QUEST’11
9.If a current of 1 amp passes through a lamp for 100 seconds, the number of
coulombs of charge passing through the lamp in that time must be
1.10 coulombs 2.15 coulombs 3.100 coulombs 4. 0.01 coulombs
10. If emf in a circuit is given by e= 100 Sin628t, then the maximum value of
voltage and value of frequency are
1.100V,50Hz 2.100V,100Hz 3.50√2,50Hz 4.50√2,100Hz
11.Which of the following transformer will be smallest in size
1.10KVa 50Hz 2. 10KVa 60Hz 3. 10KVa 100Hz 4. 10KVa 200Hz
12.Which of the following are true for a 3 phase delta connected circuit
1.Line voltage=Phase voltage 2.Line current = Phase current
3.Line current = √3 phase current 4. Line voltage = 1/√3 phase voltage
13.A set of independent current measurements taken by four observers was
recorded as 117.02mA, 117.11mA,117.08mA and 117.03mA. What is the range of
error?
1.± 0.045 2. ± 0.054 3. ± 0.065 4. ± 0.056
14.Fleming’s right hand rule is applicable to
1.Generator 2.Motor 3.Transformer 4.None of these
15.The first power station operated by Edison is
1.AC 2.DC 3.Both AC & DC 4.None of these
16.The type of transmission used for sound in TV transmission is
1.AM 2.FM 3.PCM 4.PWM
17.What is NSEC?
1.National Safety Electrical Code. 2.National Society for Electrical & Computer.
3.National Society for Environmental Concern. 4.National Society of Engineering
Course.
18.What is maximum AC transmission voltage in india.
1.700KV 2.650KV 3.690KV 4.1200KV
19.The largest power plant in the world is located in
1. Congo 2.India 3.U.K. 4.China
20.The output of a logic gate is ‘1’ when all its input are at logic ‘0’. The gate is
either,
1. a NAND (or) an Ex-OR Gate 2. a NOR (or) an Ex-OR Gate
3. a NAND (or) an Ex-NOR Gate 4. a NOR (or) an Ex-Nor Gate
21.How many 1’s are present in the binary representation of 3x512+7x64+5x8+3?
1.8 2.9 3.10 4.11
22.As the temperature is increased, the voltage across a diode carrying a constant
Current
1. Increases 2. Decreases 3. Remains constant 4. May increase (or) decreases
depending upon the doping levels in the junction
23.Which one of the following oscillators is used for generation of light
frequencies.
1.R.C.Phase Shift 2.Wien bridge 3.L.C.oscillator 4.Blocking oscillator
24.A semiconductor that is electrically neutral
1. has no majority carriers 2. has no minority carriers
3. has no free charge carriers 4. has equal amount of +ve & -ve charges.
ANS:4
25.A multivibrator produces
1.Pure sine wave
2.Square waves
3.Distorted sine waves
4.Sawtooth voltages
ANS:3
26.The resistivity of semi-conductor
1. Increases as Temperature increases
2. Decreases as Temperature increases
3. remains constant even when temperature varies
4. None of the above
ANS:2
27. Which device automatically interrupts the supply in the event of surges
1.Earthing Switch
2.Series reactor
3.Isolator
4. Circuit breaker
ANS : 4
28.Vande Graaff generators are useful for
1. Very high voltage & low current applications
2. Very high voltage & high current applications
3. Constant high voltage & current applications
4. High voltage pulses only
ANS:1
29. A driver maintains the speed of a car at 50Kmph. Here the feedback element is
1.Steering wheel
2.Needle of the speedometer
3.Eyes
4.All of these
ANS:2
30.An automatic washing machine is
1. A single feedback control system
2. A multi feedback control system
3. An open loop control system
4. None of the above.
ANS: 3
31.Most suitable numerical method to solve electrostatic field problem is
1. Laplace equation method
2. Charge simulation method
3. Finite difference method
4. Resistance analog method.
ANS: 2
32. Tap changing transformers are used for
1. Stepping up the voltage
2. Stepping down the voltage
3. Both stepping up & stepping down the voltage
4. Supplying low voltage current for instruments
ANS: 3
33. Which of the following is not the distribution system normally used
1. 3-phase 4 wire
2. 3-phase 3 wire
3. Single phase 3 wire
4. Single phase 4 wire
ANS: 4
34. Skin effect depends on
1. Size of the conductor
2. Frequency of the current
3. Resistivity of the conductor material
4. All of the above
ANS: 4
35. Material generally used for bus bar is
1. Copper 2. Steel 3. Aluminium 4. Tungsten
ANS: 3
36. Example for piezo-electric material
(a) Rochelle salt (b) Lead zirconate (c) Potassium niobate (d) Barium Titanium
oxide
ANS: 2
37. Units for electric field strength
(a) A/cm2 (b) mho/meter (c) cm2/V.s (d) V/cm
ANS;3
38. The motor used in electric toys is
1.Split phase motor
2. Permanent capacitor motor
3.Shaded pole motor
4.Capacitor start motor
ANS:3
39. Moving coil in dynamometer wattmeter connected
a) In series with fixed coil
b) Across supply
c) In series with load
d) Across load
Ans: Both
42. Voltage feed back amplifier is a
a) Shunt-Shunt
b) Shunt-Series
c) Series-Shunt
d) Series- Series
Ans: Shunt-Shunt
43. The motor used in household refrigerators is
ANS:D
(C) bearings
45. In a hysteresis motor, the position of shaded pole with respect to main pole
determines
ANS:2
ANS:4
ANS:D
48. Any physical system which does not automatically correct for variation in
its output, is called ?
a) open loop system
b) closed loop system
c) unstable system
d) none of the above
ANS:(a)
49. open loop control system is one in which the control action ?
ANS:(b)
c) inductor d) SCR
ANS: C