a. Class IV mod II
b. Class II mod I
c. Class I mod II
d. Class I mod I
a. an occlusal rest
b. cingulum rest
c. channel rest
d. distal rest
a. Kennedy class II
b. Kennedy Class I
c. Kennedy Class I mod I
d. Kennedy Class II mod I
a) The guide planes on #31 & #18 will act as retentive elements
b) Circumferential retentive clasps will be necessary on #31 & #18
c) The retentive clasps on # 21 & #29 should be wrought wire circumferential.
d) Indirect retention is required
a) indirect retention
b) direct retention
c) nailhead retention for tooth #5
d) acrylic retention for anterior teeth
15) For which indication given would this major connector be used?
a) Class I mod I
b) Class IV mod II
c) Class III mod II
d) Class II mod II
e) None of the above
ARTICULATOR (7)
19) On which side of the arch has adequate relief been provided under the acrylic retention
areas?
20) On which side of the arch is the position external finish line of the removable partial denture
the most correct?
21) Is the direct retainer on tooth #11 acceptable for this particular case?
22) If a removable partial denture is being fabricated for this patient, which of the following
direct retainers would be most indicated on tooth #29 with the rest as it is prepared?
(a) A cast circumferential clasp arm with 0.01" of undercut on the mesiobuccal,
with distal rest and distal guide plane.
(b) A cast "I" bar clasp into 0.01" of undercut in the mesio-buccal-gingival
quadrant, with mesial rest and distal guide plane.
(c) A wrought wire circumferential clasp into 0.02" of undercut in the mesiobuccal,
with distal rest and distal guide plane.
24) If a retentive clasp arm is placed on the buccal of tooth #29, then the retentive clasp arm
on #18 should be placed on .
a) The buccal
b) The lingual
c) Either the buccal or the lingual
d) Mesio-lingual
ARTICULATOR 9
a) Survey crowns should be done to correct the mesial tilt of the molars.
b) Retentive clasps are required next to each edentulous space.
c) The lingual plate would be the major connector of choice.
d) A dual path of insertion should be considered.
a) Major connector
b) Guide planes
c) Direct retainers
d) Indirect retainers
ARTICULATOR (10)
a) is too thin
b) is too close to the free gingival
margins of the teeth
c) is too thick
d) A & B
e) none of the above
Space
a) Guide planes
b) Indirect retainers
c) Acrylic retention areas
d) Direct retainers
e) All of the above
a) indistinct
b) would allow for acrylic to be
mechanically retained in the
framework.
c) too deep or over-contoured
a) class I
b) class III
c) class IV
a) minor connector
b) guide plane
c) reciprocating arm
d) retentive clasp arm
e) rest
a) Not necessary.
b) Mesial of tooth #28.
c) Distal of tooth #21.
a) Lingual bar
b) Lingual plate
c) Interrupted lingual plate
d) Labial bar
a) Palatal Strap
b) Anterio-posterior Palatal Strap
c) Palatal Plate