm | 7.8 in
Net Weight, without mounting kit 46.3 kg | 102.1 lb
Packed Dimensions
Length 2630.0 mm | 103.5 in
Width 608.0 mm | 23.9 in
page 3 of 4
September 30, 2019
©2019 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope.All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 23, 2019
RRV4-65C-R6
Regulatory Compliance/Certifications
Agency Classification
RoHS 2011/65/EU Compliant by Exemption
ISO 9001:2015 Designed, manufactured and/or distributed under this quality management system
China RoHS SJ/T 11364-2014 Above Maximum Concentration Value (MCV)
Included Products
BSAMNT
BSAMNT--3 — Wide Profile Antenna Downtilt Mounting Kit for 2.4 - 4.5 in (60 - 115 mm) OD round members. Kit contains one scissor top
bracket set and one bottom bracket set.
BSAMNT
BSAMNT--M — Middle Downtilt Mounting Kit for Long Antennas for 2.4 - 4.5 in (60 - 115 mm) OD round members. Kit contains one
scissor bracket set.
* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance
page 4 of 4
September 30, 2019
©2019 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope.All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 23, 2019