INSTALLATION
INSTRUCTIONS DESCRIPTION: OUTBACK WHEEL ARCH MOLDING
KIT CONTENTS:
A. B. C. D.
Left Front Molding x 1 Right Front Molding x 1 Left Rear Molding x 1 Right Rear Molding x 1
E. F. G. H. I.
Plastic Tab Plastic Clip x 2 #14 3/4" Truss Two Piece Clamp #10 5/8" Truss
x 16 Head Screw x 2 Clip x 12 Head Screw x 12
J. K.
TOOLS REQUIRED:
#2 Stubby Phillips or Grease Pencil Drill with 1/4” Drill Needle Nose
Ratcheting Screwdriver Bit and Drill Stop Pliers
Surface Preparation
1 Make sure that all installation surfaces (shown below) are clean, free of dirt, grease, and
debris. If necessary, use a clean, lint-free cloth and alcohol based cleaner. Inspect vehicle
for damage before installation of body kit.
REAR
FRONT
FRONT
6 Remove screw installed in Step 4 and 7 Fold supplied Plastic Tab in half. Peel liner
remove molding from fender. and center Tab over each mark made in
Step 5, folding over edge of fender lip (3
places). Place a second tab over circled
area so there are two tabs at this location.
FRONT
G
E
8 Slide supplied two piece Clamp Clip onto 9 Position molding on fender.
Plastic Tab (3 places).
FRONT
I I
I
FRONT
12 Pushing up and in on molding, use a 13 Pull molding back then use drill with 1/4”
grease pencil to mark one Metal “U” Clip drill bit to drill hole in bumper on mark
location on fender. made in Step 12.
FRONT
14 Install supplied Metal “U” Clip over hole 15 Install supplied #8 Pan Head Screw
drilled in Step 13, flat side facing wheel through molding and into Metal “U” Clip
well, without removing molding. installed in Step 14. Do not tighten.
FRONT
FLAT SIDE
K
J FRONT
FLAT SIDE
K
J
REAR REAR
K
REAR REAR
21 Fold supplied Plastic Tab in half. Peel liner 22 Slide supplied two piece Clamp Clip onto
and center Tab over each mark made in Plastic Tab (3 places).
Step 19, folding over edge of fender lip (3
places). Place a second tab over area so
there are two tabs at this location.
REAR
REAR
25 Install supplied #10 Truss Head Screws 26 Ensure that molding is properly positioned
through holes in molding and into Clamp on fender. Apply pressure at each
Clips installed in Step 22. Do not tighten. fastening point, and tighten all screws.
Repeat Step 17 – Step 26 for other side.
REAR
I I I