Refer to the exhibit. If the show cdp neighbors command is issued on RTB, which devices will
appear in the output if all devices use the Cisco IOS and have CDP enabled?
RTA, RTC
RTA, RTC, Sw2
RTA, RTC, Sw1, Sw2, Sw3
RTA, RTC, Sw1, Sw2, Sw3, PC1, PC2
What is used by a routing protocol to determine the best path to include in the routing table?
4 Convergence time
Default distance
Metric
Type of router
5
Refer to the exhibit. R1 and R2 are configured with the commands that are displayed. All interfaces
are properly configured, but neither router is receiving routing updates. What two things can be done
to solve the problem? (Choose two.)
Configure the routing protocol on R1 for network 10.0.0.0.
Configure the routing protocol on R2 for network 10.0.0.0.
Configure the routing protocol on R1 for network 192.168.4.0.
Configure the routing protocol on R1 for network 192.168.2.0.
Configure the routing protocol on R2 for network 192.168.1.0.
Configure the routing protocol on R2 for network 192.168.3.0.
A small tire retailer requires a low-cost WAN connection to its headquarters in order to manage its
6 inventory and process customer sales in real time. Which WAN connection type is best suited to its
needs?
SONET
T3
T1
DSL
leased line
Refer to the exhibit. Router Left is unable to ping router Right. The show interfaces serial 0/0/0
command indicates that the interface is up but the line protocol is down on both routers. Which action
could be taken to establish connectivity between the two routers?
Configure S0/0/1 instead of S0/0/0 on router Right.
Enter the encapsulation hdlc command on router Right.
Contact the service provider to report that the circuit is down.
Contact the service provider to enable PPP on the WAN circuit.
Enter the no encapsulation ppp command on router Left S0/0/0.
A user reports being able to access the Internet but not being able to download e-mail from the mail
8 server at the ISP. What should the user check on the user workstation?
the POP3 and SMTP server settings in the e-mail application
the patch cable connections at the back of the workstation and at the wall plate
the DHCP settings in the operating system
the IP address, mask, and default gateway values
the NIC drivers
11
Refer to the exhibit. What could be two possible causes for the Serial0/0/0 interface status? (Choose
two.)
A Layer 3 issue exists.
The bandwidth is set too high.
An incorrect cable is being used.
A loopback address must be set.
The reliability setting is too low for the interface.
A defective serial interface cable was used.
12
Refer to the exhibit. Which subnet mask would accommodate the number of hosts shown for each
subnetwork with the least amount of IP addresses wasted?
255.255.0.0
255.255.255.192
255.255.255.224
255.255.255.240
255.255.255.248
Which combination of network address and subnet mask allows 62 hosts to be connected in a single
14 subnet?
Network address 10.1.1.4 Subnet mask 255.255.255.240
Network address 10.1.1.0 Subnet mask 255.255.255.252
Network address 10.1.1.0 Subnet mask 255.255.255.192
Network address 10.1.1.4 Subnet mask 255.255.255.248
15 What is the maximum unrepeated distance set by industry standards for UTP cable?
10 meters
75 meters
100 meters
325 meters
All contents copyright 1992-2010 Cisco Systems, Inc. Privacy Statement and Trademarks
Assessment System
Skip to Time Left | Skip to Navigation | Skip to Assessment Items
Take Assessment - DsmbISP Final Exam - CCNA Discovery: Working at a Small-to-Medium Business or ISP (Version 4.1)
Time Remaining:
18
Refer to the exhibit. A NOC technician at an ISP enters the command c:\ping 209.165.201.7. What
are two reasons to use this command? (Choose two.)
map the path to 209.165.201.7
test reachability to 209.165.201.7
locate connectivity problems along the route to 209.165.201.7
identify ISPs that interconnect the NOC and remote host with IP 209.165.201.7
measure the time that packets take to reach 209.165.201.7 and return to the
technician's workstation
1 Which AAA process requires users to prove their identity with a username and password to gain
9 access to a network?
accounting
authorization
authentication
acknowledgment
20 What routing protocol would be appropriate to use for exchanging routes between ISPs?
RIPv2
BGP
OSPF
EIGRP
2
1
Refer to the exhibit. A technician uses the SDM application to configure router R1. Which step
should be taken by the technician to enable the Fa0/0 interface on R1 to participate on the
connected local network?
