Isolasi Dan Pemisahan Senyawa Alkaloid Dari Buah M
Isolasi Dan Pemisahan Senyawa Alkaloid Dari Buah M
Isolasi Dan Pemisahan Senyawa Alkaloid Dari Buah M
net/publication/321221577
CITATION READS
1 12,106
3 authors, including:
SEE PROFILE
Some of the authors of this publication are also working on these related projects:
Antioxidant Activity of Pidada (Sonneratia caseolaris (L.) Engl.) Fruit Extract by DPPH Method View project
All content following this page was uploaded by Sari Defi Okzelia on 26 January 2018.
ABSTRACT
High Performance Liquid Chromatography (HPLC) is a modern separation method that could be used for
separating, purifying and determining the composition of chemical compound. Alkaloid is one of secondary
metabolite compounds which has function as natural medicine. Mahkota Dewa (Phaleria macrocarpa Boerl.) is
usually used by the native as traditional medicine. This research aimed to isolate and separate alkaloid compounds
from fruit of Mahkota Dewa using HPLC method. Fruit of Mahkota Dewa was cut into small pieces, dried, then
macerated with methanol. Concentrated methanol extract was acidified with hydrochloric acid to pH 2-3 then
extracted with dichloromethane-water (1:3). Acidic water fraction then basified and extracted again with
dichloromethane-water (1:3). Each of fractions was always tested with Dragendorff reagent and thin layer
chromatography to prove the existence of alkaloid. Separation using HPLC was done for basic dichloromethane
fraction using C18 (RP-18e) column, isocratic elution with mobile phase 10% acetonitrile and 90% sodium
dihydrogen phosphate in water (pH 3) for 20 minutes. Alkaloids in basic dichloromethane fraction were found six
components. Conventional column chromatography was prepared in order to get purer components , using silica
gel G60 and 2.5% gradien of chloroform-methanol as eluent. Fraction 3 of 41 fractions, which assumed containing
standard alkaloid, was fractioned by conventional column chromatography again using ODS and methanol-water
(7:3) as eluent. Separation by HPLC was done again for fraction 2 and 3 of 20 fractions. The results showed that
alkaloid in Mahkota Dewa could be separated using HPLC and obtained two components in fraction 2 and fraction
3 with good resolution but according to the retention time, those alkaloids are not the standard alkaloid used
(atropin).
ABSTRAK
Kromatografi cair kinerja tinggi (KCKT) merupakan metode pemisahan modern yang dapat digunakan untuk
pemisahan, pemurnian dan penentuan kadar senyawa. Alkaloid merupakan senyawa metabolit sekunder yang
berfungsi sebagai bahan obat alami. Tumbuhan mahkota dewa (Phaleria macrocarpa Boerl.) banyak digunakan
sebagai obat tradisional oleh masyarakat. Penelitian ini bertujuan untuk mengisolasi dan memisahkan senyawa
alkaloid yang terdapat dalam buah mahkota dewa dengan metode KCKT. Buah mahkota dewa dipotong kecil-kecil,
dikeringkan, lalu dimaserasi dengan metanol. Ekstrak metanol pekat diasamkan dengan asam klorida 1% sampai pH
2-3 kemudian diekstraksi dengan diklorometana-air (1:3). Fraksi air yang telah diasamkan tersebut dibasakan
dengan amonium hidroksida sampai pH 9-10 kemudian diekstraksi lagi dengan diklorometana-air (1:3). Masing-
masing fraksi selalu diuji kualitatif dengan pereaksi Dragendorff untuk mengetahui keberadaan alkaloidnya juga
dengan kromatografi lapis tipis. Terhadap fraksi diklorometana basa dilakukan pemisahan dengan KCKT
menggunakan kolom C18 (RP-18e) dan dielusi secara isokratis menggunakan fase gerak 10% asetonitril dan 90%
larutan kalium dihidrogen fosfat 0,05 M dalam air (pH 3) selama 20 menit. Senyawa alkaloid yang terkandung
dalam fraksi diklorometana basa pekat diperoleh enam komponen. Untuk lebih memurnikan alkaloid dilakukan
fraksinasi dengan kromatografi kolom klasik menggunakan silika gel G60 dan eluen kloroform-metanol bergradien
2,5%. Fraksi 3 (dari 41 fraksi) yang diduga merupakan senyawa alkaloid standar difraksinasi lagi menggunakan
ODS dengan eluen metanol-air (7:3). Terhadap fraksi 2 dan 3 (dari 20 fraksi) dilakukan kembali pemisahan dengan
KCKT. Dari hasil penelitian didapatkan bahwa senyawa alkaloid dalam buah mahkota dewa dapat dipisahkan
PENDAHULUAN