Prerequisites
Context
When the VC12/VC3 trail transits multiple VC4 server trails, the consistency of VC4
timeslot used by each server trail is not required, but the T2000 automatically uses the
server trails that use the same VC4 timeslot if possible.
Procedure
1. Choose Trail > SDH Trail Creation from the Main Menu.
2. Set the service direction and the level to VC12 or VC3.
3. Set the resource usage strategy to Protected Resource and the protection
priority strategy to SNCP First.
NOTE:
NOTE:
o If you do not assign the timeslot, the first available timeslot is selected
automatically.
o If multiple trails are selected, right-click them and choose Uniform
Timeslot. T2000 consider the timeslot value of the trail in the first row
as the datum value and modify the timeslot values of other trails to be
consistent with the datum value. In this way, all trails use the same
timeslot.
9. Click the SNCP setting tab.
o Right-click the dual-fed point and choose Set Dual-Fed Point, and the
node is displayed as . Right-click the selective-receiving point and
choose Set Selective-Receiving Point, and the node is displayed as .
o Right-click the area in the tab and choose Add from the shortcut menu.
In the Add the dual-fed and selective-receiving node displayed, select
Dual-Fed Point and Selective-Receiving Point. Click OK.
10. Optional: If the trail passes through the ASON, you can check the Select
ASON Server Trail First check box. Click the ASON Attributes Settings tab
and set the corresponding protection attributes.
11. Click the General Attributes tab and set the general attributes of the trail, such
as the Name and Order No..
12. Optional: If you do not want to activate the created trail when the configuration
is issued to NEs, you can uncheck the Activate the trail check box.
NOTE:
o If you activate a trail, the service configuration data of the trail is sent to
the NE.
o If you do not activate a trail, the service configuration data of the trail is
stored at the NE layer on the T2000.
13. Optional: Check the Alarm Reversion check box to set the alarm reversion on
the trail to be created.
14. Optional: If you want to create multiple trails with the same route, check the
Copy after Creation check box. After the creation of the trail, a dialog box is
displayed and you can copy the trail.
15. Click Apply. In the Operation Result dialog box displayed, click Close.