Anda di halaman 1dari 1

LACK OF FUSION (FUSI YANG TIDAK SEMPURNA)

Adalah cacat las yang disebabkan oleh karena tidak terjadi fusi atau penggabungan antara logam las dan
permukaan logam induk atau logam las disekitarnya.

Is defective weld caused by fusion or merger does not occur between weld metal and parent metal surface
or the surrounding weld metal.

Sketsa / sketch
Penyebab Langkah - Langkah Pencegahan
Root cause Counter measures
1. Kecepatan pengelasan terlalu tinggi. 1. Kurangi kecepatan pengelasan.
Welding speed to high Reduced welding speed

2. Jika dibandingkan dengan detail sambungan, 2. Gunakan elektroda yang sesuai dengan tebal
elektroda yang dipakai terlalu besar. logam induk yang dilas.
Compared with the joint detail, the Use a size of electrode
electrode or filler material used is corresponding to the parent
too large. metal to be welded.

3. Arus las terlalu rendah sehingga penetrasi busur 3. Naikkan arus las untuk menambah penetrasi
dangkal. busur.
Welding currents are too low so Raise current to increase
that the penetration of arc was too penetration arc welding
shallow.

4. Panjang busur tidak teratur. 4. Jaga panjang busur yang sesuai.


The length of the arc (the distance Maintain arc distance (the
between tungsten tip and base distance between the base metal
metal) was unstable. with tungsten tip) is stable.

5. Perencanaan sambungan yang tidak tepat ; root face 5. Rencanakan joint detail yang benar dengan
terlalu tebal atau root opening yang terlalu sempit. mempertimbang kan proses dan tebal material.
Joint design that was not . Make design a joint detail is right with it
appropriate; root face too thick or considering the process and material thickness.
root gap too narrow.

6. Fit-up / penyuaian sambungan tidak sesuai dengan 6. Lakukan fit-up sambungan sesuai dengan detail
detail yang telah dispesifikasikan pada welding detail. yang telah dispesifikasikan.
Fit-up of the connection was not in Perform fit-up connection in
accordance with details that have accordance with details that
been specified in the welding detail. have been specified

7. Arah busur tidak tepat. 7. Arahkan busur pada permukaan logam induk
The arc direction was not correct. atau logam las sebelumnya.
Point the arc on the surface of
the parent metal or weld metal

8. Ayunan (weaving) elektroda terlalu cepat. 8. Tahan / berhenti sesaat pada setiap ujung
The weaving of the electrode was ayunan untuk memberi kesempatan permukaan
to fast. logam induk atau logam las sebelumnya
mencair.
Hold / paused for a moment at
each end of the swing to allow
the surface of the parent metal or
weld metal is melting.

Anda mungkin juga menyukai