However,
the communication between the two routers cannot be established. Based on the output of the commands,
what can be done to solve the problem?
Replace the serial cable .
Enable CDP on R2 so that the other routers will receive routing updates
Refer to the exhibit. Partial results of the show access-lists and show ip interface FastEthernet 0/1
commands for router Router1 are shown. There are no other ACLs in effect. Host A is unable to telnet to host
B. Which action will correct the problem but still restrict other traffic between the two networks?
Apply the ACL in the inbound direction.
using alternate paths to avoid access control lists and bypass security measures
encapsulating an entire packet within another packet for transmission over a network
Refer to the exhibit. A network administrator is attempting to configure a Frame Relay network. The administrator enters the comman
shown in the exhibit on R2, but the Frame Relay PVCs are inactive. What is the problem?
The incorrect DLCI numbers are being configured on R2.
A single router interface cannot connect to more than one Frame Relay peer at a time.
6 What will be the result of adding the command ip dhcp excluded-address 192.168.24.1 192.168.24.5 to the configuration of a l
router that has been configured as a DHCP server?
Traffic that is destined for 192.168.24.1 and 192.168.24.5 will be dropped by the router.
Traffic will not be routed from clients with addresses between 192.168.24.1 and 192.168.24.5.
The DHCP server will not issue the addresses ranging from 192.168.24.1 to 192.168.24.5.
The router will ignore all traffic that comes from the DHCP servers with addresses 192.168.24.1 and 192.168.24.5.
7 A network administrator uses the 3DES algorithm to encrypt traffic that crosses a VPN. Which VPN characteristic is being config
authentication
authorization
data integrity
data confidentiality
Refer to the exhibit. What can be concluded from the exhibited output of the debug ip nat command?
The 10.1.1.225 host is exchanging packets with the 192.168.0.10 host.
9 How many bits are reserved for host addresses in the IPv6 space?
8
16
24
32
64
10 Which IP address and wildcard mask would be used in an ACL to block traffic from all hosts on the same subnet as host
192.168.16.43/28?
access-list 10 deny 192.168.16.0 0.0.0.31
11 What functionality do access control lists provide in the implementation of dynamic NAT on a Cisco router?
define which addresses can be translated
PPP
HDLC
SLIP
Refer to the exhibit. All devices are configured as shown in the exhibit. PC1 is unable to ping the default gateway. What is the cause o
problem?
The default gateway is in the wrong subnet.
STP has blocked the port that PC1 is connected to.
14 An administrator learns of an e-mail that has been received by a number of users in the company. This e-mail appears to come f
office of the administrator. The e-mail asks the users to confirm their account and password information. Which type of security t
does this e-mail represent?
cracking
phishing
phreaking
spamming
15 Which data link layer encapsulation protocol is used by default for serial connections between two Cisco routers?
ATM
Frame Relay
HDLC
PPP
SDLC
16 A network administrator has changed the VLAN configurations on his network switches over the past weekend. How can the
administrator determine if the additions and changes improved performance and availability on the company intranet?
Conduct a performance test and compare with the baseline that was established previously.
Interview departmental secretaries and determine if they think load time for web pages has improved.
Determine performance on the intranet by monitoring load times of company web pages from remote sites.
Compare the hit counts on the company web server for the current week to the values that were recorded in previous week
Refer to the exhibit. A network administrator is trying to connect R1 remotely to make configuration changes. Based on the exhibited
command output, what will be the result when attempting to connect to R1?
failure to connect due to Telnet not being enabled
a successful connection but inability to make configuration changes because of the absence of an enable secret password
18 What are two effective measures for securing routers? (Choose two.)
Protect all active router interfaces by configuring them as passive interfaces.
19 A network technician analyzes the network and notices late collisions. The collisions occur accompanied by jabber that originate
the server. What is the likely cause of the problem?
faulty switch port
web server CPU overload
20 Which Frame Relay flow control mechanism is used to signal routers that they should reduce the flow rate of frames?
DE
BE
CIR
FECN
CBIR
Refer to the exhibit. What is the meaning of the term dynamic in the output of the command?
The bandwidth capability of the interface increases and decreases automatically based on BECNs.
The mapping between DLCI 100 and 172.16.3.1 was learned through Inverse ARP.
DLCI 100 will automatically adapt to changes in the Frame Relay cloud.
22 A network administrator is instructing a technician on best practices for applying ACLs. Which suggestion should the administrato
provide?
Named ACLs are less efficient than numbered ACLs.
Extended ACLs should be applied closest to the source that is specified by the ACL.
23 Which technology is used to dynamically map next hop, network layer addresses to virtual circuits in a Frame Relay network?
Inverse ARP
LMI
DLCI
FECN
Refer to the exhibit. Headquarters is connected through the Internet to branch office A and branch office B. Which WAN technology w
best suited to provide secure connectivity between headquarters and both branch offices?
ATM
VPN
ISDN
Frame Relay
broadband DSL
25 Which option correctly defines the capacity through the local loop guaranteed to a customer by the service provider?
BE
DE
CIR
CBIR
26 Which combination of Layer 2 protocol and authentication should be used to establish a link without sending authentication inform
in plain text between a Cisco and a non-Cisco router?
PPP with PAP
27 A network administrator is tasked with maintaining two remote locations in the same city. Both locations use the same service pr
and have the same service plan for DSL service. When comparing download rates, it is noticed that the location on the East side
has a faster download rate than the location on the West side of town. How can this be explained?
The West side has a high volume of POTS traffic.