Enable a DHCP server on the Fa0/0 LAN interface.
Configure the appropriate IP address on the Fa0/0 interface.
Configure IP addresses for the primary and secondary DNS server.
Configure the starting and ending IP addresses for the DHCP pool but exclude the Fa0/0 IP
address.
22
The show ip route command was executed on one of the routers shown in the graphic and the
following output was displayed:
Refer to the exhibit. The network administrator uses the command below to configure a default route
on RTB:
A ping issued from PC3 is successful to RTB. However, echo request packets arrive at PC1 but the
echo replies do not make it back to PC3. What will fix this problem?
RTA must be configured to forward packets to the 192.168.2.0 network.
The ip route command needs to be edited so that the next hop address is 10.1.1.5.
The ip route command needs to be edited so that the 192.168.2.1 address is the next hop
address.
The ip route command should be removed from the RTB router configuration.
Another default route should be configured on RTA with a next hop address of 10.1.1.6.
24
Refer to the exhibit. While configuring the serial interface of a router, the network administrator sees
the highlighted error message. What is the reason for this?
The serial interface is administratively down.
The serial interface is already configured with an IP address.
The network administrator has attempted to configure the serial interface with a
broadcast address.
The same IP address has been configured on another interface.
26 If the configuration register is currently set to 0x2102, what is the first action that a router will take
after the bootstrap program loads successfully?
load the IOS from flash
load the IOS from NVRAM
load the IOS from the TFTP server
load the startup configuration file from flash
load the startup configuration file from NVRAM
load the startup configuration file from the TFTP server
2 Which two services are required to enable a computer to receive dynamic IP addresses and access
7 the Internet using domain names? (Choose two.)
DNS
WINS
HTTP
DHCP
SMTP
28
Refer to the exhibit. Devices need to connect to the file server from remote networks. What method
should be used to provide the file server with an IP address to allow these connections?
static NAT
static PAT
dynamic NAT
dynamic PAT
2 A small company has contracted with its ISP for web hosting. Which two items would be included in
9 the SLA for this service? (Choose two.)
performance
web server cost
service availability
operating system on the web server
web server model and configuration
30 A network engineer is planning a new horizontal cable installation in an office building. What
advantage would UTP cable have over fiber optic cable for this installation?
lower installation costs
better protection from EMI
higher transmission speeds
longer unrepeated distance between endpoints
All contents copyright 1992-2010 Cisco Systems, Inc. Privacy Statement and Trademarks
Assessment System
46 A user is unable to connect to the Internet. The network administrator decides to use the top-down
troubleshooting approach. Which action should the administrator perform first?
Run the tracert command to identify the faulty device.
Check the patch cable connection from the PC to the wall.
Enter an IP address in the address bar of the web browser to determine if DNS has failed.
Run the ipconfig command to verify the IP address, subnet mask, and
gateway on the PC.
4 A small company wishes to provide e-mail accounts for its users. For insurance reasons the
7 company wants to ensure that proper mail retention policies are followed. The company wants to
ensure that all e-mail is backed up regularly, but it does not want the users to have to perform this
backup themselves. Which protocol would meet the needs of the company?
SSL
POP3
SMTP
IMAP4
50 At which layer of the OSI model is the Ethernet family of technologies defined?
Layer 1
Layer 2
Layer 3
Layer 4
Layer 5
Layer 6
Layer 7
5
1
Refer to the exhibit. What does the highlighted value 120 represent?
the number of hops between the router and network 10.0.5.0
the administrative distance of the routing protocol
the UDP port number that is used for forwarding traffic
the bandwidth that is allocated to the serial interface
52 A building has experienced a power outage. When the power returns, none of the devices on one floor
can access the Internet. The network administrator checks the switch in the IDF that these devices are
connected to and notes that the SYST LED on the front of the switch is amber.
All contents copyright 1992-2010 Cisco Systems, Inc. Privacy Statement and Trademarks