6.2
1.8 1.8
0.2
0.35 0.15
1.65
1.3
0.35
Properties of materials
since tension is on water face, the design has to be done on basis of uncracked section.
A 6.3
2.1
A
1.8 2.6 1.8
PLAN OF THE WATER TANK
2.5
0.12
1.65
2.1 0.2
0.35
0.3
SECTION A-A
Properties of materials
Edge condition used for design purpose is tank with walls hinged at top & bottom.
The table 6 of IS:3370 (Part 4) corresponds to these edge conditions.
2.30 E
C A
1.86
F
4.30 D B
BENDING MOMENT
-ve sign means bending moment causing tension on inner face of wall
+ve sign means bending moment causing tension on outer face of wall
Mh = horizontal moment = My * w * a 3
Mv = vertical moment = Mx * w * a 3
SHEAR FORCE
Material
Dimensions
2525
3100
325
Loads
Lx 2.53 m
Ly 3.10 m
Ly / Lx 1.23
Since Moment produce tension on water face thickness of concrete from point of view of cracking is given below
Material
Dimensions
2525
6200
200
Loads
Lx 2.53 m
Ly 6.20 m
Ly / Lx 2.46
Condition
using table no 27 of IS456:2000
Mx My
+ve -ve +ve -ve
Design
deff 170 mm 160 mm
Ast Prov.
Dia 10 10
Spacing 100 100
Ast 785 785
p% 0.39 0.39
p% min 0.12 0.12
OK OK
Mu, lin
Conc 95.9 kN-m 84.9 kN-m
Steel 52.7 kN-m 49.3 kN-m
Deflection Check