28 Which two statements are true about IPv6 link local addresses? (Choose two.)
They begin with the 2000::/3 prefix.
29 Where does a service provider assume responsibility from a customer for a WAN connection?
local loop
demarcation point
demilitarized zone
30 When would the multipoint keyword be used in Frame Relay PVCs configuration?
when global DLCIs are in use
Refer to the exhibit. A network administrator configures a standard access control list on Router1 to prohibit
traffic from the 192.168.0.0/24 network from reaching the Internet. The access control list also permits traffic
from the 192.168.0.0/24 network to reach the 192.168.1.0/24 network. On which interface and in which
direction should the access control list be applied?
interface Fa0/0, inbound
33 While troubleshooting a problem with an e-mail server, an administrator observes that the switch port used by the server shows "
protocol up". The administrator cannot ping the server. At which layer of the OSI model is the problem most likely to be found?
application layer
network layer
physical layer
34 An issue of response time has recently arisen on an application server. The new release of a software package has also been in
on the server. The configuration of the network has changed recently. To identify the problem, individuals from both teams respo
for the recent changes begin to investigate the source of the problem. Which statement applies to this situation?
Scheduling will be easy if the network and software teams work independently.
It will be difficult to isolate the problem if two teams are implementing changes independently.
Results from changes will be easier to reconcile and document if each team works in isolation.
Only results from the software package should be tested as the network is designed to accommodate the proposed softwar
platform.
Refer to the exhibit. This serial interface is not functioning correctly. Based on the output shown, what is the most likely cause?
improper LMI type
interface reset
unplugged cable
36 A company is looking for a WAN solution to connect its headquarters site to four remote sites. What are two advantages that ded
leased lines provide compared to a shared Frame Relay solution? (Choose two.)
reduced jitter
reduced costs
reduced latency
the ability to borrow unused bandwidth from the leased lines of other customers
Refer to the exhibit. R1 is performing NAT overload for the 10.1.1.0/24 inside network. Host A has sent a packet to the web server. W
the destination IP address of the return packet from the web server?
10.1.1.2:1234
172.30.20.1:1234
172.30.20.1:3333
192.168.1.2:80
38 Which three guidelines would help contribute to creating a strong password policy? (Choose three.)
Once a good password is created, do not change it.
Write passwords in locations that can be easily retrieved to avoid being locked out.
Use long words found in the dictionary to make passwords that are easy to remember.
NCP tests the link to ensure that the link quality is sufficient.
40 When Frame Relay encapsulation is used, what feature provides flow control and exchanges information about the status of virtu
circuits?
LCP
LMI
DLCI
Inverse ARP
Refer to the exhibit. Which statement correctly describes how Router1 processes an FTP request that enters
interface s0/0/0 and is destined for an FTP server at IP address 192.168.1.5?
The router matches the incoming packet to the statement that was created by the access-list 201 deny
icmp 192.168.1.0 0.0.0.255 any command, continues comparing the packet to the remaining statements
in ACL 201 to ensure that no subsequent statements allow FTP, and then the router drops the packet.
The router reaches the end of ACL 101 without matching a condition and drops the packet because there
is no statement that was created by the access-list 101 permit ip any any command.
The router matches the incoming packet to the statement that was created by the access-list 101 permit
ip any 192.168.1.0 0.0.0.255 command and allows the packet into the router.
It matches the incoming packet to the statement that was created by the access-list 201 permit ip any
any command and allows the packet into the router.
Refer to the exhibit. From the output of the show interfaces and ping commands, at which layer of the OSI model is a fault indicated
application
transport
network
data link
physical
43 Which IEEE 802.16 broadband wireless technology allows users to connect to the ISP at speeds comparable to DSL and cable?
Wi-Fi
satellite
WiMAX
Metro Ethernet
Refer to the exhibit. Every time the administrator reboots this router, the boot process ends in setup mode. What is a possible problem
There is insufficient RAM for the IOS to load on this router.
The bootstrap version and the version of the IOS are different.
The IOS image is damaged and must be reloaded using tftpdnld.
45 Which configuration on the vty lines provides the best security measure for network administrators to remotely access the core ro
headquarters?
Refer to the exhibit. Results of the show vlan and show vtp status commands for switches S1 and S2 are displayed in the exhibit. V
was created on S1. Why is VLAN 11 missing from S2?
There is a Layer 2 loop.
The VTP domain names do not match.
48 Compared with IDS systems, what can IPS systems do to provide further protection of computer systems?
detect potential attacks
Refer to the exhibit. The corporate network that is shown has been assigned network 172.16.128.0/19 for use at branch office LANs.
is used, what mask should be used for addressing hosts at Branch4 with minimal waste from unused addresses?
/19
/20
/21
/22
/23
/24
50 An administrator is configuring a dual stack router with IPv6 and IPv4 using RIPng. The administrator receives an error message
trying to enter the IPv4 routes into RIPng. What is the cause of the problem?
When IPv4 and IPv6 are configured on the same interface, all IPv4 addresses are over-written in favor of the newer techno
51 Which type of ACL will permit traffic inbound into a private network only if an outbound session has already been established bet
the source and destination?
extended
reflexive
standard
time-based
Refer to the exhibit. A host connected to Fa0/0 is unable to acquire an IP address from the DHCP server. The
output of the debug ip dhcp server command shows "DHCPD: there is no address pool for 10.1.1.1". What is
the problem?
The 10.1.1.1 address is already configured on Fa0/0.
The default router for the 10Network pool is incorrect.
The ip helper-address must be added to Fa0/0 interface.